2001 Buick Regal

BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

On [XXX], my son drove the car to Wendy’s to get lunch around 12:30 pm. He returned, parked the car in the driveway. My son entered the house and while we were eating lunch the doorbell rang, it was the police informing us that my car was on fire in the driveway. The fire department was called and they eventually extinguished the fire which started under the hood of the car. The jaws of life were used to cut the hood of the car loose to fully extinguish the fire. The car is destroyed. There is no fixing it. Marion, Virginia Fire Department extinguished the fire and stated that a report could be obtained but they were positive the fire started in the engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11569322

Incident

Feb 1, 2024

The 2001 buick regal that we have has very inadequate head lights as far as im concerned it is a wiring problem dims are so dim that it's like you have no head lights at all bright are just bright enough to almost see 50 to 100 feet in front of vehicle also this buick is not the only gm vehicle I have experienced this on the 98 buick century's have same head light problem some what worse though also our 2002 chevy venture van has same extremely dim dims on all three vehicles brights are substituted for dims I have tried to rimity the problem by cleaning oxidation from lenses also replacing head lamp bulbs on one vehicle lenses had condensation inside lenses replaced both lenses but the results were same extremely dim dims and still had to substitute brights for dims to see also thought batterie might be getting weak both van and buick have new batteries and alternator on Both are charging strong and to specification so after all that still have head lamp problem no worse no better

NHTSA ID

11461416

Incident

Apr 19, 2022

I have a buick.regal go 3.8 was just notified about recall for under hood fire I have not had this happen yet but I have been a mechanic for.8 years and from what I've seen with my 3.8 and others I have worked on it's not just only the front valve cover and gasket I have noticed that on mine I had oil pooling from lower intake manifold onto transmission also same thing on right hand side of engine the intake leaks oil were the factory uses the silicone form a gasket when sealant goes bad the oil pools on top of transmission and on right the oil pools on top of the timing cover /water pump housing so I think just replacing the front valve cover is not an adequate fix when you have two ends of lower intake leaking oil and also rear valve cover leaking the rear may not be as big of fire hazard but those intake leaks were they pool could very well poor that pooled oil onto front exuast manifold and or crossover pipe when a had break is applied to vehicle

NHTSA ID

11461414

Incident

Nov 14, 2021

My car lit on fire under the hood

NHTSA ID

11440472

Incident

Oct 27, 2021

HAD A FRONT TIRE BLOW OUT CAR WENT ACROSS THE ROAD DOWN INTO SMALL DITCH AND STOPPED TO HIT A MAILBOX RESULTING IN THE AIRBAGS DEPLOYING THE PASSENGER SIDE AIRBAG CAME OUT SO HARD THAT IT BROKE THE WINDSHIELD DRIVER SIDE AIRBAG CAME OUT AND RESULTED IN IT BREAKING MY SPINE I'VE HAD TO HAVE ONE SURGERY SINCE THEN AND MAYBE MORE

NHTSA ID

11359843

Incident

Aug 15, 2020

Mileage

178,000 mi

TL* THE CONTACT OWNED A 2001 BUICK REGAL. WHILE THE VEHICLE WAS IDLING FLAMES APPEARED FROM UNDER THE HOOD. NO INJURIES WERE REPORTED. THE CAUSE WAS UNDETERMINED. THE CONTACT STATED THAT WHILE PARKED WITH THE ENGINE ON FLAMES WERE SUDDENLY PRESENT COMING FROM UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. A FIRE DEPARTMENT AND POLICE DEPARTMENT REPORTS WERE TAKEN AT THE SCENE. THE VEHICLE WAS DESTROYED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VIN LOOK UP INDICATED THAT THE VEHICLE WAS INCLUDED IN THE NHTSA RECALL CAMPAIGN: 15V701000 (ENGINE AND ENGINE COOLING). THE CONTACT INDICATED THAT THE VEHICLE HAD EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 100,000.

NHTSA ID

11322853

Incident

Apr 14, 2020

Mileage

100,000 mi

LOSING OIL NOT VISIBLE, APPEARS TO BE VALVE COVER GASKET, OIL PAN, HOSE. ADDING A QUART A MONTH.

NHTSA ID

11321881

Incident

Jan 12, 2020

RECALL FIXED THE FRONT VALVE COVER AND THE REAR ONE SHOULD OF BEEN DONE ALSO DUE TO THE LEAKING OF OIL THAT COULD POTENTIALLY START A FIRE FROM LEAKING ON THE BLOCK AND POSSIBLY BURN ON THE EXHAUST MANIFOLD.

NHTSA ID

11316888

Incident

Feb 1, 2020

Mileage

175,000 mi

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.