1998 Buick Regal

GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.

GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

On my way home from purchasing the vehicle, the car began to lose power and i noticed black smoke though the rear view mirror. Another driver signaled me down, so I pulled over and realized my car was on fire. The fire was in the engine compartment from what appeared to be the exhaust manifold. Since i was in a residential area, i grabbed a water hose and began to diffuse the fire. The fire department arrived and forced my hood open to reassure the fire was out. Luckily i was able to make it out safe. But i strongly believe my life and the lives of other drivers were definitely in danger

NHTSA ID

11455963

Incident

Mar 4, 2022

The contact owns a 1998 Buick Regal. The contact stated that the vehicle would not start. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 317,000.

NHTSA ID

11430527

Incident

May 5, 2021

Mileage

317,000 mi

EVERY TIME I TURN ON MY LEFT OR RIGHT TURN SIGNAL IT SHORTS OUT.... TOOK TO A MECHANIC AND HE DID SOME RE WIRING AND IT WORKED FOR A LITTLE BIT THEN STARTED TO HAPPEN AGAIN.... I DON'T WANT TO SPEND A BUNCH OF MONEY ON IT ANYMORE. WHAT SHOULD I DO?

NHTSA ID

11384503

Incident

Mar 14, 2020

Mileage

230,000 mi

TL* THE CONTACT OWNED A 1998 BUICK REGAL. THE CONTACT STATED WHILE HER HUSBAND WAS IDLE AT A GUARD SHAFT, WHEN SHE SAW SMOKE COMING FROM THE HOOD OF THE VEHICLE. THE DRIVER MOVED FORWARD AWAY FROM THE GUARD SHAFT AND PARKED THE VEHICLE. THE CONTACT STATED NO WARNING LIGHTS WERE ILLUMINATED. THE CONTACT STATED HER HUSBAND OPENED THE HOOD AND SAW FIRE COMING FROM THE ENGINE. THE CONTACT STATED THE GUARD PROVIDED A FIRE EXTINGUISHER TO HER HUSBAND TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT WAS CONTACTED AND A COMPLAINT WAS FILED. THE VEHICLE WAS TOWED TO IMPOUND LOT. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED AS OF YET. THE CONTACT STATED SHE RECEIVED RECALL LETTER NHTSA CAMPAIGN NUMBER: 09V116000 (ENGINE AND ENGINE COOLING) AFTER THE FAILURE. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11240685

Incident

Jul 5, 2019

TL* THE CONTACT OWNS A 1998 BUICK REGAL. THE CONTACT STATED THAT THE ENGINE WARNING INDICATOR CONTINUED TO RANDOMLY FLASH. ALSO, ONCE THE VEHICLE WAS STARTED, THE ENGINE WOULD MISFIRE AND THE VEHICLE WOULD OVERHEAT. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 09V116000 (ENGINE AND ENGINE COOLING) AND 99V356000 (EXTERIOR LIGHTING), BUT THE CONTACT WAS UNCERTAIN IF THE FAILURES WERE RELATED TO THE RECALLS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11098814

Incident

Feb 1, 2016

TL* THE CONTACT OWNS A 1998 BUICK REGAL. THE CONTACT STATED THAT OIL WAS LEAKING ONTO THE REAR EXHAUST MANIFOLD AND SPARK PLUGS. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE DEALER WAS NOT CALLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

NHTSA ID

11082173

Incident

Aug 16, 2016

Mileage

135,000 mi

THE ELECTRICAL SYSTEM ON THE DRIVERS FRONT DOOR IS FAULTY I WENT THROUGH THREE MASTER WINDOW SWITCH'S AND STILL SOMETHING WRONG. THE CRUISE CONTROL HAS FAULT EVEN AFTER SOME SENSORS REPLACED. AND THE DIGITAL ODOMETER DISPLAY QUIT WORKING BUT THE REST OF THE GAUGES STILL WORK THE ODOMETER QUIT SHOWING AFTER 115K. THE DRIVER SIDE ELECTRICAL QUIT WORKING ONE DAY WHILE DRIVING ON THE HIGHWAY, THE NEW MASTER SWITCH WHEN YOU PRESS THE BUTTON IT UNLOCKS AND LOCKS THE DOORS. THE CRUISE CONTROL QUIT WORKING IN OR AROUND 98K MILES. AND THE DIGITAL ODOMETER AND THE OTHER DIGITAL SCREEN STARTED TO FADE AND EVENTUALLY JUST STOPPED SHOWING AFTER 115K MILES.

NHTSA ID

11055099

Incident

Sep 12, 2017

CAR HAS BECOME VERY HARD TO TURN, UNLESS MOVING.

NHTSA ID

11006534

Incident

Jan 12, 2017

Mileage

87,000 mi

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.