2001 Mitsubishi Galant

IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.

TL* THE CONTACT OWNS A 2001 MITSUBISHI GALANT. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE THE TRANSMISSION HAD MALFUNCTIONED AND THE VEHICLE WOULD NOT OPERATE IN THE DRIVE AND REVERSE POSITION. IN ADDITION, THERE WAS A LEAKAGE AND SMOKE WAS ALSO PRESENT COMING FROM UNDER THE VEHICLE. THE CONTACT INDICATED THAT THE FAILURE WOULD ONLY OCCUR WHEN ENGINE TEMPERATURE WAS HEATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION WAS FAULTY AND NEEDED TO BE REPLACED. THE CONTACT INDICATED THAT THE TRANSMISSION HAD PREVIOUSLY EXPERIENCED THE SAME FAILURE AND WAS REPLACED IN 2013. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 220,000.

NHTSA ID

11296677

Incident

Dec 1, 2019

Mileage

220,000 mi

THE INTAKE MANIFOLD CRACKED IN AUG 2014 SO I BOUGHT ONE AND REPAIRED IT AND CHANGED THREE MOTOR AND TRAIN MOUNTS DROVE FOR TWO MONTHS AND CRACKED AGAIN RIGHT BEHIND THE THROTTLE BODY IT STARTED STALLING WHEN COME TO A STOP ROUGH IDLE.

NHTSA ID

10819104

Incident

Aug 15, 2015

Mileage

160,000 mi

I HAD ISSUES WITH MY DRIVER SIDE SEAT FOR YEARS AND CURRENTLY STILL AN ISSUE. I NEVER REALIZED THIS WAS A RECALL ISSUE. I HAD A NUMBER OF ISSUE/PROBLEMS WITH MY VEHICLE AND ALWAYS TOOK MY CAR TO THE MITSUBITSHI DEALER AND THEY TOO NEVER MENTIONED ANY RECALL REGARDING DRIVER SIDE SEAT. THE DRIVER'S SEAT IS NOT PROPERLY SECURE THE SEAT AND COULD INCREASE THE RISK OF DRIVER INJURY IN AN ACCIDENT.

NHTSA ID

10722190

Incident

May 4, 2002

WHEN STARTING OUT, THE GAS PEDAL STICKS. THIS STARTED WHEN OUR TEMPERATURE WAS VERY COLD FOR A FEW DAYS. MY VEHICLE IS ALWAYS PARKED IN THE GARAGE OVERNIGHT. *TR

NHTSA ID

10700590

Incident

Feb 3, 2015

Mileage

92,000 mi

PROBLEM CODES WRONG WITH MY CAR. P0431 P0174 P0176 OR P0171 P0441 P0335 P0300. *TR

NHTSA ID

10679585

Incident

Jan 28, 2015

Mileage

13,000 mi

I HAVE HAD REPEATED INCIDENTS WHERE MY HORN WILL SOUND DURING THE NIGHT, AND IF I WAS USING IT AS A WARNING TO ANOTHER DRIVER. I HAVE HAD IT CHECKED SEVERAL TIMES, AND I WAS FINALLY TOLD THAT THE AIRBAG IS PROBABLY WHAT IS CAUSING THE PROBLEM. NOW MY HORN DOESN'T SOUND AT ALL AND THIS POSES A SAFETY HAZARD TO ME, MY CHILDREN AND ANY OTHER PASSENGERS AS WELL AS OTHER DRIVERS AND PEDESTRIANS. *TR

NHTSA ID

10649656

Incident

Aug 9, 2014

Mileage

98,000 mi

THERE IS A MAJOR GAS IN MY CAR. THE SPELL IS THERE 100% OF THE TIME. WHEN YOU COME WITHIN 20 FEET OF THE CAR...YOU GET THE OVERWHELMING GAS SPELL. I'M AFRAID TO DRIVE THE CAR AT ALL NOW. I'M A SINGLE FATHER ON FULL DISABILITY, WITH A 16 YEAR OLD DAUGHTER WITH NO MOTHER. I CAN'T AFFORD THE GAS WHICH DOUBLED DUE TO THE GAS LEAK. MORE IMPORTANTLY...I CAN'T DRIVE MY DAUGHTER TO SCHOOL...ANYWHERE. *TR

NHTSA ID

10628602

Incident

Jun 17, 2014

Mileage

125,000 mi

THIS CAR HAS HAD A PROBLEM WITH THE O2 SENSORS, FUEL LINE, OIL LEAKS, FUSE AND ELECTRICAL SHORTS FROM THE START. WE HAVE TRIED TO FIX THE PROBLEMS, BUT THE REPAIRS NEVER LASTED LONG. THE BRAKE LINE RECENTLY STARTED LEAKING. TODAY WE WERE IN A WRECK BECAUSE THE BRAKES WENT OUT. WE WERE TRAVELING AT 35 MPH AND SHOULD HAVE HAD TIME TO STOP. THE CAR SLID UNDER A TRUCK, AND WAS TOTALED. WE WERE NEVER CONTACTED ABOUT ANY RECALLS INVOLVING OUR CAR. *TR

NHTSA ID

10587638

Incident

May 10, 2014

Mileage

250,000 mi

This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023.

This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue.

This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross vehicle weight rating (GVWR) or 100 lbs.

This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 2nd quarterly technician quiz for 2023.

This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.

This is a service newsletter (Tech Talk) that was sent out to dealers.