1998 Plymouth Grand Voyager Owner Complaints

I WAS DRIVING AND THE WHOLE DASH PANEL WENT OUT, GAS, SPEED , HORN GAUGES

NHTSA ID

11192209

Incident

Mar 3, 2019

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. WHILE DRIVING AT VARIOUS SPEEDS, THE HORN FAILED TO FUNCTION AND THE AIR BAG LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE CLOCK SPRING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10875916

Incident

Jun 22, 2016

Mileage

100,000 mi

AT CERTAIN TIMES THE SERPENTINE BELT WILL SLIP OFF OF THE PULLEYS AND QUIT POWERING THE ALTERNATOR, WATER PUMP, AND POWER STEERING PUMP. THIS CAN BE WORSENED BY RAINY CONDITIONS. CHANGING BELT TENSIONER WORKS FOR A YEAR OR TWO.

NHTSA ID

10787840

Incident

Nov 2, 2015

Mileage

180,000 mi

THE DASH PANEL DIES AND THE ABS LIGHT TURNS ON FOLLOWED BY THE CHECK ENGINE LIGHT DUE TO THE COMPUTER THROWING A CODE. I HAVE REMOVED THE DASH PANEL THREE TIMES AND FOUND THE PROBLEM IS AT THE FEMALE PLUG ON THE BACK OF THE PANEL, BY USING A WIGGLE TEST. THE DEALER WANTED $250.00 FOR WHAT THEY CLAIMED ONLY HAD ON CIRCUIT PANEL WHEN I KNEW BETTER. IT HAS TWO. I REPAIRED IT BY USING A STRONG ZIP TIE TO HOLD THE PLUG UP. THIS WORKED FOR YEARS. NOW IT'S THE SAME OLD PROBLEM BUT IT IS NO LONGER ON AND OFF DEPENDING ON THE TEMP.OF THE INSIDE OF THE VEHICLE. IT IS 100% DEAD SO NOW HERE I GO AGAIN. TAKE THE DASH APART AND TRY TO GET IT TO FUNCTION. I USE MY GPS FOR MILAGE, SPEED, AND FUEL. THAT AND A USB LIGHT MADE FOR A PC. I HAVE DELT WITH THE FAULTY TENSHIONER AND SERPENTINE BELT PROBLEM TWICE. NOW IT IS ALL THE RELAYS FROM HEAT BURNT OUT. IT STARTED WITH THE STARTER RELAY AND WENT SOUTH. TAIL LIGHTS AND SO ON.

NHTSA ID

10734807

Incident

Jul 1, 2013

Mileage

100,000 mi

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH ATTEMPTING TO ACCELERATE, THE VEHICLE FAILED TO ACCELERATE. IN ADDITION, THE FUEL GAUGE GAVE AN INCORRECT READING. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THERE WAS FUEL SPEWING FROM THE FUEL RAIL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FUEL RAIL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 00V268000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 241,338.

NHTSA ID

10732735

Incident

Jul 2, 2015

Mileage

241,338 mi

BRAKE LINE TO REAR BRAKES ABOVE FUEL TANK RUPTURED AND LOST ALL BRAKE FLUID

NHTSA ID

10732557

Incident

Jun 14, 2015

Mileage

120,000 mi

DRIVING TO STORE. WEATHER WAS CLEAR ~ 85 DEGREES F, ROAD WAS CLEAR, NO RAIN, TIME APPROXIMATELY 10PM. WHILE DRIVING, I MOVED INTO THE CENTER LANE (MAJOR ROAD, THREE LANES BOTH WAYS) FOR A TURN TO THE STORE, DURING MY TURN TO THE LEFT, I NOTICED THAT MY POWER STEERING WAS NOT FUNCTIONING AND VERY HARD TO CONTROL/STEER THE VEHICLE. AFTER STRUGGLING TO STRAIGHTEN OUT MY VAN (1998 PLYMOUTH, GRAND VOYAGER SE) I NOTICED THAT MY ENGINE TEMPERATURE HAD GONE OFF SCALE / OVER HEATING. AT THIS POINT I STOPPED THE VAN IN THE MIDDLE OF TRAFFIC. *TR

NHTSA ID

10712929

Incident

Apr 25, 2015

Mileage

221,000 mi

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING FAILED WITHOUT WARNING AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. WHEN THE HOOD WAS OPENED, THE CONTACT DISCOVERED THAT THE DRIVING BELT WAS OUT OF THE PULLEY. THE BELT WAS PLACED BACK INTO POSITION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 154,000.

NHTSA ID

10680458

Incident

Dec 3, 2014

Mileage

154,000 mi

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. WHILE DRIVING 60 MPH ON A MAJOR HIGHWAY, THE VEHICLE STALLED MULTIPLE TIMES. THE FUEL GAUGE FAILED TO READ PROPERLY AND THE INSTRUMENT PANEL CLUSTER MALFUNCTIONED. IN ADDITION, THE POWER LOCKS AND WINDOWS FAILED TO OPERATE AND THE INTERIOR DOME LIGHT FAILED THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

NHTSA ID

10597703

Incident

Feb 5, 2011

Mileage

145,000 mi

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT SHE SMELLED FUEL COMING FROM THE VEHICLE. ALSO, THE CONTACT MENTIONED THAT THE INSTRUMENT PANEL FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MODULE ASSEMBLY AND INSTRUMENT CLUSTER ASSEMBLIES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 06E091000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 77,000. *TR

NHTSA ID

10507280

Incident

Apr 15, 2009

COMPUTER FAILING TO SEND SIGNAL TO FAN RELAY. *TR

NHTSA ID

10489509

Incident

Dec 28, 2011

Mileage

223,001 mi

TL* THE CONTACT OWNS A 1998 PLYMOUTH VOYAGER. THE CONTACT STATED THAT THE SERPENTINE BELT WOULD DETACH WHENEVER THE VEHICLE WAS DRIVEN WHILE RAINING. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THERE WAS NOTHING THAT COULD BE DONE DUE TO THE DESIGN OF THE VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS UNKNOWN.

NHTSA ID

10478448

Incident

Oct 16, 2009

I PURCHASED VEHICLE USED AND FOUND NO PROBLEMS WITH THE VEHICLE WITH THE EXCEPTION OF A SQUEAKY SERPENTINE BELT. PUT A LITTLE BELT DRESSING ON IT AND THAT WAS AS FAR AS THE ISSUE WENT. THEN ON A DARK RAINY NIGHT, WENT THROUGH A RAIN PUDDLE-VERY SLOWLY, AND INSTANTLY, STEERING BECAME VERY DIFFICULT. THE WORST PART OF THIS EXPERIENCE THIS NIGHT WAS TRYING TO PUT BELT BACK ON PULLEYS, AS YOU CAN IMAGINE IN THE DARK AND NO IDEA HOW TO ROUTE IT. THANK GOODNESS THERE WAS A DIAGRAM IN ENGINE. WITH NO KNOWLEDGE THAT THIS WAS A VERY WELL KNOWN ISSUE WITH THESE VEHICLES IT WAS QUITE A SURPRISE. AFTER RESEARCHING THIS ONLINE, AND READING ALL OF THE CONSUMER COMPLAINTS I CAN'T FIGURE OUT WHAT YOU PEOPLE ARE WAITING FOR!! FATAL ACCIDENTS!! THERE HAS BEEN MORE THAN ENOUGH INFO SUBMITTED AND DOCUMENTED TO WARRANT A RECALL AND HAVE THE MANUFACTURER TAKE CARE OF THIS. OH-BUT GUESS WHAT? ANOTHER COMPANY 'GATES" HAS COME UP WITH A SOLUTION THAT APPARENTLY HAS HAD POSITIVE REVIEWS. MY ORDER IS IN AND I AM AWAITING MY RETROFITTED TENSIONER BELT COMPONENT KIT SO THAT I WILL FEEL SAFE ENOUGH TO BE OUT ON THE ROADS AND THAT I WILL NOT BECOME A HAZARD TO OTHER DRIVERS ON THE ROAD WITH ME. THE FEDERAL GOVERNMENT COMES TO THE AID OF A BIG COMPANY LIKE CHRYSLER (PLYMOUTH) EVEN WHEN IT IS MORE THAN OBVIOUS THAT THEY ARE BUILDING SUBSTANDARD CARS. THIS IS NOT A MAJOR REPAIR, BUT IT IS CERTAINLY A PROBLEM THAT COULD VERY EASILY CAUSE SERIOUS BODILY INJURIES TO MANY PEOPLE FROM JUST ONE INCIDENT! IT HAS NOW BEEN FOURTEEN YEARS SINCE THIS CAR WAS MANUFACTURED. HOW MANY YEARS OF COMPLAINTS DOES IT TAKE TO GET SOMEONE TO NOTICE AND TAKE ACTION? IS THERE SOMEONE ABOVE YOU THAT WE HAVE TO BEG, PLEASE HELP US! THE LITTLE GUYS. WHY SHOULD WE HAVE TO BEG, "PLEASE DON'T LET MY CAR BE THE ONE THAT IS GOING TO KILL SOMEONE."MAKE THE ONES RESPONSIBLE-BE RESPONSIBLE! THANK YOU (I THINK). *TR

NHTSA ID

10445541

Incident

Jan 17, 2012

Mileage

140,000 mi

OK I DIDN'T KNOW HOW ELSE TO PUT THIS BUT TO SAY THAT WHEN RAINING THIS VAN AND THE FUNNY PART IS THAT WHEN DRIVING DURING WEATHER CONDITIONS (I.E. RAIN SNOW) THE MICRO V BELT SLIPS OFF AND MAKES THE VAN HARD TO DRIVE AND MAY IN TIME IF NOT ALREADY CAUSE AND ACCIDENT THE FIRST TIME IT HAPPENED TO US WE WENT THOUGH A SMALL PUDDLE OF WATER ON AN ON RAMP FROM ONE FREE WAY TO ANOTHER AND THE VAN BECAME UNSTABLE AND HARD TO STEER WE HAD A 11 AND A 2 YEAR OLD IN THIS VAN AND NOW IT DOESN'T MATTER WHEN WE DRIVE IN THE RAIN IT HAPPENS I HAVE BEEN TOLD THAT THERE IS A FIX BUT THE KIT IS OVER 200 DOLLARS AND IS NEXT TO IMPOSSIBLE FOR PEOPLE TO FIX THIS ON FIXED INCOMES TO THIS DAY WE STILL DEAL WITH IT BUT SOMETHING SHOULD BE DONE ABOUT IT WITH CHRYSLER AND AFTER DOING A SEARCH ON JUST GOOGLE ALONE I FOUND 1500-5000 DIFFERENT COMPLIANCE ON THIS ONE PROBLEM. *TR

NHTSA ID

10441400

Incident

Jul 4, 2010

Mileage

170,000 mi

FOUND THE DRIVER SIDE STRUT TOWER IS COMPLETELY RUSTED OUT. DISCOVERED ONLINE HUNDREDS OF COMPLAINTS OF SAME ON THE SAME VEHICLE AND DATE RANGE. PLYMOUTH CHRYSLER KNOW ABOUT THIS AND DESCRIBES IT AS COSMETIC BUT THIS IS A STRUCTURAL PROBLEM. *TR

NHTSA ID

10438018

Incident

Nov 24, 2011

Mileage

145,000 mi

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT THE SERPENTINE BELT WOULD DETACH FROM THE VEHICLE WHENEVER IT WOULD RAIN. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE TENSION PULLEY NEEDED REPLACING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 219,000.

NHTSA ID

10427648

Incident

Jan 26, 2011

Mileage

219,000 mi

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT'S VEHICLE WAS CRASHED INTO FROM THE REAR. THE FRONT DRIVER AND PASSENGER SIDE SEATS FRACTURED, THROWING THE DRIVER AND PASSENGER INTO THE DASH BOARD. THE SEAT THEN MOVED BACKWARD INDEPENDENTLY. THE AIR BAGS DID NOT DEPLOY. THE DRIVER AND PASSENGER WERE TRANSPORTED TO THE HOSPITAL VIA AMBULANCE. THE DRIVER SUSTAINED NECK, SHOULDER, BACK, HIP AND KNEE INJURIES. THE PASSENGER SUSTAINED INJURIES TO THE NECK, SHOULDER, BACK, HIP AND A BRUISED HERNIA. THE POLICE REPORTED TO THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10422789

Incident

Jul 3, 2011

Mileage

100,000 mi

DRIVING DOWN ROAD AND ALL OF SUDDEN MY GUAGES GO OUT ON INSTRUMENT PANEL-SPEEDOMETER,FUEL,TEMP, ETC. IT GOES OUT AND COMES ON WHENEVER IT WANTS TO- I DO A LOT OF TRAVELING AND RELY ON MILEAGE RE-IMBURSEMENT BUT I GET NONE CAUSE MY ODOMETER AND TRIPOMETER GO OUT ALSO, SOMETIMES TO NEVER COME ON FOR A WEEK OR TWO. *TT

NHTSA ID

10411705

Incident

Jun 15, 2011

Mileage

142,350 mi

TL* THE CONTACT OWNED A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT THE DRIVER INSERTED THE KEY INTO THE IGNITION AND TURNED IT INTO THE ACCESSORY POSITION WHEN THE AIR BAGS DEPLOYED. THE DRIVER SUSTAINED INJURIES TO THE ARMS, CHEST AND WRIST. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THERE WAS WATER INTRUSION, WHICH COULD HAVE CAUSED THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, AND DETERMINED THAT IT WAS NOT MECHANICAL. THE INSURANCE COMPANY DECIDED THAT THE FAILURE WAS MECHANICAL, AND CLASSIFIED THE VEHICLE AS BEING DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 63,800.

NHTSA ID

10411502

Incident

Jun 21, 2011

Mileage

63,800 mi

TL*THE CONTACT OWNS 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THE AIR BAG LIGHT WAS ILLUMINATED INDICATING THAT THE AIR MALFUNCTIONED. THE CONTACT REVIEWED NHTSA CAMPAIGN NUMBER 04V480000 (AIR BAG) AND NOTIFIED THE MANUFACTURER. THE MANUFACTURER STATED THE VIN WAS NOT A PART OF THE RECALL. THE CONTACT WAS CONCERNED THAT THE AIR BAG COULD DEPLOY WITHOUT A WARNING. THE FAILURE MILEAGE WAS 176,000.

NHTSA ID

10407031

Incident

Jun 15, 2011

Mileage

176,000 mi

I HAVE A 1998 PLYMOUTH GRAND VOYAGER WITH THE 3.3L MOTER, EVERY TIME THE VAN GOES THROUGH A PUDDLE OF WATER THE DRIVE BELT COMES OFF. THE PROBLEM HAS BEEN AROUND FOR A LONG TIME,WHAT HAS TO BE DONE IS THE BELT TENSER AND PULLYS NEED TO BE CHANGED TO FIX THE PROBLEM. THE DEALERSHIP REFUSES TO FIX THE PROBLEM. *TR

NHTSA ID

10373499

Incident

Dec 24, 2010

Mileage

68,000 mi

DASHBOARD INSTRUMENT PANEL KEEPS COMING ON AND GOING OFF, ABS LIGHT COMES ON THEN THE INSTRUMENT PANEL GOES OFF. SPEED IS UNKNOWN, AMOUNT OF GAS IS UNKNOWN, OIL, ETC. THIS IS RIDICULOUS IN THE FACT THAT SO MANY HAVE BEEN COMPLAINING ABOUT IT AND THE COMPANY STILL HASN'T RECALLED THE VEHICLES TO HAVE THIS ISSUE FIXED. YES I MAY HAVE A 1998 PLYMOUTH VOYAGER, BUT I DON'T FEEL THAT BECAUSE OF THE INCOMPETENCE THAT THIS COMPANY HAS THAT I SHOULD HAVE TO SHELL OUT MONEY TO HAVE IT FIGURED OUT AND REPAIRED. I UNDERSTAND NORMAL WEAR AND TEAR BUT THIS IS NOT NORMAL (FOR OTHER VEHICLES, OBVIOUSLY VERY NORMAL FOR THIS ONE IN GENERAL). THE STRANGEST THING IS, IF THE VEHICLE IS WARMED UP FROM THE SUN, THE PANEL SEEMS TO WORK, THE MAJORITY OF THE TIME, WHERE I LIVE IT DOESN'T WORK, AND I HAVE TO GUESSTIMATE EVERYTHING. HOW IS THIS SAFE?!?! *TR

NHTSA ID

10363939

Incident

Mar 5, 2009

WE OWN A 1998 PLYMOUTH GRAND VOYAGER WITH A 3.3 LITER ENGINE. ON FRIDAY,OCTOBER 1,2010, MY WIFE DROVE SLOWLY THROUGH A PUDDLE AND THE SERPENTINE BELT CAME OFF CAUSING A LOSS OF POWER STEERING AND OTHER SYSTEM POWERED BY THE SERPENTINE BELT. THIS HAS HAPPENED TO HER ONCE BEFORE AND FROM WHAT I HAVE READ ON THE INTERNET IS A VERY COMMON PROBLEM WITH THESE VEHICLES. MY WIFE USUALLY ENJOYS DRIVING HER VAN BUT NOW HAS LOST ALL CONFIDENCE IN IT. SHE STATES IT'S A VERY SCARY SITUATION, NOT TO MENTION DANGEROUS. WITH ALL I HAVE READ IT IS ALMOST IMPOSSIBLE TO BELIEVE THERE HAS NOT BEEN A RECALL TO HAVE THIS VERY DANGEROUS SITUATION CORRECTED. *TR

NHTSA ID

10358936

Incident

Oct 1, 2010

Mileage

102,000 mi

RANDOMLY A SHORT CIRCUIT IN THE INSTRUMENT CLUSTER HAS DEVELOPED IN THE 1998 PLYMOUTH GRAND VOYAGER. WHEN THIS OCCURS, THE DASH BOARD REMAINS ILLUMINATED BUT THE GAUGES DO NOT FUNCTION(SPEED, RPM, GEAR, TEMP,ETC) AND THE VEHICLE DOSES NOT COMMUNICATE TO THE TRANSMISSION AND THE VEHICLE DOES NOT SHIFT INTO OVERDRIVE GEAR. THE BRAKES AND AIRBAG WILL ILLUMINATE ON DASH. THE COMPUTER CODES AND READS ECM FAILURE. TWICE TAKEN TO DEALERSHIP DON DRENNAN HOOVER AL. *TR

NHTSA ID

10352447

Incident

Jun 13, 2006

Mileage

110,000 mi

I OWN A 1998 PLYMOUTH GRAND VOYAGER SE. MY GAUGES (GAS, TEMP, RPM, AND GEAR INDICATOR) ARE ALL OUT. IN READING ONLINE, THIS SEEMS TO BE A PROBLEM WITH OTHER PEOPLE AS WELL. I HAVE TO USE A GPS TO BE ABLE TO TELL HOW FAST I'M GOING. I'VE TWICE RAN OUT OF GAS WHILE GOING DOWN THE HIGHWAY BECAUSE I CAN'T TELL HOW MUCH FUEL I HAVE REMAINING. *TR

NHTSA ID

10345092

Incident

May 10, 2009