1998 Plymouth Grand Voyager Problems

AT CERTAIN TIMES THE SERPENTINE BELT WILL SLIP OFF OF THE PULLEYS AND QUIT POWERING THE ALTERNATOR, WATER PUMP, AND POWER STEERING PUMP. THIS CAN BE WORSENED BY RAINY CONDITIONS. CHANGING BELT TENSIONER WORKS FOR A YEAR OR TWO.

DRIVING TO STORE. WEATHER WAS CLEAR ~ 85 DEGREES F, ROAD WAS CLEAR, NO RAIN, TIME APPROXIMATELY 10PM. WHILE DRIVING, I MOVED INTO THE CENTER LANE (MAJOR ROAD, THREE LANES BOTH WAYS) FOR A TURN TO THE STORE, DURING MY TURN TO THE LEFT, I NOTICED THAT MY POWER STEERING WAS NOT FUNCTIONING AND VERY HARD TO CONTROL/STEER THE VEHICLE. AFTER STRUGGLING TO STRAIGHTEN OUT MY VAN (1998 PLYMOUTH, GRAND VOYAGER SE) I NOTICED THAT MY ENGINE TEMPERATURE HAD GONE OFF SCALE / OVER HEATING. AT THIS POINT I STOPPED THE VAN IN THE MIDDLE OF TRAFFIC. *TR

I WAS DRIVING AND THE WHOLE DASH PANEL WENT OUT, GAS, SPEED , HORN GAUGES

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. WHILE DRIVING AT VARIOUS SPEEDS, THE HORN FAILED TO FUNCTION AND THE AIR BAG LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE CLOCK SPRING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

I WAS DRIVING AND THE WHOLE DASH PANEL WENT OUT, GAS, SPEED , HORN GAUGES

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. WHILE DRIVING AT VARIOUS SPEEDS, THE HORN FAILED TO FUNCTION AND THE AIR BAG LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE CLOCK SPRING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

MY VAN IS A LEMON. ALL KINDS OF ELECTRICAL PROBLEMS - DEFOGGER SOMETIMES WORK AND SOMETIMES NOT, WINDOWS WON'T ROLL DOWN, STEREO SPEAKERS SOMETIMES WORKS, INSTRUMENT PANEL LIGHTS GO OFF AND ON, DIM YELLOW HEADLIGHTS, ETC. FOUND PIN HOLE IN HEAD...DEFECT IN METAL. VAN OVER HEATED AND GAUGE DID NOT SAY IT WAS HOT. FAN WENT OUT. NOW SOMETHING GOING WRONG WITH FRONT END. OCCASIONALLY SMELL GAS. THE LIFTER HEAD GASKET NOW LEAKS OIL. VAN SOMETIMES JUMPS IN PARK AND ROLLS. I CAN NOT AFFORD TO FIX THIS STUFF... BAIL ME OUT NOT CHRYSLER.... *TR

TL*THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT THE TRANSMISSION FAILED AFTER THE VEHICLE WAS PURCHASED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP AND THE MECHANIC STATED THAT THE TRANSMISSION HAD TO BE REBUILT. THE VEHICLE WAS REPAIRED. APPROXIMATELY A MONTH LATER, THE TRANSMISSION BEGAN FAILING AGAIN. THE VEHICLE WAS DRIVEN TO THE LOCAL REPAIR SHOP ON THREE DIFFERENT OCCASIONS AND THE MECHANIC STATED EACH TIME THAT THE TRANSMISSION FAILED DUE TO THE SPEED SENSOR. THE VEHICLE WAS REPAIRED AFTER EACH VISIT. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS 170,000 AND THE FAILURE MILEAGE WAS UNAVAILABLE.

BRAKE LINE TO REAR BRAKES ABOVE FUEL TANK RUPTURED AND LOST ALL BRAKE FLUID

I PURCHASED VEHICLE USED AND FOUND NO PROBLEMS WITH THE VEHICLE WITH THE EXCEPTION OF A SQUEAKY SERPENTINE BELT. PUT A LITTLE BELT DRESSING ON IT AND THAT WAS AS FAR AS THE ISSUE WENT. THEN ON A DARK RAINY NIGHT, WENT THROUGH A RAIN PUDDLE-VERY SLOWLY, AND INSTANTLY, STEERING BECAME VERY DIFFICULT. THE WORST PART OF THIS EXPERIENCE THIS NIGHT WAS TRYING TO PUT BELT BACK ON PULLEYS, AS YOU CAN IMAGINE IN THE DARK AND NO IDEA HOW TO ROUTE IT. THANK GOODNESS THERE WAS A DIAGRAM IN ENGINE. WITH NO KNOWLEDGE THAT THIS WAS A VERY WELL KNOWN ISSUE WITH THESE VEHICLES IT WAS QUITE A SURPRISE. AFTER RESEARCHING THIS ONLINE, AND READING ALL OF THE CONSUMER COMPLAINTS I CAN'T FIGURE OUT WHAT YOU PEOPLE ARE WAITING FOR!! FATAL ACCIDENTS!! THERE HAS BEEN MORE THAN ENOUGH INFO SUBMITTED AND DOCUMENTED TO WARRANT A RECALL AND HAVE THE MANUFACTURER TAKE CARE OF THIS. OH-BUT GUESS WHAT? ANOTHER COMPANY 'GATES" HAS COME UP WITH A SOLUTION THAT APPARENTLY HAS HAD POSITIVE REVIEWS. MY ORDER IS IN AND I AM AWAITING MY RETROFITTED TENSIONER BELT COMPONENT KIT SO THAT I WILL FEEL SAFE ENOUGH TO BE OUT ON THE ROADS AND THAT I WILL NOT BECOME A HAZARD TO OTHER DRIVERS ON THE ROAD WITH ME. THE FEDERAL GOVERNMENT COMES TO THE AID OF A BIG COMPANY LIKE CHRYSLER (PLYMOUTH) EVEN WHEN IT IS MORE THAN OBVIOUS THAT THEY ARE BUILDING SUBSTANDARD CARS. THIS IS NOT A MAJOR REPAIR, BUT IT IS CERTAINLY A PROBLEM THAT COULD VERY EASILY CAUSE SERIOUS BODILY INJURIES TO MANY PEOPLE FROM JUST ONE INCIDENT! IT HAS NOW BEEN FOURTEEN YEARS SINCE THIS CAR WAS MANUFACTURED. HOW MANY YEARS OF COMPLAINTS DOES IT TAKE TO GET SOMEONE TO NOTICE AND TAKE ACTION? IS THERE SOMEONE ABOVE YOU THAT WE HAVE TO BEG, PLEASE HELP US! THE LITTLE GUYS. WHY SHOULD WE HAVE TO BEG, "PLEASE DON'T LET MY CAR BE THE ONE THAT IS GOING TO KILL SOMEONE."MAKE THE ONES RESPONSIBLE-BE RESPONSIBLE! THANK YOU (I THINK). *TR

FOUND THE DRIVER SIDE STRUT TOWER IS COMPLETELY RUSTED OUT. DISCOVERED ONLINE HUNDREDS OF COMPLAINTS OF SAME ON THE SAME VEHICLE AND DATE RANGE. PLYMOUTH CHRYSLER KNOW ABOUT THIS AND DESCRIBES IT AS COSMETIC BUT THIS IS A STRUCTURAL PROBLEM. *TR

MY VAN IS A LEMON. ALL KINDS OF ELECTRICAL PROBLEMS - DEFOGGER SOMETIMES WORK AND SOMETIMES NOT, WINDOWS WON'T ROLL DOWN, STEREO SPEAKERS SOMETIMES WORKS, INSTRUMENT PANEL LIGHTS GO OFF AND ON, DIM YELLOW HEADLIGHTS, ETC. FOUND PIN HOLE IN HEAD...DEFECT IN METAL. VAN OVER HEATED AND GAUGE DID NOT SAY IT WAS HOT. FAN WENT OUT. NOW SOMETHING GOING WRONG WITH FRONT END. OCCASIONALLY SMELL GAS. THE LIFTER HEAD GASKET NOW LEAKS OIL. VAN SOMETIMES JUMPS IN PARK AND ROLLS. I CAN NOT AFFORD TO FIX THIS STUFF... BAIL ME OUT NOT CHRYSLER.... *TR

I WAS DRIVING AND THE WHOLE DASH PANEL WENT OUT, GAS, SPEED , HORN GAUGES

PUT THE VAN IN DRIVE AND IT ACTS LIKE IT IS IN PARK/NEUTRAL THEN WITHIN 20 SECONDS OR MORE IT DECIDES TO GO. NOW YOU WILL BE DRIVING AND ALL OF A SUDDEN THE VAN PUTS ITSELF IN NEUTRAL AND THEN BACK INTO DRIVE AFTER AWHILE. NOT SAFE!! THERE ARE SEVERAL LEAKS UNDERNEATH THE FIRST 5 MINUTES THE VAN IS TURNED ON IT DINGS LIKE THE DOOR IS OPEN. AFTER ABOUT 10 MINUTES THE BRAKE LIGHT SHINES ON DASH AND THE BELL RINGS THE VAN IS PARKED FOR NOW. *TR

MY VAN IS A LEMON. ALL KINDS OF ELECTRICAL PROBLEMS - DEFOGGER SOMETIMES WORK AND SOMETIMES NOT, WINDOWS WON'T ROLL DOWN, STEREO SPEAKERS SOMETIMES WORKS, INSTRUMENT PANEL LIGHTS GO OFF AND ON, DIM YELLOW HEADLIGHTS, ETC. FOUND PIN HOLE IN HEAD...DEFECT IN METAL. VAN OVER HEATED AND GAUGE DID NOT SAY IT WAS HOT. FAN WENT OUT. NOW SOMETHING GOING WRONG WITH FRONT END. OCCASIONALLY SMELL GAS. THE LIFTER HEAD GASKET NOW LEAKS OIL. VAN SOMETIMES JUMPS IN PARK AND ROLLS. I CAN NOT AFFORD TO FIX THIS STUFF... BAIL ME OUT NOT CHRYSLER.... *TR

FRONT WINDSHIELD WIPERS SOMETIMES WILL NOT TURN ON. THE REAR WIPER AND BOTH WASHERS WORK FINE. SOME COMPONENTS WERE REPLACED IN 1999, BUT PROBLEM CONTINUES. *TR

FOUND THE DRIVER SIDE STRUT TOWER IS COMPLETELY RUSTED OUT. DISCOVERED ONLINE HUNDREDS OF COMPLAINTS OF SAME ON THE SAME VEHICLE AND DATE RANGE. PLYMOUTH CHRYSLER KNOW ABOUT THIS AND DESCRIBES IT AS COSMETIC BUT THIS IS A STRUCTURAL PROBLEM. *TR

TOOK CAR FOR PA STATE INSPECTION AND FAILED DUE TO TECH WOULD NOT LOAD CAR ON LIFT. LEFT FRONT STRUT TOWER IS RUSTED THROUGH. HE WAS AFRAID THAT THE LIFT WOULD PUSH THE STRUT THROUGH THE HOOD OF THE CAR. *TR

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH ATTEMPTING TO ACCELERATE, THE VEHICLE FAILED TO ACCELERATE. IN ADDITION, THE FUEL GAUGE GAVE AN INCORRECT READING. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THERE WAS FUEL SPEWING FROM THE FUEL RAIL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FUEL RAIL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 00V268000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 241,338.

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT SHE SMELLED FUEL COMING FROM THE VEHICLE. ALSO, THE CONTACT MENTIONED THAT THE INSTRUMENT PANEL FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MODULE ASSEMBLY AND INSTRUMENT CLUSTER ASSEMBLIES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 06E091000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 77,000. *TR

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT'S VEHICLE WAS CRASHED INTO FROM THE REAR. THE FRONT DRIVER AND PASSENGER SIDE SEATS FRACTURED, THROWING THE DRIVER AND PASSENGER INTO THE DASH BOARD. THE SEAT THEN MOVED BACKWARD INDEPENDENTLY. THE AIR BAGS DID NOT DEPLOY. THE DRIVER AND PASSENGER WERE TRANSPORTED TO THE HOSPITAL VIA AMBULANCE. THE DRIVER SUSTAINED NECK, SHOULDER, BACK, HIP AND KNEE INJURIES. THE PASSENGER SUSTAINED INJURIES TO THE NECK, SHOULDER, BACK, HIP AND A BRUISED HERNIA. THE POLICE REPORTED TO THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

MY VAN IS A LEMON. ALL KINDS OF ELECTRICAL PROBLEMS - DEFOGGER SOMETIMES WORK AND SOMETIMES NOT, WINDOWS WON'T ROLL DOWN, STEREO SPEAKERS SOMETIMES WORKS, INSTRUMENT PANEL LIGHTS GO OFF AND ON, DIM YELLOW HEADLIGHTS, ETC. FOUND PIN HOLE IN HEAD...DEFECT IN METAL. VAN OVER HEATED AND GAUGE DID NOT SAY IT WAS HOT. FAN WENT OUT. NOW SOMETHING GOING WRONG WITH FRONT END. OCCASIONALLY SMELL GAS. THE LIFTER HEAD GASKET NOW LEAKS OIL. VAN SOMETIMES JUMPS IN PARK AND ROLLS. I CAN NOT AFFORD TO FIX THIS STUFF... BAIL ME OUT NOT CHRYSLER.... *TR

AT CERTAIN TIMES THE SERPENTINE BELT WILL SLIP OFF OF THE PULLEYS AND QUIT POWERING THE ALTERNATOR, WATER PUMP, AND POWER STEERING PUMP. THIS CAN BE WORSENED BY RAINY CONDITIONS. CHANGING BELT TENSIONER WORKS FOR A YEAR OR TWO.

TL* THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING FAILED WITHOUT WARNING AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. WHEN THE HOOD WAS OPENED, THE CONTACT DISCOVERED THAT THE DRIVING BELT WAS OUT OF THE PULLEY. THE BELT WAS PLACED BACK INTO POSITION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 154,000.

CONSUMER COMPLAINED ABOUT SEAT BELT SYSTEM. DEALER INDICATED NOTHING THEY COULD DO ABOUT IT SINCE VEHICLE HAD TOO MANY MILES AND NO WARRANTY.*AK

WHEN PLACING THE CHILD INSIDE THE CAR SEAT THE HANDLE BROKE, CAUSING THE CHILD TO FALL OUT.*AK

OK I DIDN'T KNOW HOW ELSE TO PUT THIS BUT TO SAY THAT WHEN RAINING THIS VAN AND THE FUNNY PART IS THAT WHEN DRIVING DURING WEATHER CONDITIONS (I.E. RAIN SNOW) THE MICRO V BELT SLIPS OFF AND MAKES THE VAN HARD TO DRIVE AND MAY IN TIME IF NOT ALREADY CAUSE AND ACCIDENT THE FIRST TIME IT HAPPENED TO US WE WENT THOUGH A SMALL PUDDLE OF WATER ON AN ON RAMP FROM ONE FREE WAY TO ANOTHER AND THE VAN BECAME UNSTABLE AND HARD TO STEER WE HAD A 11 AND A 2 YEAR OLD IN THIS VAN AND NOW IT DOESN'T MATTER WHEN WE DRIVE IN THE RAIN IT HAPPENS I HAVE BEEN TOLD THAT THERE IS A FIX BUT THE KIT IS OVER 200 DOLLARS AND IS NEXT TO IMPOSSIBLE FOR PEOPLE TO FIX THIS ON FIXED INCOMES TO THIS DAY WE STILL DEAL WITH IT BUT SOMETHING SHOULD BE DONE ABOUT IT WITH CHRYSLER AND AFTER DOING A SEARCH ON JUST GOOGLE ALONE I FOUND 1500-5000 DIFFERENT COMPLIANCE ON THIS ONE PROBLEM. *TR

THE PIN (ABOUT 1" DIA) IN THE TRANSAXLE BROKE, TRAVELLING AT ABOUT 60MPH, AND LOCKED UP THE FRONT WHEELS OF THE VEHICLE. THE LOCKUP OCCURED BECAUSE THE PIN EXITED THROUGH THE HOUSING OF THE TRANSAXLE AND LODGED ITSELF IN BETWEEN THE BELL HOUSING AND TORQUE CONVERTER. THE TRANSAXLE HAD THREE DIFFERENT HOLES SMASHED IN ITS SIDE FROM THE FAILURE. I HAVE PICTURES OF THE DAMAGE WHICH I CAN EMAIL. I WAS TOLD BY THE GARAGE THAT REPLACED THE TRANSAXLE THAT THIS IS A COMMON FAILURE ON THE PLYMOUTH VOYAGERS ALTHOUGH NORMALLY THE FAILURE DOESN'T OCCUR UNTIL THE 90,000+ MARK. THIS FAILURE COULD HAVE CREATED A SERIOUS ACCIDENT SINCE THE FRONT WHEELS SUDDENLY LOCKED UP.

FAILED AIR CONDITIONING EXPANSION VALVE. REPLACED VALVE AND RECHARGED SYSTEM. ENGINE 3.3L. MILEAGE 95085.*AK

WHEN A LEFT TURN WAS MADE, THE STEERING WHEEL LOCKED UP. *JB CONSUMER HAD TO JERK TO THE RIGHT TO BREAK LOOSE THEN THE TURN SIGNALS WOULD NOT CANCEL. BROKEN MULTIFUNCTION SWITCH REPLACED. AIR CONDITIONER INOPERATIVE. DEALER REPLACED LEAKING EVAPORATOR. FASCIAS AND REAR SLIDING DOOR DAMAGED, DIRTY. *TT

MY VAN IS A LEMON. ALL KINDS OF ELECTRICAL PROBLEMS - DEFOGGER SOMETIMES WORK AND SOMETIMES NOT, WINDOWS WON'T ROLL DOWN, STEREO SPEAKERS SOMETIMES WORKS, INSTRUMENT PANEL LIGHTS GO OFF AND ON, DIM YELLOW HEADLIGHTS, ETC. FOUND PIN HOLE IN HEAD...DEFECT IN METAL. VAN OVER HEATED AND GAUGE DID NOT SAY IT WAS HOT. FAN WENT OUT. NOW SOMETHING GOING WRONG WITH FRONT END. OCCASIONALLY SMELL GAS. THE LIFTER HEAD GASKET NOW LEAKS OIL. VAN SOMETIMES JUMPS IN PARK AND ROLLS. I CAN NOT AFFORD TO FIX THIS STUFF... BAIL ME OUT NOT CHRYSLER.... *TR

DT*: THE CONTACT STATED WHILE DRIVING AT NIGHT THE HEADLIGHT ILLUMINATION WAS TOO DIM. THE VEHICLE WAS DRIVEN TO THE DEALER WHO CLEANED AND BUFFED OUT THE LENSES. UPDATED 1/19/2007 - *NM

DRIVING HOME FROM FLORIDA IN A 1998 PLYMOUTH CARAVAN PULLING A HOBIE CAT SAILBOAT ON A TRAILER THE LEFT REAR TIRE SEPARATED. I HAVE PICTURES OF THE TIRE AND STILL HAVE THE ORIGINAL TIRE. HAD TO BUY A NEW TIRE. *JB

PE00 020 ; CONSUMER WAS TRAVELING ABOUT 75MPH ON HIGHWAY AND HEARD A NOISE. HE WAS ABLE TO CONTROL VEHICLE AND BRING TO A HALT. LEFT FRONT GOODYEAR TIRE TIRE TREAD SEPARATED. ATP233575R14.*AK CONSUMER STATES APPROXIMATELY SIX WEEKS LATER, A VIBRATION COULD BE FELT WHILE DRIVING, ANOTHER GOODYEAR TIRE HAD A BULGE AND WAS REPLACED. *SLC

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK