1999 Plymouth Grand Voyager Brakes Problems

THE REAR BRAKE LINE RUSTED THRU, CAUSING FAILURE IN BRAKING.

NHTSA ID

10981674

Incident

Apr 29, 2017

Mileage

116,700 mi

VAN WAS BOUGHT PRIVATELY IN SUMMER OF 2008. DURING THE FIRST ROAD TRIP WITH THE VOYAGER, THE TRANSMISSION WENT AND WAS REPLACED WITH A REBUILD TRANSMISSION. IN SEPTEMBER OF THAT SAME YEAR, FUEL PUMP AND BATTERY HAD TO BE REPLACED. TWO MONTHS LATER, HEAD GASKET BLEW, WAS REPAIRED BUT DAMAGE TO ENGINE WAS UNKNOWN. IN WINTER OF 2008, REPEATED PROBLEMS WITH OIL & BRAKE FLUID LEAKING OUT FROM CALIPERS. BRAKES ALWAYS NEEDED SOME TYPE OF WORK: PADS, DRUMS, BEARINGS, CALIPERS. IN 2009, WATER PUMP HAD TO BE REPLACED, YET VAN STILL FELT HOTTER THEN WHAT IT READ. EXHAUST STARTED COMING THROUGH THE PASSENGER SIDE VENTS .IT WAS REPAIRED, BUT STARTED AGAIN. FOUND HOSES GETTING HOLES BURNT THROUGH, AND NEEDED TO BE REPAIRED. IN 2010, REPLACED HEADLIGHTS, BUT NIGHT TIME ILLUMINATION WAS STILL POOR, EVEN WITH HIGH BEAMS ON. BATTERY NEEDED TO BE JUMP STARTED MORE & MORE, AND AN EXCESSIVE AMOUNT OF BATTERY ACID HAD TO BE REMOVED FROM A TERMINAL. THE BATTERY ACTUALLY LOOKED LIKE IT HAD BEEN BURNT. MORE LEAKS FOUND CAUSED BY HOLES THROUGH HOSES. YET AGAIN, THE WATER PUMP HAD TO BE REPLACED IN JULY. THEN IN OCTOBER 2010, THINGS GOT VERY SCARY, THE SERPENTINE BELT FELL OFF FOR THE FIRST TIME WHILE DRIVING ABOUT 10KM, WHILE TURNING UP INTO THE DRIVEWAY. I COULDN'T COMPLETE THE TURN DUE TO THE LOSS OF POWER STEERING AND WAS ALMOST HIT HEAD ON BY ONCOMING TRAFFIC. THE BELT WAS PUT BACK ON. 2 DAYS LATER THE BELT FELL OFF AGAIN, & AGAIN. MECHANIC REPLACED BELT AND PARTS, DROVE AROUND LIKE CRAZY & THOUGHT PROBLEM WAS FIXED. 6 WEEKS AFTER, SERPENTINE BELT FALLS OFF AGAIN WHILE DRIVING AT NIGHT, DURING A SNOW STORM, ON A CANADIAN ROCKY MTN HIGHWAY, WITH FULL ELECTRICAL SHUT DOWN OF VAN, LIMITED CELL PHONE SERVICE, AND OUR 4 SMALL CHILDREN. THIS INCIDENT WAS EXTREMELY UNSAFE, DANGEROUS, SCARY, AND EXPENSIVE! 3 WEEKS LATER, HEAD GASKET BLOWS AGAIN, AND THE VAN IS DONE.

NHTSA ID

10383538

Incident

Oct 27, 2010

Mileage

230,000 mi

TOTAL BRAKE FAILURE WHILE OPERATING VEHICLE 1999 GRAND VOYAGER I DID RESEARCH AND IT SEEMS THAT THIS QUITE COMMON. *TR

NHTSA ID

10259703

Incident

Feb 23, 2009

Mileage

67,301 mi

STEEL HYDRAULIC BRAKE LINE TO REAR BRAKES RUPTURED WHILE DRIVING (BRAKING), RESULTING IN COMPLETE LOSS OF BRAKE FLUID AND BRAKING ABILITY. INSPECTION SHOWED BRAKE LINE WAS CORRODED THROUGH. RUPTURE WAS LOCATED IN SOLID TUBING UNDER VEHICLE, BELOW DRIVER'S SEAT, WHERE THE BRAKE LINE TURNED AND HEADED TOWARDS REAR OF VEHICLE. VEHICLE WAS SAFELY BROUGHT TO A STOP USING PARKING BRAKE. CHRYSLER DEALER SERVICE DEPARTMENT REPLACED 4 REAR BRAKE LINES, 2 FLEX LINES, BOOSTER AND MASTER CYLINDER. THE CORRODED TUBING WAS REPLACED WITH FLEXIBLE STEEL WRAPPED LINES. FROM THE INVOICE THE PARTS REPLACED WERE: ITEM DESCRIPTION (FOLLOWED BY FP NUMBER) MASTER CYL 5039003 (4683264); BOOSTER 5100002 (4797614); LINE TAND 5062001 (4683291); TUBE JUNC 5062001 (4683696); TUBE JUNC 5062001 (4683697); BRACKET B 5057002 (4683441); FLUID BRA 1081006 (4318080-AB); LINE VALV 5062001 (4683320); LINE VALV 5062001 (4683321); LOCK BRAK 5057002 (2208893, QUANTITY 2). TOTAL CHARGE FOR PARTS, LABOR, TAX = $1,547.31. *TR

NHTSA ID

10250105

Incident

Jul 25, 2007

Mileage

99,862 mi

DT: CONTACT STATED WHILE DRIVING THE INTERIOR LIGHT DIMMED, AND THE ABS LIGHT ON THE DASHBOARD CAME ON. THE ENTIRE ELECTRICAL SYSTEM FAILED AND THE VEHICLE STALLED. THE PROBLEM OCCURRED WITHOUT WARNING. THE DEALER HAS NOT BEEN CONTACTED YET. THE MANUFACTURER INFORMED HER THAT SHE NEEDED TO HAVE THE VEHICLE LOOKED AT. THE VEHICLE WILL HAVE TO BE TOWED TO THE DEALER. *AK

NHTSA ID

10141631

Incident

Nov 2, 2005

Mileage

200,000 mi

IGNITION LOCK CYLINDER DEFECT. THIRD DEFECT/REPLACEMENTON THIS VEHICLE. STRANDED DO TO DEFECTIVE MATERIAL/WORKMANSHIP. ADDITIONAL DEFECTS INCLUDE TEMPERATURE SWITCH,RADIATOR COOLING FANS, PREMATURE BRAKE WEAR(BRAKES REPLACED TWICE ALREADY). MANUFACTURER THINKS THIS IS NORMAL.*AK

NHTSA ID

10043685

Incident

Oct 20, 2003

I HAVE HAD BRAKE PROBLEMS WITH MY '99 PLYMOUTN GRAND VOYAGER SE FOR SOME TIME. WHEN APPLYING THE BRAKES IT SEEMS THAT THERE MOMENTARILY ISN'T ANY BRAKES THEN THERE IS A FEEL IN THE BRAKE PEDAL LIKE A CATCH BEFORE THE BRAKING BEGINS. THERE HAS BEEN OCCASION WHERE ON A SUDDEN STOP IT SEEMED THAT THE BRAKES JUST WERE NOT EFFECTIVELY THERE. THE HARDER I APPLIED THEM SEEMED TO HAVE NO AFFECT. I WAS SHOOK-UP FOR SURE. DURING THE FACTORY WARRANTY PERIOD I EXPRESSED MY CONCERN TO THE CHRYSLER DEALER, BILL LUKE DODGE. I WAS TOLD THERE WAS NO RECALL ON THIS PROBLEM, THEREFORE NO REPAIRS WAS MADE. I HAVE SINCE REPLACED THE PADS BUT HAS MADE NO CHANGE ON THE PROBLEM. *LA

NHTSA ID

10043367

Incident

Nov 22, 2000

THE ANTI-LOCK BRAKE SYSTEM WARNING LIGHT ILLUMINATED AND WAS TAKEN TO THE DEALER FOR SERVICE. DEALER DIAGNOSED THE ABS HYDRAULIC CONTROL UNIT HAD FAILED AND NEEDED TO BE REPLACED. *JB THE CONTROL UNIT WAS COVERED BY THE MANUFACTURER IN 1998. FAILURE OF THIS PART COULD ALLOW THE BRAKES TO LOCK UP CAUSING THE VEHICLE TO SLIDE OUT OF CONTROL. *SCC

NHTSA ID

10017864

Mileage

48,000 mi

WHEN BRAKES WERE DEPRESSED, THE PEDAL TRAVELED TO THE FLOOR, AND THE ABS LIGHT ILLUMINATED. THE DEALERSHIP REPLACED THE SENOR, HOWEVER THE PROBLEM RECURRED. *JB

NHTSA ID

10014724

Incident

May 19, 2002

Mileage

35,000 mi

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID

764394

Incident

Jul 15, 2002

WHEN APPLYING BRAKES AT 70 MPH CONSUMER HEARD A SCRAPING SOUND WITH VIBRATION AND BRAKING DISTANCE WAS EXTENDED BEYOND 300 FEET. *JG *AK

NHTSA ID

8007602

Incident

Apr 6, 2002

THE AIR CONDITIONING WAS NOT WORKING, CONSUMER WAS INFORMED THAT A REAR EVAPORATOR WAS NEEDED.*YH

NHTSA ID

562063

Incident

May 21, 2001

FRONT BRAKES WITHOUT ANY WARNING DEVELOPED METAL TO METAL GRINDING NOISE. DEALER INDICATED THAT PADS AND ROTORS WERE NEEDED. INDICATED THAT VAN IS NOT EQUIPED WITH WEAR INDICATORS WHCIH THEN ALLOW FOR ADDITIONAL PARTS DAMAGE SINCE BRAKES GO WITHOUT WARNING. *AK

NHTSA ID

742165

Incident

Mar 9, 2001