1999 Pontiac Montana

SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.

ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

THE REAR PASSENGER SUSPENSION SYSTEM HAS FAILED AND THE TIRE IS SITTING ON THE TIRE-WELL. THE FRAME APPEARS TO BE LOOSE DUE TO RUST AND HAS CAUSED THE SPRING COIL TO POP OUT AND WOBBLE UNCONTROLLABLY. I WAS DRIVING WHEN THIS INCIDENT OCCURRED AND IT WOULD BEGIN TO "FISH TAIL" AROUND 40MPH OR WHEN I WOULD HIT BUMPS, MAKE TURNS OR SWITCH LANES.

NHTSA ID

10926987

Incident

Nov 18, 2016

Mileage

135,600 mi

AIRBAG LIGHT CAME ON AND TRANSMISSION SHIFT LEVER MOVES BUT DOES NOT ENGAGE TRANSMISSION. *TR

NHTSA ID

10578368

Incident

Apr 8, 2014

Mileage

96,700 mi

I HAD AN ACCIDENT WHERE A CAR FISH TAILED IN FRONT OF ME SLID DIRECTLY IN FRONT OF MINE. I HIT THE OTHER CAR WHILE GOING 40 MPH, IT WAS A T*BONE COLLISION. MY FRONT AIR BAGS DEPLOYED AT THE TIME OF COLLISION. AFTER GETTING OUT OF THE VEHICLE I NOTICED THAT THE PASSENGER SIDE AIR BAG WAS LAYING IN THE FRONT PASSENGER SEAT WITH THE AIR BAG STILL INFLATED. I DO REMEMBER THAT FOR A LONG TIME BEFORE TODAY THE RED AIRBAG LIGHT WAS ON. I THOUGHT THIS WOULD CAUSE THE AIR BAGS NOT TO WORK. I DO HAVE PICTURES OF THE DAMAGE, AND THE DEFECT WITH THE AIR BAG. *TR

NHTSA ID

10496406

Incident

Feb 4, 2013

Mileage

260,375 mi

IT SEEMS THAT THE THIS PARTICULAR MAKE AND MODEL HAS KNOWN PROBLEMS WITH THE COOLING SYSTEM. ON A FAMILY TRIP TO VIRGINIA THE CAR STARTED TO OVERHEAT AND I STOPPED THE VEHICLE. WHEN PARKED RED FLUID WAS VISIBLE UNDER THE CAR AND UPON TESTING WAS FOUND OUT TO BE COOLANT LEAK. CAR WAS TOWED TO PA AND MECHANIC REPORTED LOSS AND REPLACEMENT OF RADIATOR/HOSES AND LOWER INTAKE MANIFOLD (GASKET) A LABOR INTENSIVE WORK COSTING ABOUT 1700 TO FIX ALL THE ISSUE WITH THIS OVER HEATING. *TR

NHTSA ID

10460448

Incident

May 27, 2012

Mileage

168,000 mi

ELECTRICAL COMPONENTS AND REAR LIGHT FAILURE INCLUDING BREAKS AN TURN SIGNALS.*TR

NHTSA ID

10383023

Incident

Feb 16, 2011

1. EVENTS UNKNOWN 2. COOLING SYSTEM FAILURE, ALL THE TIME, UNDRIVEABLE 3. UNABLE TO CORRECT FAILURE. *TR

NHTSA ID

10378277

Incident

Jan 1, 2011

Mileage

160,000 mi

FIRST THE DRIVER'S SIDE WINDOW STOPPED WORKING, THEN THE TAIL LIGHTS JUST WENT OUT ON THE 99 PONTIAC MONTANA. THEY WERE JUST WORKING AND THEN ON MY WAY HOME THEY JUST STOPPED WORKING. I REPLACED ALL BULBS AND THEY STILL AREN'T WORKING. WENT TO SEE A TECHNICIAN AND HE SAYS IT IS AN ELECTRICAL PROBLEM. AFTER THAT THE RADIO DISPLAY FLICKERS IN AND OUT WHEN THE BRAKE IS PUSHED ON. I'VE SEARCHED TO SEE IF I COULD FIND AN ANSWER AS TO WHY THIS HAPPENED AND THERE ARE MANY WEBSITES WITH THE SAME COMPLAINTS AS I HAVE STATED HERE WITH THE SAME PROBLEMS. *TR

NHTSA ID

10345982

Incident

Jun 7, 2010

Mileage

178,280 mi

VEHICLE SPONTANEOUSLY CAUGHT FIRE WHILE STUCK IN SNOW DRIFT. FIRE WAS ALL CONSUMING - FIRE TRUCK HAD TO COME OUT IT OUT - JUST SHELL OF VAN WAS LEFT. WE WERE ABLE TO GET OUT AS FIRE WAS SLOW TO TAKE OFF. FIRE STARTED IN ENGINE COMPARTMENT. FIRE CHIEF SAID WE WOULD NEVER KNOW CAUSE AS NO ENGINE COMPARTMENT REMAINS. *TR

NHTSA ID

10252473

Incident

Dec 19, 2008

Mileage

113,000 mi

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.