2015 RAM 1500 Electrical Problems

ABS module has failed and causes traction control and cruise control not to work. Ram says the part is unavailable. The vehicle is unsafe to operate like this.

NHTSA ID

11750725

Incident

Jul 16, 2026

On July 2nd, I was actively driving my 2015 Ram 1500 equipped with the 5.7L Hemi V8 gas engine. The vehicle is completely factory-stock with zero aftermarket electronics, wiring modifications, or accessories. While operating the truck, the dashboard instrument cluster suddenly began flickering wildly, indicating a severe voltage drop or electrical system failure. Immediately following the flickering, a catastrophic fire erupted inside the cabin, originating directly underneath the dashboard on the passenger's side. The fire department responded to extinguish the flames. The engine bay was unaffected by fluid leaks, and the fire originated strictly within the factory dashboard electrical wiring harness/modules. The vehicle is a total loss.

NHTSA ID

11748767

Incident

Jul 2, 2026

While driving on the highway with my entire family in the vehicle, truck lost power without warning and what it seems it went into a limp mode. This created an incredibly hazardous situation, exposing my family and the drivers around us to an imminent risk of a high-speed collision. Thankfully, nothing happened and no one was hurt. Upon restarting the vehicle, the check engine light illuminated, and power was drastically reduced, capping our speed at approximately 40 mph. I brought the truck to St Charles's dealership for diagnosis. Service department has informed me that the root cause of this catastrophic failure was the crankshaft tone wheel. Furthermore, I was informed that this specific issue was an unaddressed/unfixed defect on my vehicle by Stellantis. What I learned is that the fix for a broken tone wheel required dropping the transmission to physically press a brand-new tone wheel onto the crankshaft. Because this was incredibly expensive and time-consuming, Chrysler rolled out a recall remedy consisting of a Powertrain Control Module (PCM) software flash.This should be unacceptable for trucks that cost $70,000 or any vehicle. Imagine that software failed what would have happened and yet we had no idea about this.

NHTSA ID

11747078

Incident

Feb 1, 2026

Dear NHTSA, I am contacting you regarding an active service campaign for my vehicle involving the crankshaft position sensor and tone ring. I would like to arrange for this campaign to be completed as soon as possible. I was told by one dealership that my vin doesn't fall under this campaign. The Campaign is noted for the years of vehicle and my Truck stopped mid-drive in traffic abruptly. I feel this could have been a safety concern. When code ran and light on dash it says crank shaft position sensor. Vehicle Information: 2015/Ram 1500/EcoDiesel 3.0 VIN: [XXX] Current Mileage: 192446 I understand this service campaign addresses potential issues related to the crankshaft position sensor and tone ring, which may affect vehicle performance and reliability. I am requesting that the inspection and all applicable repairs or replacements associated with this campaign be performed at no cost as outlined by the manufacturer. Please contact me with the earliest available appointment date and any additional information or documentation needed prior to service. You may reach me at [XXX] or [XXX] Thank you for your prompt attention to this matter. I look forward to your response. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11746207

Incident

May 4, 2026

My eps is going out. When driving and turning my wheel the wheel catches and is hard to turn. It is significantly harder to turn when driving compared to being parked. Also it seems to not do this during the evening and early morning when it’s cool out.

NHTSA ID

11741913

Incident

May 9, 2026

ABS communication failure has completely locked the transmission in Park, creating an immediate safety hazard, and that the manufacturer has failed to provide replacement part

NHTSA ID

11739594

Incident

May 22, 2026

The vehicle is experiencing an intermittent and unpredictable loss of power steering assist. The steering becomes extremely stiff and difficult to turn, often immediately upon startup or while at a standstill, then randomly becomes loose again before returning to a stiff state. This creates a significant safety hazard as the effort required to steer changes without warning during operation. Upon inspection, the electrical connectors to the EPS rack were found to be clean and free of corrosion, suggesting an internal failure of the Electronic Power Steering motor or control module. This issue is identical to the safety concerns addressed in NHTSA Recall 16V-167 (S19), but this specific VIN is not currently included in that recall.

NHTSA ID

11737550

Incident

Mar 23, 2026

The ABS module failed in June of 2025. Ram originally told me the part was on back order 6-8 months. In December they said there were 100 ABS modules on order for our area. In January 2026 they informed the mechanic that is doing the work that there is still parts on back order and it could be another 1-2 months. Today 2/25/26 the mechanic was told there are 265 modules on back order and it can be another 2-3 months. The truck now has a throttle body control issue that is stemming from the ABS issue. The truck is not operable at the moment because of this back order. I have been waiting for 7 months for this part and there are no alternatives on the market. If Ram does not get a part available for me I will either have to find a used one that hopefully isn't going to fail or be out of a $50,000 truck. This is a problem that many people have had according to all of the RAM forums. RAM needs to find a solution because the consumer already paid for the vehicle so parts should be available.

NHTSA ID

11720411

Incident

Feb 7, 2026

I have a 2015 Ram 1500, my experience is not unique and this issue is well known online. The ABS module (Part No: 68228991AD) is no longer working and my truck has been having an issue with this for about 3 years. The Parts departments in dealerships will typically say that the manufacturer is "looking" for a new contract parts supplier and say that a certain date is upcoming, but it always gets pushed further into the future. I have been without ABS for a long time for this reason. Since I have moved around, I have been unable to stick with a certain parts department for an extended period of time, but I have had this part on order with the current dealership near me for over 5 months, with no status update other than its on order. This seems like a large safety issue to me and I would like the regulator to do something about this.

NHTSA ID

11717487

Incident

Apr 26, 2023

The main ABS module has an internal electrical failure and shuts down. The failure affects the ABS, Traction Control, Trailer brake system and Cruise control to all be inoperable until replaced. The Module is unavailable from dealership with no known date of arrival.

NHTSA ID

11707232

Incident

Dec 16, 2025

What component or system failed or malfunctioned, and is it available for inspection upon request? ABS Control Module (Part Number 68228991AD). Failure of this part prevents the ABS system, trailer brake, cruise control, and traction control from functioning properly. Part is currently installed into vehicle and is not available for inspection. How was your safety or the safety of others put at risk? Car no longer has ABS, traction control, trailer brake, or cruise control. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. This is a know issue with 2014-2016 Ram 1500s. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Following lights are on dashboard: Brake, Traction Control, ABS. OBD Code C2200 for internal module failure. Lights were first intermittent in the Summer of 2024. Came on permanently in early 2025. ADDITIONAL INFORMATION There is a design flaw in the ABS Module for these vehicles that causes them to malfunction. This issue affects thousands of Ram vehicles. The chip in the module that is defective is no longer being produced, and Stellantis is unable to provide replacement ABS modules at the rate they are needed. Thousands of these trucks are driving around with no ABS, T/C, etc or are sitting in shops waiting for a new module, as they will not pass state safety inspections. Stellantis will not acknowledge there is a design flaw with these modules, even though they have been listed as being under "Engineering Review" for multiple years. Due to the critical vehicle systems that are impacted, these ABS Modules must be recalled.

NHTSA ID

11705921

Incident

Mar 1, 2025

FAILURE IN ABS CONTROL MODULE. NO NEW REPLACEMENTS AVAILABLE AND NO AFTERMARKET PARTS AVAILABLE. HAVE BEEN UNDER ENGINEERING REVIEW DUE TO COMPONENT FAILURE WITH NO RECALLS ISSUED. IT CONTROL MY ANTI-LOCK BRAKES AND ELECTRONIC STABILITY CONTROL. IT ALSO DISABLES MY 4WD AND TRAILER BRAKE SYSTEM. ACCORDING TO THE DEALER, NO ETA ON A POSSIBLE RETURN OF STOCK. I AM PULLING CODE C2200-49 WHICH INDICATES AN INTERNAL ELECTRICAL FAILURE OF THE COMPONENT. I HAVE BEEN DEALING WITH THIS ISSUE FOR ALMOST 2 1/2 YEARS.

NHTSA ID

11698969

Incident

Mar 12, 2023

Ram trucks have a known problem with the ABS module. When this system fails the truck loses it traction control. It has been known for years, but Ram truck continually states it's under engineering review. Per the dealer in Jacksonville, FL., there is no solution and no parts to fix this issue. My truck only has 61,000 miles and I've lost my ABS, traction control, cruise control, and 4-wheel drive.

NHTSA ID

11697731

Incident

Nov 5, 2025

The Antilock Brake Module (part # 68228991AD) and Antilock Brake Hydraulic Pump (part # 68196033AA) have failed for no apparent reason. The dealer states there's a national backorder for the module with no delivery date noted. The module controls the anti lock braking system, traction control, and cruise control, which are all safety concerns. The module cannot work without the associated pump. This problem has been confirmed by two dealerships and an independent service center. There were no warnings prior to the failure, which occurred on 10/18/25. The cost of the pump is $1290 from the dealership, which is outrageous. There are remanufactured modules and pumps out there, but they are outrageously priced. I'm thinking about going the remanufactured route to address the safety concerns this causses though.

NHTSA ID

11696313

Incident

Oct 18, 2025

The Starter of the truck seems to have "shorted" and started an electrical fire that burnt the wiring harness leading up to the battery including part of the battery cover. Drove truck on 100 mile trip. Arrived, parked. 2 days later went out to truck to drive home. Turned key, check engine light came on. Service electronic throttle control light came on. Opened hood, smelled burned smell. discovered battery cover and harnessed burned. Disconnected and removed battery. Had truck towed 100miles home. Went to mechanic who traced the burn down to the starter. He replaced the starter and showed me where the fire started. FYI I called the service manager at Berthod Ram in Glenwood Springs Colorado to ask if they would like to see the Starter, left message. THEY DID NOT REPLY.

NHTSA ID

11694540

Incident

Sep 6, 2025

My 2015 Chrysler Ram EcoDiesel 4x4 has a major safety defect that nearly caused a catastrophic accident and has left me traumatized. The vehicle is currently inoperable, sitting in my driveway with a dead battery and what sounds like a thrown rod after breaking down for the second time on the highway. While driving on Highway 101 in California, towing a horse trailer with live horses, the truck suddenly lost power without warning. I was left struggling to control the vehicle and avoid a crash in high-speed traffic. This was one of the most terrifying experiences of my life. Losing engine power with a loaded trailer on a busy highway could easily have resulted in fatalities — not just for me and my animals, but for other drivers on the road. I was horrified and shaken, and I continue to suffer PTSD from the event. This is the second time the vehicle has broken down under dangerous circumstances. The failure was life-threatening, and it is obvious to me that the engine has now suffered catastrophic internal damage (likely a thrown rod). Recall Issues: I had already received a notice of Recall 22V-406, but when I contacted Chrysler, I was told the parts were not available and they would not buy back my truck. The repair was not released yet, leaving me to continue driving a vehicle I already knew had a serious defect. This delay put me, my animals, and the public at unacceptable risk.

NHTSA ID

11687900

Incident

Dec 23, 2023

I am experiencing ABS issues on my truck. After visiting a local auto parts store to get an OBD scan, the code says it’s a bad ABS module. I called the dealership to share this information and they confirmed the code from the auto parts store is a bad ABS module. They said “oh no, you got that code huh? You’re not the only one.” The reason for my visit was because three lights were illuminated on my dash. The ABS light, the traction control light, and the BRAKE (trailer brake) light. The messages on the dash display say to service the ABS system, service the electronic braking system, and service the trailer brake system. From my research, I have discovered that many people are experiencing this same issue on similar vehicles . So much in fact that the parts for repair are unavailable at the dealership and online warehouses. The cruise control is disabled while experiencing this issue and braking performance is affected while driving. I’m afraid that my brakes will lock up on me in a hard stop event and lead to an incident.

NHTSA ID

11685818

Incident

Sep 8, 2025

For my truck a 2015 Ram 1500 there is a known issue where the ABS module fails and won't allow the driver to use ABS. It's ubiquitous and Chrysler isn't manufacturing or supplying the ABS module anymore. I was told by the Dealer that I should "just buy a new truck" if I want anti-lock breaks. I have children, this is unacceptable. I'm on a wait list for the part now for over 2 years and I'm told that I may or may not actually ever get the part indicating, again, that I should buy a new one for safe braking. Apparently I am one of 100's of people on a list and Ram just recalled 1.5 million trucks with the same issue but not my year range of truck.... Part no: 68228991ad

NHTSA ID

11684417

Incident

Dec 20, 2023

The ABS module has malfunctioned and needs to be replaced. It has been months and the dealership/chrysler is unable to provide parts for the repair.

NHTSA ID

11683996

Incident

Apr 3, 2025

The issue started with ABS, Brake, and Traction Control lights coming on intermittently. Leventually they stayed on all the time. Cruise Control is disabled while these lights are on and the ABS system is obviously not working. The dealership stated that it was the ABS control module and states that the part is discontinued and they advised that they didn't have any more parts in stock in addition to quoting around 3k if they could find one at any other locations. All fuses are working properly. And all codes that are pulled indicate ABS system faults.

NHTSA ID

11678556

Incident

Aug 5, 2025

Power steering went out. There is an open recall for RAM 1500s that mine needs to be added to. I called in March after it happened. Recall Reference Number 11649049. Vehicle was inspected by auto mechanic on Beale Air Force Base and he identified that it should be part of the recall.

NHTSA ID

11676862

Incident

Mar 1, 2025

The electronic power steering component itself is failing. When turning the steering wheel one way the wheel will jerk the opposite direction and be very difficult to turn due to the power steering failing. An indicator light on the instrument panel comes on that states to service the steering control system and then shuts off by itself. This impacts the safety of all those in or around the vehicle when in motion due to steering becoming impossible or next to impossible to control. The vehicle has never been under water nor in the snow to cause any such damage. The problem is continuous and can be reproduced and inspected at any time supporting this claim. The factory has a recall in place for this year model and month range for when this truck was produced but my vin is not showing up as being part of the troubled load. It however does fit all of the criteria outlined by the manufacture and current issued recall.

NHTSA ID

11669552

Incident

Jun 22, 2025

I am experiencing electric-power-steering problems on my 2015 Ram 1500. Although my truck is outside of Recall S19, I understand Recall VB9 / TSB 19E-077 allows dealers to inspect the eps gear serial number for contamination. I am formally requesting that my vehicle be inspected under this bulletin and that goodwill assistance be provided if the EPS gear is contaminated. Please advise next steps.

NHTSA ID

11667265

Incident

May 17, 2025

Unknow

NHTSA ID

11664991

Incident

May 1, 2024

I have a 2015 Ram 1500 Laramie that I've owned for just over a year. I have already had to replace the EPS rack and pinion once, due to losing all power steering while driving with my kids. I paid $1,800 for the rack and pinion with a limited warranty. The warranty is now up and I am having to buy another rack and pinion from $1,800-$2,500. When I was driving my kids to school, my steering wheel completely locked up and I could not control my vehicle. This has been an ongoing issue and my truck has been inoperable for three weeks. MOPAR is selling dangerous vehicle that are not road worthy that endanger not only my family's lives, but those also on the road. This issue needs fixed, because I am now paying for a vehicle that is unsafe and is putting me in financial hardship. The issue has been confirmed by a mechanic shop to be the EPS rack and pinion system. There was zero warning each time this has occurred, I just lost complete control of my vehicle without warning.

NHTSA ID

11657010

Incident

Apr 2, 2025