2022 Tesla Model Y Other / unspecified Problems

"I have a Tesla Model Y that experienced what looks like a steering malfunction, with documented data and repair records already in hand. "While driving our 2024 Tesla Model Y when the steering wheel suddenly turned itself, hard left, and driver couldn't regain control. The car went up a hillside, between a utility/ electricity pole and an electrical box, coming to a stop just inches from the pole. No injury, but real vehicle damage." "I pulled Tesla's own vehicle data log for that exact moment. It shows the steering angle went from +362° to -358° — basically two full wheel rotations — in about 1.5 seconds, while the torque sensor barely registered any force. Then the wheel stayed pinned at full-left lock for about 8 seconds while the car was actively accelerating in Drive." There was a fault code 14 mention in the data file right before the incident. "Tesla told us their review of the data showed 'no malfunction.' But afterward, Tesla's own repair records show they replaced the steering gear assembly and the drive unit — after we complained the steering felt stiff once we got the car back from the first repair."

NHTSA ID

11748516

Incident

Jun 5, 2026

Model Y (VIN: [XXX]). On XXX, I brought my vehicle to Tesla Service for replacement of the front wheel hub assembly and paid approximately $1,000 for the repair. Shortly after picking up the vehicle, I noticed abnormal knocking and clicking noises while turning the steering wheel. Because I was concerned about the safety of the vehicle, I sought a second opinion from an independent repair facility. On XXX, the independent shop inspected the vehicle and found that two wheel hub mounting bolts had not been properly tightened and that one mounting bolt was completely missing. The repair invoice states that the vehicle was being operated in an unsafe condition and that continued operation could have resulted in wheel hub failure and a serious accident. The shop corrected the condition by replacing the missing bolt and properly tightening the wheel hub assembly. I incurred an additional expense of $284.47, which would not have been necessary had the original repair been completed properly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11743366

Incident

Jun 6, 2026

While driving, the vehicle displays a critical “Air pressure in tires very low — pull over safely” alert. When I pull over and inspect, the tire pressure is normal and there is no flat. The alert clears on its own after driving a few more miles. The vehicle has been serviced four times for this issue between February and May 2026 at Tesla service centers in Austin TX, Flower Mound TX, San Diego CA, and Los Angeles CA. The tire pressure monitoring sensors have been replaced three times (rear left twice, front left once). On the May 7, 2026 San Diego service visit, the technician documented the root cause as a low voltage issue with the sensor system. The issue continues to recur after each repair. A false critical safety alert that instructs the driver to pull over creates a safety risk because it trains drivers to distrust real alerts, and pulling over on highways carries its own risk.

NHTSA ID

11737798

Incident

Feb 6, 2026

The contact owns a 2022 Tesla Model Y. The contact stated that while charging the vehicle or using the onboard navigation system to search for a charging station, the entire infotainment central processing unit shut down unintendedly. The contact stated that there was an abnormally low humming sound, and approximately 30-seconds later the infotainment screen shut down unintendedly. The contact had taken the vehicle to a local dealer where the battery and the coolant system were checked. The contact was advised by the dealer that they were not able to isolate the failure and needed to run additional diagnostic testing. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 22V296000 (Back Over Prevention, Equipment); however, when the dealer was contacted about the recall, the contact was advised there was no recall associated with the VIN. The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.

NHTSA ID

11719376

Incident

Jan 9, 2026

Mileage

70,000 mi

While driving, the front left brake caliper detached, causing immediate damage to the wheel and a tire blowout. There was no recent brake, wheel, or suspension service (over two years). Tesla is repairing the vehicle for an estimated $2,336.41 but did not clearly identify root cause. This was a sudden brake system failure that could have resulted in loss of control. I am reporting this as a potential safety defect.

NHTSA ID

11716035

Incident

Feb 5, 2026

Tesla Collison Center Denver - returned vehicle with bent wheel after an accident They refuse to repair despite safety risk They are now Blocking my access to service of fixing my car for unrelated issues as well. This bent wheel may result in an unsafe vehicle on the road

NHTSA ID

11700424

Incident

Feb 3, 2023

The contact owns a 2022 Tesla Model Y. The contact purchased aftermarket rubber floor mats, and the floor mat on the driver’s side was warped and had started to block the contact from depressing the accelerator pedal. The contact stated that after removing the foot from the accelerator pedal to depress the brake pedal, and then switching back to depress the accelerator pedal, it was more difficult than normal due to the warped floor mat blocking the accelerator pedal. The manufacturer was informed of the failure and replaced the floor mats twice; however, the second set of floor mats was also warped. The failure mileage was approximately 85,000.

NHTSA ID

11697850

Incident

Sep 6, 2022

Mileage

85,000 mi

The Tesla model Y Performance has a tire wear problem that causes uneven wear and creates cupping that occurs within 7500 miles of tire wear. There is also a weird sound even when you have new tires on the vehicle. The noise grows as your speed goes up it is almost painful at 70mph. It is a known issue and Tesla refuses to address the problem even though they are aware of it. This cupping issue creates a loud noise within the vehicle and reduces the tire mileage to under have of the rated mileage. I have taken my model Y in three times and while they state they are unable to work on the noise unless I replace my tires. I believe there is other problems with the suspension because of the noise the model y make regardless of the cupping.

NHTSA ID

11694842

Incident

Oct 13, 2025

I initially brought my car in for a weird clicking noise. This noise went away after the car was towed to the Service Center. During service at Tesla Service Center in LA on August 04, 2025, technicians identified structural deformation of the left-hand rear subframe toe link mounting side wall. This deformation prevents proper alignment of the suspension bolt and makes a 4-wheel alignment impossible. Tesla refused warranty coverage, claiming “impact damage,” citing only cosmetic wheel rim scrape as evidence. However: 1. Torque paint marks remain intact, proving the bolt has not shifted since factory assembly. 2. No collateral suspension damage (control arms, bushings, underbody) was found, which would normally occur if an impact strong enough to bend a subframe ear had happened. 3. This failure mode is nearly identical to Tesla’s prior recall (21V-835 / 23V-235) on the front suspension lateral link bolts, which involved subframe mounting holes deforming and preventing proper alignment. Safety Concern: The subframe is a critical structural component of the suspension system. Deformation at the toe link mounting point risks the following issues: improper suspension geometry, loss of wheel alignment, reduced vehicle stability and tire wear, and potential sudden loss of control in emergency maneuvers. Tesla has declined to repair this under warranty, leaving the defect unresolved. I believe this represents a potential systemic defect in the rear subframe design, similar to the previously acknowledged front subframe defect.

NHTSA ID

11683017

Incident

Aug 4, 2025

I have only driven my car for 10k miles in past 2 years. I have been on 3 long trips only. Every trip has become scary because one or the other tire turns flat right on busy highways with my little kids in it. I have had one replacement and two repairs on the only long trips I made. No other car I have have had any flat tires till date on the same routes in past 10 years. Tesla vehicles are heavy and they make tires prone to this posing a safety hazard. Tesla should either publicly announce this or give some solution since if known no one would want to take this vehicle with this kind of risk. I have asked tesla technicians and it seems it does not matter what company's tire it is.

NHTSA ID

11613205

Incident

Aug 31, 2024

My Tesla model Y performance 2022 was purchased on September 26, 2022. I found that the left rear wheel was leaking in July 2023. After other tire repair shops failed to find the cause of the leak, I went to the Alhambra Tesla service center for further inspection. They found that my wheels rims had cracks that caused the tire to leak very slowly. These cracks are invisible to the naked eye (I still have this wheel rim at home). During my negotiation with this Tesla service center, they told me that it was my use that caused the wheels rims to crack, and they would not be responsible for the wheels rims. I disagreed with their decision and bought a new WHEEL RIM at my own expense. I use this car for work. I have never driven this car for strenuous exercise or to steep mountains. This is my vehicle usage scenario. In February 2024, the same situation occurred on my right rear wheel. My wheel began to leak slowly and I couldn't find the reason. After multiple inspections, Tesla service center found that there was a very small crack in the right rear wheel rim. The conclusion of TESLA SERVICE CENTER is still that my use caused the crack of the wheel rims. TESLA MODEL Y PERFORMANCE is a high-performance sports car. The wheels rims are specially made 22 inches and are produced by the original factory. There have been many cases of wheels rims cracking in 18 months. I hope to attract your attention and conduct product quality inspections, which is very important for safety.

NHTSA ID

11591439

Incident

Nov 17, 2023

I was sideswiped by another vehicle which just joined our direction of traffic coming out of a cutout. As soon as I saw the vehicle moving fast from inside the cutout to join our direction and into my lane, I immediately decided to move to the lane next to me. I was at the leftmost lane at the time. Halfway into the lane I just felt the violent impact of the other vehicle hitting us. My wife and I were shaken so bad, we were shocked and terrified at what just happened and what else might happen to us. I felt like we were travelling on the front wheels with our rear end up in the air. Next thing we knew, the car stopped in front of a tree. Our iphones and the our car's phone called 911. We were pulled out of the car and taken immediately into an ambulance and Orange Global Hospital, where we stayed for about 2 days. X rays, CT Scan and MRI were taken. NOTE: A ROD STICKING OUT FROM THE FLOOR HIT MY WIFE during the accident. This rod was connected to the wheel and was not supposed to be stick out inside the car during an accident! I BELIEVE THAT A DEFAULT IN CAR DESIGN CAUSED THIS ROD TO HIT MY WIFE , WHICH CAUSED SO MUCH PAIN, DOCTORS COMPARED HER BRUISED RIBS TO BROKEN RIBS!!

NHTSA ID

11589809

Incident

Mar 28, 2024

My car met a major accident and the impact was so severe that it was total loss. The car was badly damaged from drive side and it skid at least 100 meters and it turn around And I am aware that Tesla has side airbags also but none of airbag were deployed I tried to contact Tesla support and report this issue but no one from Tesla gave proper Response . If you want I can share the pics of my car and claim details

NHTSA ID

11531477

Incident

May 7, 2023

The 21 inches uberturbine wheel breaks to easy with not too big road holes. It cause the tire to loose air pressure and can cause a serious accident. The machine shop has a lot of them to be repaired. For the money it cost, it should have a better quality wheel.

NHTSA ID

11522567

Incident

Apr 22, 2023

Getting flat tire or leak in tires since day one. There is a gap between tire and rim edge and whenever i drive over a road bump or railroad tracks rims cut into tire and get flat tire. Been to tesla service center 3 times already each time they charge me for service and tires. Yesterday they changed a tire and this morning that exact tire got flat again. Towed to tesla service center and they wont accept the fault and charged me again another 432$.. tire getting blown daili

NHTSA ID

11511052

Incident

Mar 8, 2023

The contact owned a 2022 Tesla Model Y. The contact stated prior to driving the vehicle, he was charging the vehicle due to low electric power. The manufacturer informed the contact to take the vehicle in for service. The contact stated while driving approximately 65 MPH, the computer inadvertently shutdown and the steering wheel was difficult to maneuver. The vehicle then drove off the road, and the contact drove over a grassy area and the curb. The TPMS warning light illuminated. The front axle was completely fractured. The police were not initially on the scene; however, the police arrived the following day. A police report was not filed. There were no injuries sustained. The contact attempted to have the vehicle towed several times, but was unsuccessful; however, the vehicle was finally towed to the dealer. The vehicle was not diagnosed or repaired. After the contact consistently discussed the failure; he was informed by the insurance company that the vehicle was deemed a total loss. The contact received a notification for NHTSA Campaign Number: 22V296000 (Back Over Prevention, Equipment) and related the failure to the recall. The approximate failure mileage was 9,700.

NHTSA ID

11472611

Incident

May 15, 2022

Mileage

9,700 mi

Vehicle was sold to me on 12/23/2021 (winter) in Paramus NJ. Tesla did not notify or otherwise inform me that this Performance Model Y comes with summer tires. A week ago my wife found she had little to no traction on wheels while going to work - she almost had an accident. A friend told me i might have summer tires. Tesla website has no info on this topic. After contact Tesla support they confirmed that this vehicle has summer Tires. I think Tesla is putting drivers in danger by letting them drive off the lot in summer tires during winter months and not informing them of it. Additionally, the summer tires immediately loose warranty when used in temperatures below 40 degrees.

NHTSA ID

11447253

Incident

Jan 5, 2022