2017 Volkswagen Golf R

On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Thermostat Sensor Failure causing check engine light P00B7. Vehicle not reading the correct engine temp causing cooling fans to run at 100% and drivability concern. Dealer diagnosed the repair as replacement of the Thermostat/Thermostat Housing quoted at $1,635. The vehicle has not been inspected by any other party other than dealership. Check Engine line appeared, thermostat not reading proper temp, and cooling fans running at 100% speed. This is a well documented problem with my vehicle: https://www.reddit.com/r/GolfGTI/comments/drna5m/mk775_thermostat_housing_issue_and_coolant_loss/

NHTSA ID

11561868

Incident

Dec 14, 2023

The fuel suction pump in my 2017 volkswagen golf r failed causing strong gas odors to emit whenever the car is running, loss of power, inability to put more than a small amount of fuel in, and gas leaking into the evap and charcoal canister causing them to fail. This creates a huge risk for ignition and fuel dumping onto the road which, only because I stopped driving it, has not happened to me. A check engine light has still yet to appear even after part failure. I believe you can see how big of a safety risk this causes to not only the vehicle's occupants, but those around it as well. I have already taken it to the volkswagen dealer and they themselves confirmed that yes the fuel suction pump has failed and that all those parts and the fuel tank itself need replaced totaling around 3,500 to 4,000 dollars. I have not gotten anything replaced. They refuse to cover it under the warranty extension titled VWP22-12 even though my car is obviously not 15 years old and it only has around 37,000 miles. They claim they revised the part for 2017 so that it doesn't fail anymore, but if that were the case then why is that warranty extension all the way up to 2020 models. I have looked through other complaints filed on this site and see you've already been contacted several times about my exact issue on 2017 models. I am urging you to please make this a recall. Volkswagen clearly knows this is a widespread issue evidenced by the fact the it affects such a large amount of models and years and by not making a recall you are allowing them to screw people over.

NHTSA ID

11560614

Incident

Sep 1, 2023

My VW on two occasions experienced coolant / water pump system failures (May 2022 and August 2023), the second of which required full water pump replacement. These are identical to the class action lawsuit outlined on https://waterpumpsettlement.com/ (civil court case Civ. No.: 2:21-cv-11251-MCA-MF), though I am receiving difficulties with the settlement claim for unknown reasons. My vehicles water pump is identical to those outlined in the case, as the pump model numbers and OEM origin are identical. These two incidents posed a severe risk/hazard to both the vehicle and myself due to leakage and loss of coolant putting the car at risk of catatrosphic engine failure. It is becoming apparent that these should amount to a recall as the growing number of incidents keeps increasing.

NHTSA ID

11537264

Incident

Aug 7, 2023

The shift boot trim piece was poorly designed and is the metal is peeling and has cut my hand several times. It has happened once while driving and I had to stop at a gas station to get a paper towel to stop the bleeding. The trim piece peels right where the opening to the storage cubby is. The dealer is aware of the situation, but will not cover the cost of replacing the part.

NHTSA ID

11448803

Incident

Jan 3, 2022

The contact owns a 2017 Volkswagen Golf R. The contact stated that the fuel gauge remained on Empty after fueling the vehicle. Additionally, fuel accumulated in the EVAP system, and leaked out from the fuel tank onto the rear passenger's side wheel. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but informed the contact that recalls were VIN specific and there was no recall associated with the VIN. The contact related the failure to NHTSA Campaign Number: 16V647000 (Fuel System, Gasoline, Engine and Engine Cooling) however, the VIN was not included in the recall. The failure mileage was approximately 38,000.

NHTSA ID

11447546

Incident

Jan 13, 2022

Mileage

38,000 mi

While driving in the left hand lane on a divided 4-lane (2 lanes each direction) road, a car in front of me slowed in order to make a left hand turn. I braked to slow, looked and saw space in the adjacent lane, moved into that lane and pressed the accelerator to get to the speed of the approaching traffic in that lane. There was no throttle response at first so the approaching traffic was quickly closing the gap. I lifted my foot off the accelerator and then immediately pressed it again at which the throttle responded and I was able to accelerate to the speed of the approaching traffic (in this case a large dump truck) and narrowly avoided a rear-end collision. I have complained of this kind of throttle response hesitation at service visits to two different VW dealers, both of which were unable to reproduce the condition and for which they detected no error codes. I bought the car as a used car in Feb 2019. The VW dealership from which I bought the car did not disclose any such problem with the car, which car they claimed to have provided service for the previous owner. The problem has occurred intermittently since I have owned the car and I have been unable to reproduce it successfully for service personnel during service visits. Today's occurrence was the closest I have come to a collision with another vehicle. With the next occurrence I might not be so lucky.

NHTSA ID

11427052

Incident

Jul 29, 2021

THE INFOTAINMENT SYSTEM RANDOMLY RESETS DURING USAGE REGARDLESS OF WHAT MODE THE SYSTEM IS IN (BOTH IN TERMS OF DRIVE MODE OR MUSIC LISTENING MODE). DURING A RESET, ALL ACCESS TO ADVANCED SAFETY FEATURES, DRIVE MODE SELECTION, TRACTION CONTROL SELECTIONS, ARE DISABLED. THE SCREEN GOES COMPLETELY BLACK AND THEN TURNS BACK ON USUALLY WITH A DIFFERENT INTERFACE MODE ACTIVATED (BLUETOOTH VS RADIO, FOR INSTANCE). ALL STEERING WHEEL CONTROLS ARE DISABLED DURING A RESET. THIS FREEZE AND RESET CAN OCCUR WHILE MOVING OR WHILE STATIONARY. ADDITIONALLY, THE RE-VIEW CAMERA, WHILE IN REVIEW, DOES NOT WORK IF THE RESET TAKES PLACE WHILE BACKING UP. THE REVIEW CAMERA ALSO INCONSISTENTLY WORKS AT ALL. THE RESET HAS TAKEN PLACE AT BOTH SURFACE STREET SPEEDS BUT ALSO AT HIGHWAY SPEEDS.

NHTSA ID

11404320

Incident

Mar 21, 2021

Mileage

35,300 mi

PCV (POSITIVE CRANKCASE VENTILATION) VALVE MALFUNCTION. VW'S PCV VALVE, ALSO SOMETIMES CALLED THE OIL SEPARATOR VALVE, WHICH IS FOUND ON MANY OF THEIR CARS/SUVS BECOMES FAULTY AROUND 40-50K MILES. WHAT OFTEN HAPPENS IS THE THE VALVE FAILS TO VENT INTERNAL ENGINE PRESSURE, WHICH CAUSES THE PRESSURE TO BUILD UP WITHIN THE ENGINE. EVENTTUALLY THE PRESSURE WILL FIND SOME PLACE TO VENT, USUALLY OUT OF WEAKEST OIL GASKET POINT, OFTEN BEING THE REAR MAIN SEAL AND VALVE COVER. SINCE THE EXHAUST IS BEHIND THE ENGINE, THERE IS A CHANCE THAT OIL CAN SPRAY ONTO THE HOT EXHAUST. MY GOLF LEAKED OIL FROM THE REAR MAIN SEAL WHEN THE PCV FAILED. EVEN THOUGH THE CAR WAS UNDER WARRANTY, VW DIDN'T WANT TO DIAGNOSE THE PROBLEM UNLESS I WAS WILLING TO PAY FOR IT. THIS MALFUNCTIONING PCV VALVE IS A REGULAR PROBLEM ON VW'S AND COULD POSE A ROOT FAILURE LEADING TO A POTENTIAL VEHICLE FIRE.

NHTSA ID

11351518

Incident

Dec 19, 2019

Mileage

48,000 mi

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards