2000 Volkswagen Jetta Owner Complaints

The contact owns a 2000 Volkswagen Jetta. The contact stated that while driving with the front driver’s side seat heater activated, the seat became extremely hot. The contact started smelling a burning odor coming from the seat. The contact felt a hole in the seat, which burned the contact's middle finger. The contact immediately pulled over and turned off the vehicle. The contact’s back started burning due to the extreme heat of the seat back. Upon inspection, the contact discovered a hole in his jacket and approximately four holes that had formed in the front driver seat due to the seat heater failure. The contact was not treated for the burns to his back. The contact stated that two dealers were notified of the failure but neither provided immediate assistance. The manufacturer was also notified of the failure and informed the contact that there were no recalls on the vehicle. The vehicle was not repaired. The failure mileage was approximately 489,000.

NHTSA ID

11617892

Incident

Oct 3, 2024

Mileage

489,000 mi

I PURCHASED THIS VEHICLE RECENTLY AND HAVE NOTICED A DISTINCT DIESEL SMELL WHEN IDLING OR DRIVING AT LOW SPEEDS. SMELLS STRONG LIKE LEAKING DIESEL FUEL. THE CAR IDLES VERY ROUGH AND SOMETIMES STALLS WHEN COMING TO A STOP. THERE IS A VERY BAD ODOR WHENEVER I ENTER THE VEHICLE. I AM CONCERNED THAT THE CAR WILL STALL AND I MIGHT BE IN AN UNSAFE POSITION DURING TRAFFIC. I THINK THE CLUTCH MIGHT BE DEFECTIVE. IT SOUNDS VERY LOUD. THE VEHICLE HAS 260,000 MILES. DIESLS ARE SUPPOSED TO RUN FOREVER BUT I FEEL LIKE I BOUGHT A LEMON.

NHTSA ID

11337826

Incident

Jul 1, 2020

Mileage

260,000 mi

VEHICLE COMPLETELY STALLS FOR SEVERAL SECONDS SPORADICALLY WHENEVER THE FUEL GUAGE READS 3/8 OR LESS. BOTH MY VW CAR DO THE EXACT SAME THING. IT IS COMMON KNOWLEDGE THIS OCCURS WITH MOST VW CARS. EXTREMELY UNSAFE AND SHOULD BE RECALLED.

NHTSA ID

11255699

Incident

Sep 15, 2015

Mileage

170,000 mi

MY VEHICLE KEPT OVER HEATING URNS OUT IT WAS THE COOLING SYSTEM I HAD TO REPLACE THE WATER PUMP AND I HAD TO REPLACE THE TIMING BELT AND RADIATOR..

NHTSA ID

11128441

Incident

Aug 22, 2018

Mileage

135,658 mi

2000 VOLKSWAGEN JETTA. CONSUMER WRITES IN REGARDS TO ENGINE AND WARNING LIGHTS COMING ON. *LD THE CONSUMER STATED THE DAY AFTER PURCHASING THE VEHICLE THE ENGINE, ABS, AND TRACTION CONTROL LIGHTS, ILLUMINATED. THE DEALER OFFERED TO REPAIR THE VEHICLE IF THE CONSUMER BOUGHT THE PARTS. THE CONSUMER DECLINED. *JS

NHTSA ID

11091809

Incident

Mar 22, 2018

I WAS DRIVING IN TRAFFIC AROUND 35 MPH. SAW SMOKE IN MY REARVIEW MIRROR SO IMMEDIATELY PULLED OFF TO SIDE OF ROAD. THE CAR WASNT OVERHEATING, AND NO WARNING LIGHTS CAME ON UNTIL AFTER I BEGAN SLOWING DOWN TO PULL OVER. AS I STOPPED AND TURNED OFF THE CAR, I REALIZED THE ENGINE COMPARTMENT WAS ON FIRE, I GRABBED MY PHONE AND CALLED 911 AS I GOT AWAY FROM THE VEHICLE. *TR

NHTSA ID

10947693

Incident

Jan 25, 2017

Mileage

192,000 mi

WENT TO BUCKLE UP AND HEARD A NOISE. LOSS AT TENSION ON SEAT BELT.

NHTSA ID

10924987

Incident

Nov 1, 2016

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. WHILE DRIVING 80 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS MANEUVERED TO THE SHOULDER OF THE ROAD AND TOWED BACK TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 245,000.

NHTSA ID

10873602

Incident

Jun 3, 2016

Mileage

245,000 mi

WATER PUMP AND BACK HOUSING THE COOLANT SYSTEM

NHTSA ID

10819243

Incident

Dec 6, 2015

I OWN A 2000 VW JETTA. MY SON AND I WERE HEADING HOME AFTER A COLLEGE VISIT, HE TURNED ON HIS SEAT HEATER AND BEGAN TO NAP. 20 MINUTES LATER, HE POPPED UP RUBBING HIS SHOULDER, THE SEAT HEATER CAUSED THE SEAT TO CATCH FIRE AND BURNED A PORTION OF THE SEAT, HIS SHIRT AND SHOULDER. I CALLED THE DEALER AND WAS TOLD THEY'VE NEVER HEARD OF THAT ISSUE AND THAT THERE HAS NEVER BEEN A RECALL FOR SUCH AN ISSUE. I THEN DID AN INTERNET SEARCH AND FOUND WHERE IT'S A VERY COMMON ISSUE. *TR

NHTSA ID

10682887

Incident

Feb 10, 2015

Mileage

297,000 mi

BRAND NEW TIRE COMPLETELY FAILED AT HIGHWAY SPEED. THIS TIRE WAS 7 DAYS OLD AND THERE WAS A TOTAL SIDEWALL FAILURE. LOOKING ONLINE AFTER THE INCIDENT, THERE ARE COUNTLESS COMPLAINTS OF THE SAME ISSUE. *TR

NHTSA ID

10676345

Incident

Jan 7, 2015

I OWN A 2000 VW JETTA 2.0 GLS AUTOMATIC. I WAS COASTING DOWN A HILL AND COMING TO A STOP. I STARTED USING MY BRAKES AND ALL OF A SUDDEN WITH OUT ANY WARNINGS CHIMES OR INDICATION MY CAR COMPLETELY SHUT OFF, BRAKES AND STEERING WHEEL FELT LOCKED UP AND I ALMOST CRASHED IF NOT FOR MY FRIEND HELPING ME MOVE MY STEERING WHEEL TOWARDS A SIDE STREET TO FIGURE OUT WHAT HAPPEN. CAR WOULD NOT RESTART. ONLY AFTER AN HOUR OR SO OF WAITING FOR A TOW TRUCK DID MY CAR START BUT WAS DIFFERENT. THIS HAPPENED TO ME 4 MORE TIMES. LAST TIME THIS HAPPENED I WAS ON MY WAY HOME FROM NEW JOB AT AROUND 2 AM EST I GOT LOST AND CAR STALLS OUT ON ME WITH NO INDICATION AND IT DOES NOT JUST STALL AND STOP IT STALLS AND CONTINUES TO ROLL UNTIL YOU LOOSE MOMENTUM THIS IS NOT SAFE. THANKFULLY THIS PROBLEM DID NOT HAPPEN TO ME WHILE ON A HIGH WAY THIS PROBLEM COULD CAUSE SERIOUS INJURY OR EVEN DEATH IF ONES CAR STALLS AND THEY CAN NOT CONTROL IT. I TOOK THE CAR TO MY MECHANIC AND CONFIRMED BAD COIL PACK AND CRANK POSITION SENSORS. *TR

NHTSA ID

10608272

Incident

Apr 2, 2014

Mileage

119,892 mi

BRAKE LIGHTS DON'T FUNCTION DUE TO FAULTY BRAKE LIGHT SWITCH. SUBJECT OF TWO PREVIOUS RECALLS. *TR

NHTSA ID

10605363

Incident

Jun 23, 2014

Mileage

194,000 mi

WAS DRIVING DOWN THE ROAD, WHEN MY JETTA LOST COMPLETE POWER. I MANAGED TO STEER OF THE ROAD, PUT VEHICLE IN PARK AN TURNED THE KEY OFF, THEN SMOKE STARTED POURING OUT FROM UNDER MY HOOD. RAISED THE HOOD TO ONLY SEE FLAMES! THANK GOD A GENTLEMAN STOPPED AN HAD GALLON OF WATER. HAD THE VEHICLE TOWED TO MY HOUSE(3 MILES) AN THERE IT SITS! MOST THE DAMAGE IS CONTAINED TO THE TOP OF THE MOTOR ON THE DRIVERS SIDE. THE CAR WASN'T EVEN OVER HEATING!! THE ONLY ISSUE IV HAD IN THE YEAR IV OWNED IT IS THE TRANSMISSION SEEMED TO NOT GO PAST THIRD GEAR, WHICH CAUSED THE RPM TO RISE, OF COURSE... HONESTLY ,JUST THANKFUL A STRANGER STOPPED...SIGNED, WITH OUT A CAR. *TR

NHTSA ID

10596046

Incident

Apr 29, 2014

Mileage

141,000 mi

ONE YEAR AFTER PURCHASING THIS VEHICLE FROM A PRIVATE OWNER, TODAY WAS THE SECOND INCIDENT I'VE HAD REGARDING THE CLUTCH AND THE FUMES IT EMITS. SIX MONTHS AGO I NOTICED THE CLUTCH SLIPPING AND IMMEDIATELY TOOK IT INTO A REPAIR SHOP. ON TOP OF THE SLIPPING CLUTCH, THE COOLANT AND EMISSIONS WORKSHOP AND ELECTRICAL BECAME A PROBLEM. "STOP COOLANT LOW" WOULD ALWAYS APPEAR ON MY DASH, HOWEVER THE COOLANT WOULD BE FILLED. THE ENGINE LIGHT ALSO STAYED ON. THE MECHANIC DID ALL HE COULD TO FIX IT. SIX MONTHS LATER, TODAY, I'M HAVING THE SAME ISSUE WITH THIS VEHICLE. ONLY DIFFERENCE IS, I IMMEDIATELY BECAME ILL WHILE DRIVING AND BREATHING IN THE FUMES THE VEHICLE EMIT. I BECAME NAUSEA, DIZZY AND VOMITED. THIS ISSUE REGARDING THE CLUTCH IS AN ONGOING DIGRESSION TO THE VEHICLE AND THE SAFETY AND HEALTH OF MYSELF AND OTHER DRIVERS. I HOPE VW WILL TAKE THIS SERIOUSLY AND INVESTIGATE THIS CASE, I HAVE FRIENDS WHO'VE ALSO EXPERIENCE SIMILAR INSTANCES WITH THEIR VW VEHICLES. I HOPE TO GET MINE AND ALL VEHICLES WHO HAVE DISPLAYED SIMILAR ISSUES REPAIRED PROPERLY BY THE CORRECT MECHANICS BEFORE ANYONE ELSE BECOMES SUDDENLY ILL LIKE I HAVE TODAY. *TR

NHTSA ID

10520011

Incident

Jun 16, 2013

Mileage

127,000 mi

HEAT SEAT CONTROL AT 5 ONLY AVAILABLE. AFTER A NUMBER OF TIMES STARTED BURNING SEATS. LEATHER IS MELTED. NO LONGER USE. *TR

NHTSA ID

10513956

Incident

Mar 1, 2013

Mileage

41,000 mi

FOUR NEW CONTINENTAL CONTIPROCONTACT TIRES WERE PURCHASED AND INSTALLED ON MY 2000 VW JETTA. AFTER APPROX. 2 DAYS, ONE TIRE WENT FLAT WHILE DRIVING AT LOW SPEEDS. TIRE SENT TO SELLER, AND THEY PRONOUNCED IT WAS AN INSTALLATION ISSUE. THIS TIRE WAS SENT TO SELLER, AFTER PURCHASING A NEW ONE. AFTER 4 TO 5 WEEKS OF DRIVING, A SECOND TIRE (DIFFERENT WHEEL) FROM THE SAME ORIGINAL SET OF 4, FAILED SUDDENLY. THIS TIRE "SUDDENLY" FAILED WITH A "GUN SHOT" LIKE NOISE WHILE THE VEHICLE WAS STATIONARY. REVIEW AT THE SERVICE SHOP SHOWED NOTHING UNUSUAL IN THE INSTALLATION. PICTURES OF THE SECOND TIRE WERE SENT TO THE MANUFACTURER, AND THEY COMMENTED THAT THIS WAS AN INSTALL ISSUE. I WORK FOR AN AUTOMOTIVE ENGINEERING COMPANY, AND HAD ONE OF OUR EXPERT TECHNICIANS REVIEW THE SECOND TIRE. HE HAS 30 YEARS OF SERVICE EXPERIENCE WITHIN CHRYSLER DEALERSHIPS. HE WAS CONVINCED THAT THIS WAS A TIRE DEFECT, HAD NEVER SEEN SUCH A FAILURE, AND STATED THAT THIS TYPE OF FAILURE WOULD NOT HAPPEN DURING INSTALLATION. THIS WAS BASED ON THE LOOSE CONDITION OF THE STEEL RING ON THE INNER TIRE, AND THE FACT THAT THEIR WERE NO WITNESS TOOL MARKS ON THE OUTSIDE OF THE TIRE. THE ORIGINAL INSTALLER OF THE TIRES ALSO STATED THAT THE RUBBER ON THE INNER BEAD OF THE TIRE WAS "TOO THIN" AND OF POOR CONSTRUCTION. I HAVE THE SECOND TIRE IN MY POSSESSION, AND HAVE REQUESTED THE ORIGINAL FIRST TIRE BACK FROM THE SELLER. I HAVE NOT YET RECEIVED THIS, NOR HAVE I RECEIVED ANY FORMAL CONCLUSIVE REPORT WITH MEASUREMENTS AND ANALYSIS TO PROVE THEIR CONCLUSION. RIGHT NOW THEY ARE ONLY STATING THEIR PERSONAL OPINION, WITHOUT THOROUGH ANALYSIS. I AM STILL DRIVING ON THE REMAINING TIRES WITH AN "UNEASY" FEELING THAT I AM AT RISK OF ANOTHER CATASTROPHIC FAILURE. I AM ONLY AFTER THE TRUTH IN THIS MATTER, AND UP TO NOW HAVE FELT AS THOUGH IT HAS NOT BEEN PRESENTED. I DIDN'T CREATE THIS FAILURE, AND I HAVE A HARD TIME SEEING HOW THE INSTALLER, WHO DOES THIS FOR A LIVING, COULD HAVE DONE IT TO 2 TIRES. *TR

NHTSA ID

10484518

Incident

Nov 8, 2012

Mileage

120,318 mi

THE DRIVER SIDE SEAT NO LONGER STAYS IN A LOCKED POSITION, AND THE SEAT MOVES FREELY, SLIDING FROM BACK TO FRONT, MAKING CONTROL OVER THE VEHICLE'S PEDAL VERY DIFFICULT AND DRIVING HAZARDOUS. AFTER INSPECTING UNDERNEATH THE SEAT, A LARGE COILED PIECE OF METAL WAS FOUND LYING ON THE CARPET. THIS PIECE OF METAL MATCHES EXACTLY ANOTHER PIECE OF METAL THAT FELL OUT FROM THE BOTTOM OF THE PASSENGER SEAT OVER SIX YEARS AGO. I CONTACTED THE DEALER, (FRESNO MICHAEL AUDI VW) TO HAVE THEM REPLACE THE PART BACK INTO THE SEAT SO THAT THE SEAT NO LONGER MOVED FREELY AND THE SERVICE MANAGER REFUSED TO CARRY OUT ANY SUCH WORK ON MY VEHICLE. AFTER SPEAKING WITH TWO OTHER EMPLOYEES OF MICHAEL AUTOMOTIVE AND GETTING THE SAME REFUSALS EACH TIME, I ABANDONED THE ATTEMPT TO SOLICIT THEIR HELP IN REPAIRING MY VEHICLE. *TR

NHTSA ID

10483322

Incident

Aug 31, 2012

Mileage

110,839 mi

HAD THE CAR CLEANED AND WHEN I GOT THE CAR BACK THE SEAT ADJUSTMENT WOULD NO LONGER WORK. IT HASN'T WORKED SINCE. THE SEAT SLIDES FORWARD AND BACK AT WILL. *JS

NHTSA ID

10455680

Incident

Apr 6, 2011

Mileage

160,000 mi

CAR WILL NOT START AFTER BEING DRIVEN FAR ENOUGH TO WARM-UP THE ENGINE. MUST WAIT SEVERAL MINUTES--UP TO AN HOUR--BEFORE IT WILL START AGAIN. THE PROCESS OF TRYING A RESTART RESULTS IN MUCH UNBURNED FUEL VAPOR IN THE EXHAUST STREAM. THE INTERIOR LIGHTING DOES NOT TURN ON OR OFF WITH THE OPENING OF A DOOR. HORN DOES NOT SOUND WHEN LOCKING THE CAR, AUTO-DRIVERS SEAT POSITIONING DOES NOT WORK. ON THE HIGHWAY, THE CAR PERFORMS QUITE WELL--GOOD ENGINE POWER, STEERING, ETC. HOWEVER, THE NON-STARTING AFTER BEING DRIVEN A DISTANCE COULD RESULT IN BEING STRANDED AND PLACED IN DANGER. *TT

NHTSA ID

10446012

Incident

Mar 10, 2010

Mileage

84,000 mi

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE HAZARD LIGHTS DID NOT FUNCTION AND THE BULBS BLEW OUT. IN ADDITION, THERE WAS A CLICKING SOUND PRESENT INSIDE OF THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 04V584000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH), BUT THE VEHICLE WAS PREVIOUSLY REPAIRED. THE VEHICLE WAS NOT REPAIRED A SECOND TIME. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10421348

Incident

Aug 15, 2006

Mileage

100,000 mi

WHILE DRIVING AND LIGHTLY BRUSHING THE BRAKE PEDAL TO BEGIN SLOWING, THE BRAKE PEDAL AUTOMATICALLY ENGAGES FULLY, SLAMMING ON BRAKES UNEXPECTEDLY. IMMEDIATELY FOLLOWED BY A SOUND OF AIR PRESSURE BEING RELEASED. IF YOU PRESS THE BRAKE PEDAL AFTER THE AIR IS RELEASED, THE PEDAL WILL RETURN TO REST AND THE BRAKES WILL FREE UP. NO EXISTING DEALER RECALLS AND VW (AND VW SERVICE DEPARTMENTS) HAVE NO RECORD OF THIS BEING A COMMON PROBLEM. MY LOCAL VW SPECIALTY REPAIR SHOP SAYS THIS IS COMMON ON 2000 JETTA TDI'S. THIS IS A SIGNIFICANT SAFETY ISSUE. IF YOU EXPERIENCE A SIMILAR ISSUE, PLEASE REPORT IT! THERE ARE THREE OTHER ISSUES POSTED THAT APPEAR TO BE RELATED: 10116640, 10139585, 10052281.

NHTSA ID

10407781

Incident

Jun 19, 2011

Mileage

206,000 mi

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE WOULD JERK ABNORMALLY WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING LAMP. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO ADVISED THAT THE MASS FLOW AIR SENSOR FAILED. THE CONTACT HAD RECEIVED NOTIFICATION OF A VOLUNTARY MANUFACTURERS RECALL IN REGARDS TO PRIOR TO THE FAILURE. THE VEHICLE WAS REPAIRED UNDER THE RECALL. LESS THAN FOUR YEARS LATER, THE FAILURE RECURRED. THE MANUFACTURER WAS THEN CONTACTED YET THEY OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 42,000. UPDATED 07/20/11*LJ THE SENSOR LIGHT FOR THE MASS AIR FLOW REPLACED TWICE IN DECEMBER 2007 AND AGAIN IN JUNE 2011. UPDATED 07/25/11

NHTSA ID

10404303

Incident

Nov 3, 2003

Mileage

42,000 mi

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA GLX. THE CONTACT STATED THAT THE DRAINING SYSTEM FOR THE SUNROOF WOULD BECOME CLOGGED AND ALLOW WATER TO DRAIN INTO THE INTERIOR OF THE VEHICLE. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 100,000.

NHTSA ID

10386065

Incident

Mar 1, 2009

Mileage

100,000 mi

TL*THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE WOULD ACCELERATE AND THE RPMS WOULD INCREASE WHEN SHE HAD HER FEET ON THE BRAKE AND THE CLUTCH PEDALS. SHE NOTICED THAT THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 127,000.

NHTSA ID

10366382

Incident

Nov 15, 2010

Mileage

127,000 mi