2000 Volkswagen Jetta

BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.

BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.

THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.

The contact owns a 2000 Volkswagen Jetta. The contact stated that while driving with the front driver’s side seat heater activated, the seat became extremely hot. The contact started smelling a burning odor coming from the seat. The contact felt a hole in the seat, which burned the contact's middle finger. The contact immediately pulled over and turned off the vehicle. The contact’s back started burning due to the extreme heat of the seat back. Upon inspection, the contact discovered a hole in his jacket and approximately four holes that had formed in the front driver seat due to the seat heater failure. The contact was not treated for the burns to his back. The contact stated that two dealers were notified of the failure but neither provided immediate assistance. The manufacturer was also notified of the failure and informed the contact that there were no recalls on the vehicle. The vehicle was not repaired. The failure mileage was approximately 489,000.

NHTSA ID

11617892

Incident

Oct 3, 2024

Mileage

489,000 mi

I PURCHASED THIS VEHICLE RECENTLY AND HAVE NOTICED A DISTINCT DIESEL SMELL WHEN IDLING OR DRIVING AT LOW SPEEDS. SMELLS STRONG LIKE LEAKING DIESEL FUEL. THE CAR IDLES VERY ROUGH AND SOMETIMES STALLS WHEN COMING TO A STOP. THERE IS A VERY BAD ODOR WHENEVER I ENTER THE VEHICLE. I AM CONCERNED THAT THE CAR WILL STALL AND I MIGHT BE IN AN UNSAFE POSITION DURING TRAFFIC. I THINK THE CLUTCH MIGHT BE DEFECTIVE. IT SOUNDS VERY LOUD. THE VEHICLE HAS 260,000 MILES. DIESLS ARE SUPPOSED TO RUN FOREVER BUT I FEEL LIKE I BOUGHT A LEMON.

NHTSA ID

11337826

Incident

Jul 1, 2020

Mileage

260,000 mi

VEHICLE COMPLETELY STALLS FOR SEVERAL SECONDS SPORADICALLY WHENEVER THE FUEL GUAGE READS 3/8 OR LESS. BOTH MY VW CAR DO THE EXACT SAME THING. IT IS COMMON KNOWLEDGE THIS OCCURS WITH MOST VW CARS. EXTREMELY UNSAFE AND SHOULD BE RECALLED.

NHTSA ID

11255699

Incident

Sep 15, 2015

Mileage

170,000 mi

MY VEHICLE KEPT OVER HEATING URNS OUT IT WAS THE COOLING SYSTEM I HAD TO REPLACE THE WATER PUMP AND I HAD TO REPLACE THE TIMING BELT AND RADIATOR..

NHTSA ID

11128441

Incident

Aug 22, 2018

Mileage

135,658 mi

2000 VOLKSWAGEN JETTA. CONSUMER WRITES IN REGARDS TO ENGINE AND WARNING LIGHTS COMING ON. *LD THE CONSUMER STATED THE DAY AFTER PURCHASING THE VEHICLE THE ENGINE, ABS, AND TRACTION CONTROL LIGHTS, ILLUMINATED. THE DEALER OFFERED TO REPAIR THE VEHICLE IF THE CONSUMER BOUGHT THE PARTS. THE CONSUMER DECLINED. *JS

NHTSA ID

11091809

Incident

Mar 22, 2018

I WAS DRIVING IN TRAFFIC AROUND 35 MPH. SAW SMOKE IN MY REARVIEW MIRROR SO IMMEDIATELY PULLED OFF TO SIDE OF ROAD. THE CAR WASNT OVERHEATING, AND NO WARNING LIGHTS CAME ON UNTIL AFTER I BEGAN SLOWING DOWN TO PULL OVER. AS I STOPPED AND TURNED OFF THE CAR, I REALIZED THE ENGINE COMPARTMENT WAS ON FIRE, I GRABBED MY PHONE AND CALLED 911 AS I GOT AWAY FROM THE VEHICLE. *TR

NHTSA ID

10947693

Incident

Jan 25, 2017

Mileage

192,000 mi

WENT TO BUCKLE UP AND HEARD A NOISE. LOSS AT TENSION ON SEAT BELT.

NHTSA ID

10924987

Incident

Nov 1, 2016

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2000 VOLKSWAGEN JETTA. WHILE DRIVING 80 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS MANEUVERED TO THE SHOULDER OF THE ROAD AND TOWED BACK TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 245,000.

NHTSA ID

10873602

Incident

Jun 3, 2016

Mileage

245,000 mi

Update to Volkswagen engine oil standards

Volkswagen Engine oil quality standards, update to attachments.

Engine oil quality standards, update to attachments.

Update model year applicability to include 2023.

Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger. Updated to include additional model year applicability.

Tool number added to table. Removal of Behr Flush Kit. VAS 6337/1A