Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 306 NHTSA owner-reported complaints for the 2022 Volkswagen Taos. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 306 · page 1 of 13
Per VW TSB 15-23-01, Volkswagen explicitly admits that the original engine production head gasket design is defective. A leaking head gasket can cause sudden engine overheating, power loss, or catastrophic engine failure while driving. This seems like a major , dangerous issue that should be covered under a recall
I am submitting this complaint because the driver's seat belt does not fit me properly despite using all available factory adjustments. I am an adult female who is 5 feet 2 inches tall. The driver's seat is adjusted to its highest position, and the shoulder belt height adjuster is set to its lowest position. Even with these adjustments, the shoulder belt crosses and rubs against my neck instead of resting across the middle of my shoulder and chest. This has been an issue since I purchased the vehicle. The discomfort has become increasingly severe over time and now causes me to repeatedly reposition the belt while driving because it presses against my neck. I am concerned that the restraint system does not properly accommodate shorter adult drivers. While the seat belt remains fastened, the fit is poor enough that it creates a distraction during vehicle operation and raises concerns about occupant protection in a crash. I am requesting that NHTSA evaluate whether the seat belt geometry in the 2022 Volkswagen Taos provides an appropriate fit for shorter drivers and whether similar complaints have been reported by other owners.
On 7/9/2026, my 2022 VW Taos was brought to the dealer for being severely underpowered, check engine lights on, and a strong raw fuel smell inside the vehicle. On 7/10/2026, the dealer stated the vehicle was ready, claiming they replaced a turbo charge pipe O-ring. The service advisor verbally stated the vehicle had been successfully test-driven for 5 miles on streets and the highway. However, official paperwork only stated "cleared faults verified no leaks in system, vehicle is now operating as designed." Immediately upon driving home on the highway, as the vehicle reached 70–75 mph under load, a loud whistling noise and a sudden, dangerous loss of propulsion occurred simultaneously. The vehicle was returned to the dealer on 7/10/2026. On 7/13/2026, the vehicle was picked up after a second repair where the dealer admitted the plastic charge pipe (05E-145-673-Q) was actually fractured and had completely blown off the turbocharger during my highway drive, generating fault code P227900 (Intake Air System Leak). Upon reviewing the paperwork from both visits, I discovered the odometer had only increased by exactly 1 mile during the first service visit. The dealer completely failed to road-test the vehicle under actual highway boost loads before certifying it as safe, which directly caused a catastrophic structural engine failure and an emergency safety hazard at 75 mph.
While driving at highway speeds, the a low coolant caution light came on. We immediately pulled over before the engine overheated and added coolant and brought the vehicle in for repairs. This Taos currently has 43,000 miles and needs its head gasket replaced for the SECOND time. The first head gasket was replaced on 12/23 with 16,000 miles under a technical bulletin by VW. This is a know issue for this vehicle. With a head gasket failure, this can lead to engine overheating and seizing. This needs to be a recall.
There have been multiple complaints of the mechatronics unit failing prematurely. I am facing that right now and it should be under warranty but is being challenged. So many people have mentioned the mechatronics unit failing prematurely upon research and discussion with the dealership. The car stalled on the freeway and I was unable to accelerate. It was confirmed and being worked on by the dealer. All regular maintenance has been done. “Trans in emergency mode. You can keep driving.” Showed up 5 minutes before the car stalled
The engine coolant is leaking and the cylinder head gasket is leaking at the back of the engine. This requires full replacement. This is a known issue with Technical Service Bulletin 15-23-01 from Volkswagen back in 2023, and both VW and our Dealership are refusing to cover the costs of replacement.
The contact owns a 2022 Volkswagen Taos. The contact stated that while driving at various speeds, the vehicle unintendedly decelerated. The contact associated the failure with NHTSA Campaign Number: 22V687000 (Engine and Engine Cooling). The contact associated the failure with the recall. The contact stated that several unknown warning lights and the EPC and engine temperature warning lights were illuminated. The contact stated that the dealer was contacted but was unable to determine the cause of the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 25,000.
The contact owns a 2022 Volkswagen Taos. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated, and the engine seized. The contact stated that while attempting to restart the vehicle, the vehicle failed to start. The vehicle was towed to the dealer to be inspected; however, the failure was not duplicated. The failure reoccurred. The vehicle was taken back to the dealer; but the failure was not duplicated. The contact was informed that an adjustment to the fuel system was performed. The vehicle was repaired but the failure reoccurred. The failure was persistent. The contact stated that the failure had occurred with minor children inside the vehicle. In addition, the contact noticed a fuel odor on the interior of the vehicle. The vehicle was driven to the residence. The vehicle was later towed to an independent mechanic where it was diagnosed with high and low fuel pump failures. The contact was informed that the high and low fuel pumps needed to be replaced. The vehicle was repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,009.
The systems failing are electrical, engine, and fuel/propulsion systems. VW TAOS 2022 purchased Sept. 2023. Two weeks after purchasing the vehicle, I'm driving down the street and the vehicle began to lose power and start slowing down. It eventually cut off. About a week later, I experienced the same issue. I called the dealer and they had me to bring my car in. I was told that they couldn't find the problem, but that the car was misfiring. They "repaired" and returned it to me. As I drove on local streets and the interstate, I have problems with acceleration. The car does not pick up speed like it should and lags behind and then suddenly jerks forward (even after battery rest times during a stop). It rides a bit rough. Occasionally, my dashboard blacks out while I'm driving. My auto-start doesn't always work, even after the fob batteries have been changed. My gas seems to disappear and I find myself gassing up more often than I should be. I would contact the dealership, they'd coordinate service around my scheduled service dates and claim that they could never find or duplicate the problems that I'm having. The problems continue. My engine light came on while I was driving and stayed on. I was told to bring in my car. The dealership kept it from July-Sept 2025, replacing parts and then returned it to me. Two days later the engine light came back on and I had to return to the dealer again for service. After leaving a parking lot (Jun 2026), two blocks down the street the TAOS began to lose power, the engine light is flashing and the EPC code (engine control malfunction) light lit up. I called VW and they dispatched a tow. My TAOS was towed to Checkered Flag VW. My safety (and others) is at risk because the power loss just happens without warning. If a driver is not paying attention, they could run into the back of me or hit me on the side during a lane change due to the slow movement.
The EVAP line has a fault, stuck open, affects nothing whatsoever. But has every single light on the dash on. It tells me the brakes don't work, the air bags don't work, the cruise doesn't work. Everything. The confusing thing is some things actually work and some don't. The brakes work, the cruise doesn't. The auto detection doesn't work. What's worse, you can't replace that part. No one sells it. This is absolutely horrendous and very dangerous.
Had my car in at a Volkswagen dealership for its routine maintenance they called me back, letting me know that I had the head gasket leak and that coolant was leaking.
Head gasket failure is a known issue for this model. Some owners report failure at 12k miles in for quite some time. I am now faced with this known issue VW has had time to remedy. If it is a known failure why not take care of it especially if it spans across 3 models 2022 - 2024. I should not have to absorb this type of repair 4 years 57k miles in on my vehicle. Of course, everything pops up right as warranties expire. I was refused even dealer “good faith” for being 7,000 miles over the threshold VW powertrain warranty of 4 years 50k miles. Now to find $4638.83 for parts plus whatever labor will be.
The car does not accelerate when the gas is pressed. It will delay, jerk or accelerate slower than it's supposed to.
The vehicle has intermittent hesitation/delayed acceleration from a stop and during low-speed stop-and-go driving. At times, engine RPM increases before the vehicle responds or accelerates normally. This creates a safety concern when entering traffic, turning, merging, or accelerating from a stopped position because the vehicle does not always respond predictably to throttle input. The concern was reported to a Volkswagen dealer in writing during a prior repair process and was later formally documented on a repair order as hesitation on acceleration. The vehicle has prior Volkswagen repair history involving a coolant warning/low coolant concern, head gasket repair, and later camshaft seal/belt cover repair. After the most recent repair, the delayed acceleration/hesitation concern remained unresolved. The vehicle is currently under review with Volkswagen Customer Care, but the safety-related drivability concern has not yet been fully resolved. Supporting documents include the 2025 written report of jerking from a stop, the 2026 repair order documenting hesitation on acceleration, and post-repair emails showing the issue remained unresolved. After I notified the dealer in writing that the hesitation/delayed acceleration concern remained after the most recent repair, I did not receive a documented response or resolution, and the concern remains unresolved with Volkswagen Customer Care.
Electronic parking brake engaged randomly when getting gas and would not disengage letting me leave the pump
Clicking noise coming from the driver side tire/axle when making right turns only. The diagnostic at the VW service department was a faulty CV axle is the cause of the noise. VW service associate recommended replacing the CV axle. The vehicle only has 6k miles but unfortunately is no longer under warranty. According to the VW forum on line there are several issues like this on this particular model.
leaking head gasket
The SOS module has failed. THIS MEANS AUTOMATIC NOTIFICATION OF A CRASH OR SIGNIFICANT MECHANICAL FAILURE IS NOT FUNCTIONAL. THE MODLE HAS A BATTERY THAT FAILS IS IS NOT AVAILABLE. THE ONLY SOLUTION IS REPLACEMENT OF THE MODULE AT A COST OF $600 TO $800.
The contact's daughter owns a 2022 Volkswagen Taos. The contact stated that while her daughter was driving at an undisclosed speed, the engine coolant warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,000.
This vehicle has ongoing drivability issues that have not been resolved despite multiple repair attempts involving engine-related components and repairs. The issue began in November 2024 while the vehicle was under warranty with coolant and engine warnings. At that time, I reported coolant loss, warning messages, hesitation during acceleration, and abnormal vehicle vibration. I was initially told no issue existed. Shortly after warranty expiration, the vehicle required a major head gasket repair in 2025 after continuing to exhibit the same coolant-related issues. In 2026, the vehicle required an additional engine-related repair involving a camshaft seal in the same area of the engine that had previously been dismantled and rebuilt. Despite these repairs, the same drivability symptoms remain. The vehicle intermittently hesitates during acceleration, particularly from a stop or during merging conditions, where engine RPM increases significantly before the vehicle responds. The vehicle also exhibits significant steering wheel and seat vibration at highway speeds and during extended driving. These conditions create a potential safety concern because the vehicle does not consistently respond as expected during acceleration and becomes unstable and uncomfortable to operate at highway speeds. The hesitation creates concern when entering traffic, crossing intersections, or attempting to accelerate in situations requiring predictable vehicle response. The issue has been repeatedly presented to the dealership and repair attempts have been performed, including major engine work, but the condition remains unresolved. The repairs were treated as separate isolated issues rather than a continuation of the original condition first reported under warranty. The vehicle has been out of service for approximately 43 days across these repairs. No loaner vehicle was provided during those periods. The vehicle remains in its current condition with unresolved issues.
Only 41,000 miles and head gasket is leaking
I am filing a safety complaint regarding a 2022 vehicle with approximately 47,000 miles that experienced a sudden and dangerous mechanical failure while in operation. While driving at approximately 37 mph, a dashboard warning message appeared indicating that the vehicle required attention but could continue to be driven for a short period. Shortly after the warning, the vehicle suddenly lost the ability to maintain proper gear engagement. At one point, no gear was engaged at all, creating a hazardous driving situation. I pulled over and turned the vehicle off. After restarting it, I was able to regain limited operation; however, the vehicle would not shift beyond second gear, significantly limiting its drivability and creating an unsafe condition in traffic. This vehicle has been consistently maintained at an authorized dealership according to all recommended service intervals, with no missed or delayed maintenance. The dealership later informed me that the failure was related to the mechatronic system and SOS system. I was also told that the repair would not be covered under warranty. This incident raises serious safety concerns due to the sudden loss of power and gear function while the vehicle was in motion. I am requesting that this issue be reviewed for potential defects that could affect vehicle safety and reliability. I am submitting this complaint so that the issue can be investigated and to help prevent similar incidents from affecting other drivers.
Head gasket failure at 42,000 miles. Transmission leak from filter and pan. VW dealership diagnosed.
Vehicle: 2022 Volkswagen Taos Mileage at Incident: 61,170 On April 21, 2026, while driving shortly after leaving my home, the EPC (Electronic Power Control) warning light suddenly illuminated and the engine warning light began flashing rapidly. The vehicle immediately began jerking, hesitating, and losing power. It started slowing down unexpectedly while in motion. This created a serious safety hazard. I was forced to reduce speed and maneuver to the side of the road to avoid being rear-ended. The sudden loss of power in traffic placed me and other drivers at risk of a collision. After turning the vehicle off and restarting it, both warning lights disappeared. Notably, on April 3, 2026 (60,428 miles), I had an oil change performed. On April 6, the engine light came on and remained illuminated until April 18, then turned off without repair. Three days later, the EPC failure occurred. The dealership was unable to reproduce the issue but charged $190 for diagnostics and stated the problem was a cracked N80 valve line (small leak), quoting approximately $700 for repair. I am aware of reports involving similar issues affecting thousands of vehicles of this model year. Sudden loss of engine power while driving is a clear safety concern, especially when warning lights appear and disappear intermittently. The vehicle remains available for inspection.
I purchased the vehicle brand new (VW Taos 2022) and have maintained it properly. At approximately 60,000 miles—just outside the warranty period—the vehicle developed a serious transmission issue. While driving, I received a warning stating “Transmission in emergency mode” followed by a check engine light. The vehicle then entered limp mode, limiting shifting to manual gears (M2–M4) and eventually becoming stuck in M2. An authorized Volkswagen dealership diagnosed the issue as a mechatronic failure and quoted approximately $2,000 for repair. I contacted Volkswagen Customer Care to request goodwill assistance, as this represents a premature failure of a major drivetrain component. Given the relatively low mileage, the known issues associated with early model-year Taos vehicles, and the safety implications of the vehicle entering limp mode during operation, I believe this repair should not fall entirely on the consumer.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .