2022 Volkswagen Taos Powertrain (other) Problems

On 7/9/2026, my 2022 VW Taos was brought to the dealer for being severely underpowered, check engine lights on, and a strong raw fuel smell inside the vehicle. On 7/10/2026, the dealer stated the vehicle was ready, claiming they replaced a turbo charge pipe O-ring. The service advisor verbally stated the vehicle had been successfully test-driven for 5 miles on streets and the highway. However, official paperwork only stated "cleared faults verified no leaks in system, vehicle is now operating as designed." Immediately upon driving home on the highway, as the vehicle reached 70–75 mph under load, a loud whistling noise and a sudden, dangerous loss of propulsion occurred simultaneously. The vehicle was returned to the dealer on 7/10/2026. On 7/13/2026, the vehicle was picked up after a second repair where the dealer admitted the plastic charge pipe (05E-145-673-Q) was actually fractured and had completely blown off the turbocharger during my highway drive, generating fault code P227900 (Intake Air System Leak). Upon reviewing the paperwork from both visits, I discovered the odometer had only increased by exactly 1 mile during the first service visit. The dealer completely failed to road-test the vehicle under actual highway boost loads before certifying it as safe, which directly caused a catastrophic structural engine failure and an emergency safety hazard at 75 mph.

NHTSA ID

11750349

Incident

Jul 10, 2026

The vehicle has intermittent hesitation/delayed acceleration from a stop and during low-speed stop-and-go driving. At times, engine RPM increases before the vehicle responds or accelerates normally. This creates a safety concern when entering traffic, turning, merging, or accelerating from a stopped position because the vehicle does not always respond predictably to throttle input. The concern was reported to a Volkswagen dealer in writing during a prior repair process and was later formally documented on a repair order as hesitation on acceleration. The vehicle has prior Volkswagen repair history involving a coolant warning/low coolant concern, head gasket repair, and later camshaft seal/belt cover repair. After the most recent repair, the delayed acceleration/hesitation concern remained unresolved. The vehicle is currently under review with Volkswagen Customer Care, but the safety-related drivability concern has not yet been fully resolved. Supporting documents include the 2025 written report of jerking from a stop, the 2026 repair order documenting hesitation on acceleration, and post-repair emails showing the issue remained unresolved. After I notified the dealer in writing that the hesitation/delayed acceleration concern remained after the most recent repair, I did not receive a documented response or resolution, and the concern remains unresolved with Volkswagen Customer Care.

NHTSA ID

11740065

Incident

Jun 30, 2025

Clicking noise coming from the driver side tire/axle when making right turns only. The diagnostic at the VW service department was a faulty CV axle is the cause of the noise. VW service associate recommended replacing the CV axle. The vehicle only has 6k miles but unfortunately is no longer under warranty. According to the VW forum on line there are several issues like this on this particular model.

NHTSA ID

11738013

Incident

May 8, 2026

leaking head gasket

NHTSA ID

11737959

Incident

May 13, 2026

This vehicle has ongoing drivability issues that have not been resolved despite multiple repair attempts involving engine-related components and repairs. The issue began in November 2024 while the vehicle was under warranty with coolant and engine warnings. At that time, I reported coolant loss, warning messages, hesitation during acceleration, and abnormal vehicle vibration. I was initially told no issue existed. Shortly after warranty expiration, the vehicle required a major head gasket repair in 2025 after continuing to exhibit the same coolant-related issues. In 2026, the vehicle required an additional engine-related repair involving a camshaft seal in the same area of the engine that had previously been dismantled and rebuilt. Despite these repairs, the same drivability symptoms remain. The vehicle intermittently hesitates during acceleration, particularly from a stop or during merging conditions, where engine RPM increases significantly before the vehicle responds. The vehicle also exhibits significant steering wheel and seat vibration at highway speeds and during extended driving. These conditions create a potential safety concern because the vehicle does not consistently respond as expected during acceleration and becomes unstable and uncomfortable to operate at highway speeds. The hesitation creates concern when entering traffic, crossing intersections, or attempting to accelerate in situations requiring predictable vehicle response. The issue has been repeatedly presented to the dealership and repair attempts have been performed, including major engine work, but the condition remains unresolved. The repairs were treated as separate isolated issues rather than a continuation of the original condition first reported under warranty. The vehicle has been out of service for approximately 43 days across these repairs. No loaner vehicle was provided during those periods. The vehicle remains in its current condition with unresolved issues.

NHTSA ID

11735956

Incident

Nov 20, 2024

I am filing a safety complaint regarding a 2022 vehicle with approximately 47,000 miles that experienced a sudden and dangerous mechanical failure while in operation. While driving at approximately 37 mph, a dashboard warning message appeared indicating that the vehicle required attention but could continue to be driven for a short period. Shortly after the warning, the vehicle suddenly lost the ability to maintain proper gear engagement. At one point, no gear was engaged at all, creating a hazardous driving situation. I pulled over and turned the vehicle off. After restarting it, I was able to regain limited operation; however, the vehicle would not shift beyond second gear, significantly limiting its drivability and creating an unsafe condition in traffic. This vehicle has been consistently maintained at an authorized dealership according to all recommended service intervals, with no missed or delayed maintenance. The dealership later informed me that the failure was related to the mechatronic system and SOS system. I was also told that the repair would not be covered under warranty. This incident raises serious safety concerns due to the sudden loss of power and gear function while the vehicle was in motion. I am requesting that this issue be reviewed for potential defects that could affect vehicle safety and reliability. I am submitting this complaint so that the issue can be investigated and to help prevent similar incidents from affecting other drivers.

NHTSA ID

11734067

Incident

Apr 24, 2026

Head gasket failure at 42,000 miles. Transmission leak from filter and pan. VW dealership diagnosed.

NHTSA ID

11733009

Incident

Apr 22, 2026

I purchased the vehicle brand new (VW Taos 2022) and have maintained it properly. At approximately 60,000 miles—just outside the warranty period—the vehicle developed a serious transmission issue. While driving, I received a warning stating “Transmission in emergency mode” followed by a check engine light. The vehicle then entered limp mode, limiting shifting to manual gears (M2–M4) and eventually becoming stuck in M2. An authorized Volkswagen dealership diagnosed the issue as a mechatronic failure and quoted approximately $2,000 for repair. I contacted Volkswagen Customer Care to request goodwill assistance, as this represents a premature failure of a major drivetrain component. Given the relatively low mileage, the known issues associated with early model-year Taos vehicles, and the safety implications of the vehicle entering limp mode during operation, I believe this repair should not fall entirely on the consumer.

NHTSA ID

11731074

Incident

Mar 11, 2026

I am reporting a safety-related failure involving a 2022 Volkswagen Taos (AWD) with approximately 48,000 miles. While operating the vehicle under normal driving conditions, the vehicle entered “transmission emergency mode” without warning. At that point, the vehicle experienced a significant loss of functionality, downshifting to D1 and including the complete loss of reverse gear. This created a hazardous situation, as I was unable to maneuver the vehicle safely on the highway and in confined or urban environments. The issue was intermittent at first but became persistent, resulting in the vehicle being effectively unsafe to operate. The inability to engage reverse presents a clear safety risk, particularly in situations requiring immediate maneuverability (e.g., parking, avoiding obstacles, or exiting traffic situations). The vehicle was taken to an authorized Volkswagen dealership, where it was diagnosed with an internal transmission failure. The diagnostic fault code provided was P176F00 (K2 clutch out of tolerance due to internal wear). The dealer indicated that the appropriate repair is a full transmission replacement, with an estimated cost of approximately $8,400. Despite the relatively low mileage and the severity of the failure, Volkswagen has declined to provide assistance, citing that the vehicle is just outside of the warranty period. The vehicle has been out of service now for 10 days with no resolution provided. This failure appears to be premature for a major drivetrain component and raises concerns about potential defects affecting the safety and reliability of this vehicle model. The sudden loss of reverse and entry into emergency mode without warning creates a potentially dangerous condition for drivers and others on the road. I am submitting this complaint to document the issue and to request investigation into whether this represents a broader safety-related defect in the vehicle.

NHTSA ID

11731009

Incident

Apr 5, 2026

2022 Volkswagen Taos SE 1.5T (DNKA engine, <60,000 miles, <5 years old) developed internal coolant leak from cylinder head gasket. On 11/03/2025 Smith Volkswagen, Wilmington, DE (RO 692953/1) performed coolant system pressure test and confirmed leak coming from cylinder head gasket area at rear of engine below turbo (exactly as shown in Figures 1 & 2 of VW TSB 15-23-01). Dealer noted possible related engine damage that may require complete engine replacement in addition to head gasket. Vehicle available for inspection upon request. Safety risk: loss of coolant can cause sudden engine overheating, power loss, or seizure while driving, creating risk of crash, stranding, or fire. Symptoms began November 2025 with “Check Coolant” warning; reservoir was below MIN. Added coolant once; warning has not returned, but pressure test proved ongoing internal leak. No visible external drips. This exact failure is a known manufacturing defect per Volkswagen Technical Service Bulletin 15-23-01 (Transaction 2071245/1, issued 08/17/2023), which states: “Original engine production head gasket design can lead to coolant leaks” and was redesigned as of engine DNKA 234 458 (July 27, 2023). Despite VW’s own bulletin documenting the defective gasket in all 2022–2023 Taos/Jetta 1.5T engines built before the fix, VW classifies the TSB as “information only” with no warranty coverage. VW Goodwill offered only 50% assistance on the $4,927 head gasket replacement and nothing toward a potential full engine replacement, leaving owner responsible for thousands of dollars in repairs on a documented factory defect in a low-mileage, young vehicle.

NHTSA ID

11703443

Incident

Oct 20, 2025

The vehicle has had repeated issues related to the fuel system, including strong fuel odor inside the cabin, a gurgling sound coming from the fuel tank area, and recurring check engine lights shortly after a previous recall repair was completed. The most recent diagnostic from the dealer indicated a faulty fuel tank pressure sensor (G400), but I was initially told the vehicle needed a fuel pressure release valve. There has been inconsistency in the diagnostics and explanations provided to me. The fuel smell in the cabin and apparent pressure issues in the tank created a safety concern for me and my passengers, especially while driving with windows closed or using cabin heat. I am concerned about a potential fuel leak or improper tank venting. The problem has occurred multiple times, including at least five check engine lights after the recall repair. The dealer has inspected the vehicle several times, but the issue has not been fully resolved, and additional related parts (such as the tank shutoff valve) were recommended for replacement. Warning lights included repeated check engine indicators, and the fuel odor occurred each time the issue recurred. The vehicle is available for inspection upon request.

NHTSA ID

11701839

Incident

Nov 14, 2025

2022 VW Taos Head Gasket failure at 63,000 miles. Coolant leaking. Potential for engine seizure/fire. Manufacturer is aware of defect (TSB 2071245/1) but refuses to assist.

NHTSA ID

11700863

Incident

Sep 10, 2025

i got a 2022 volkswagen Taos the end of may 2025, it has been 6 months. a month after getting it i reported to the dealership that i felt like i had a wobbly tire, they looked at it and said it was fine. i have felt like it has gotten worse within the past few months so i brought it into a shop, they called me back yesterday saying i have a problem with the transmission. i’m not sure how i don’t have any warranty, but i now have to come out of pocket for the transmission. no lights came on, there was no warning. i tried driving it home after and its shifting so badly it’s now not safe to drive and im scared ill be in an accident. so im forced to fix the issue now. i’m having it sent to the dealership today but wanted to make a report to have this vehicle recalled.

NHTSA ID

11699352

Incident

Nov 13, 2025

I've been having issues with my car since I bought it. I've taken the car in for the Power Train System, and the codes that come up are P0456 and P2421. This car has a mind of its own. I've driven it and it started lagging, and I went into limp mode just crossing a 2 way stop with ongoing traffic. I don't understand how VW doesn't address this problem when I know that if anyone were in my shoes, they wouldn't have dealt with this, going to the dealership 3,4 times a year when I should only be going in frequently for oil changes. The dealership says after my warranty is over, I have to pay out of pocket, but I don't see why, when it's been an ongoing issue and VW needs to have an extended warranty, because I know I am not the only one with issues. Reddit has thousands of complaints about VW, but it's our problem that they couldn't produce a reliable car. The dealership has been aware of this for 4 years since I bought my car in June 2021. I have had the engine light come on every 3 -5 months since June 2021, and it's always the same when they replace a whole part. I have all the paperwork and all the information on what they perform on my car. I am a regular. citizen, and I only make around 30K a year, if I were able to, I would get another car, but I've literally invested 20K in this car, and it's ridiculous how unreliable and how I constantly have to worry if the car will work. I don't have a scanner, so I uploaded how many times I've been to the dealership for one car.

NHTSA ID

11696396

Incident

Aug 15, 2021

Took my 2022 VW Taos in for its 20,000 mile service. Upon picking up the vehicle I was told everything looks great and I'm going to want to watch my rear brakes, the pads are worn 50%. I inquired as to wear on the front, near new at 11. I had also asked if they could check on the sluggish or jack rabbit take offs. They said that had been corrected thru a computer update at a previous visit. I said it was minimally improved? and had hoped VW had figured out the cause. I dwellled on the rear brake issue overnight, discussed the situation with my BIL, and called my service advisor in the am to say we believe the sluggish/rapid acceleration isn't brake related, but rather the brakes aren't completely releasing during stop to acceleration. He said he suspected that also and discussed it with his service manager who agreed. He said they submitted an inquiry and are asking VW to look in to this and as my rearbrakes are out if warranty by my "in service date", to see if VW will waive the pad replacement for low odometer. I've complained about and filed a NTHSA report for the acceleration problem a couple years ago. This is still a serious safety issue and abuse of the paying public.VW needs to step up before someone has to die. Brakes are nothing you wanting failing doing 70 mphs on I-90 thru mountain passes. Please follow-up and seek a resolution from VW. In the meantime I saw someone posted VW has a new brake pad as if May 2025. Guess I'll be paying for the replacement. P.S. I still don't have 20,000 mile on it. Ridiculous to be replacing rear pads!

NHTSA ID

11679719

Incident

Jul 29, 2025

The vehicle has ongoing acceleration delay and jerking under normal driving, along with repeated premature rear brake wear and a major coolant leak that required head gasket replacement. The most recent incident occurred on August 8, 2025, immediately after picking up the vehicle from a service visit for the acceleration concern. Two separate throttle delays with a sudden jerk forward occurred at approximately 5:47 PM and 5:50 PM in moderate city traffic at 79°F. These incidents put my safety and the safety of other drivers at risk, as delayed acceleration can prevent safe merging, crossing, or passing. Within the first 25,000 miles of ownership, the vehicle has also required one rear brake replacement and a second replacement was recommended due to premature wear, which could reduce braking performance and stopping distance. Additionally, a coolant leak ultimately required head gasket replacement. Suspension components, including a knuckle, have also been replaced under warranty. The acceleration problem has been reported to authorized Volkswagen dealers, but was documented as “could not reproduce” despite occurring minutes after pickup. Coolant leak and brake issues have been confirmed and repaired or recommended for repair by dealers. There were no warning lights or error messages prior to the acceleration incidents.

NHTSA ID

11679701

Incident

Aug 8, 2025

Vehicle is persistently lagging in acceleration on highways

NHTSA ID

11647730

Incident

Feb 12, 2025

Head Gasket Leaking Coolant, yes it's available for inspection Engine could cease to operate properly Head gasket leaking was confirmed by Volkswagen Dealer No, I had a low coolant light, manual says add fluid This is a very HIGH COST REPAIR Brake Pads were worn out at 16,000 miles, replace ourselves because out of warranty at the time

NHTSA ID

11628901

Incident

Jun 4, 2024

I recently started experiencing a delay in acceleration after my car has stopped at a light or stop sign. The car doesn’t immediately accelerate when the gas pedal is used but then it catches and takes off lunging forward very quickly. The has caused many close calls especially with left hand turns. I have almost been hit multiple times due to the car not going and oncoming traffic continuing. I have also almost rear ended other drivers due to the surge of acceleration when the car finally takes off. I took my car to the dealer for an oil change and brought this to their attention. They told me it was a known issue, particularly with the Volkswagen Taos. They said they had several vehicles come in for inspection citing the same problem. So I assumed they would have a solution since it is a known issue, but I was told there was nothing they could do to fix it. They told me this was why my check engine light was on when I brought my vehicle in, they tested for errors, found none, turned the light off, and sent me on my way with my vehicle still experiencing this “turbo lag”. I goggled the issue and there is a lot of information online and reports of the same experience but no solutions. Does someone need to die before car manufacturers are held accountable to fixing this? It is documented with the dealership that I had concerns about this and I will be taking legal action should an accident occur because of this issue because this isn’t right. They literally told me, “I would hate to charge you money for us to do work on your car knowing we cannot fix it.” And of course the issue didn’t show up until my car hit a certain number of miles. I bought the car brand new in 2021 and have maintained the required servicing.

NHTSA ID

11617020

Incident

Sep 28, 2024

In the two years I have had this car it has gone into limp home mode stating “start/stop error” while I am drivig the vehicle. I have taken it to my dealership and they will not do anything to fix the problem. The vehicle has also cut off twice while I am driving it with no warning lights which has caused other Volkswagen models to be recalled

NHTSA ID

11594947

Incident

Jun 17, 2024

From the start, car regularly needed coolant topped off. Dealer said there was no issue. At 68,000 miles other mechanic noticed a major oil leak. Took it to dealer and needed cylinder head gasket replaced. Apparently there are many many people with a similar issue. I however did not discover it until I was out of warranty. They should not be getting away with this. This is a near $4,000 repair I have to come with out of pocket (plus interest) which is due to manufacturing defect and not simple wear and tear.

NHTSA ID

11590884

Incident

May 22, 2024

2022, Volkswagen Taos VIN: [XXX] Dealer Servicing:Nailey Volkswagen, 1550 Mansell Road, Alpharetta, GA 3009 We have owned this vehicle since [XXX]/2022 and I’m starting to regret buying it. We have had a ton of random things gone wrong with this vehicle, like Fluids Leak, Faulty Cylinder Head Gasket, Coolant Leak, Check Engine Light ON doesn’t function sometimes. This Car stayed with Dealer Service Center more than in my drive way. We are completely fed up with this car., and we are totally concerned and scared as my son drives this car., with all the mechanical issues I am seeing, it’s really getting worried of his security with this car. Overall, the car was with the DEALER is 7+ Months in the last 21 Months I own this car. I’m super annoyed with this whole situation. Today I dropped it off again, after receiving the car just 5 days ago from OIL CHANGE and I see Check Engine Light ON…. Dealer don’t have LOANER CAR to support my son job and his classes during summer. Moreover, I am not comfortable taking the car back… you guys rather buy this back… or get a more stable model for my son…. We cannot accept this car anymore…. WE DON’T FEEL SAFE FOR MY SON TO DRIVE THIS CAR., Appreciate your immediate attention into this for resolution… if not I need to find other ways going legal with this issue to US Government, BBB and so on… INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11586708

Incident

May 3, 2024

Within weeks of leading car, EPC light flashing, check engine light, limp mode from 55 to about 30. I bought it to dealer said fixed. A few months later again, brought it to another dealer fixed it, said don’t use eco mode and high tier gas. It was fine for a few months did it again two days ago. I shut the engine off and turned it on was fine. VW HQ said no new car. They will keep trying to fix it. Dealer won’t change it. Dealer wants me to bring it in again….They will try something else. I explained to dealer and VWHQ this is very dangerous. Previous incident 11/2023, previous incident shortly after leasing the car. Each time told it was fixed and not.

NHTSA ID

11578764

Incident

Mar 19, 2024

This vehicle was purchased new 1/2022 and it has had several issues that occurred: - 2/23 driving down the highway trying to accelerate onto the highway I pressed the gas pedal and it wouldn’t accelerate for about 3-4 seconds then the check engine light came on as well as the car losing power - while driving the car the forward collision indicator has activated without at car being around and stops suddenly - if you put the car in reverse sometime the car will not go into drive so your basically waiting for the car to respond - I barely drive my car it has 19k miles I do not feel safe even driving this vehicle at this point. - when you take it to the dealership they say if it can’t be reproduced they can’t fix the issues no matter if I call and state there is a problem. I’ve been a VW owner since 2005 and this vehicle has given me more problems then any VW I’ve ever owned

NHTSA ID

11573529

Incident

Feb 23, 2024

The car completely shut off while driving it. This was not the first time this happened. The EPC and check engine lights are constantly on. I have brought the car several times to try to fix the problem, nothing works. I have also had to add radiator fluid twice. The car was sold to me during a stop sale that I had no idea about. I tried going through VW for a buy back that they were initially going to grant and then changed their mind once a fix for the recall was announced. Horrific company to deal with.

NHTSA ID

11570132

Incident

Feb 1, 2024