2022 Volkswagen Taos Fuel system Problems

On 7/9/2026, my 2022 VW Taos was brought to the dealer for being severely underpowered, check engine lights on, and a strong raw fuel smell inside the vehicle. On 7/10/2026, the dealer stated the vehicle was ready, claiming they replaced a turbo charge pipe O-ring. The service advisor verbally stated the vehicle had been successfully test-driven for 5 miles on streets and the highway. However, official paperwork only stated "cleared faults verified no leaks in system, vehicle is now operating as designed." Immediately upon driving home on the highway, as the vehicle reached 70–75 mph under load, a loud whistling noise and a sudden, dangerous loss of propulsion occurred simultaneously. The vehicle was returned to the dealer on 7/10/2026. On 7/13/2026, the vehicle was picked up after a second repair where the dealer admitted the plastic charge pipe (05E-145-673-Q) was actually fractured and had completely blown off the turbocharger during my highway drive, generating fault code P227900 (Intake Air System Leak). Upon reviewing the paperwork from both visits, I discovered the odometer had only increased by exactly 1 mile during the first service visit. The dealer completely failed to road-test the vehicle under actual highway boost loads before certifying it as safe, which directly caused a catastrophic structural engine failure and an emergency safety hazard at 75 mph.

NHTSA ID

11750349

Incident

Jul 10, 2026

The contact owns a 2022 Volkswagen Taos. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated, and the engine seized. The contact stated that while attempting to restart the vehicle, the vehicle failed to start. The vehicle was towed to the dealer to be inspected; however, the failure was not duplicated. The failure reoccurred. The vehicle was taken back to the dealer; but the failure was not duplicated. The contact was informed that an adjustment to the fuel system was performed. The vehicle was repaired but the failure reoccurred. The failure was persistent. The contact stated that the failure had occurred with minor children inside the vehicle. In addition, the contact noticed a fuel odor on the interior of the vehicle. The vehicle was driven to the residence. The vehicle was later towed to an independent mechanic where it was diagnosed with high and low fuel pump failures. The contact was informed that the high and low fuel pumps needed to be replaced. The vehicle was repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,009.

NHTSA ID

11745744

Incident

Oct 5, 2025

Mileage

45,009 mi

The systems failing are electrical, engine, and fuel/propulsion systems. VW TAOS 2022 purchased Sept. 2023. Two weeks after purchasing the vehicle, I'm driving down the street and the vehicle began to lose power and start slowing down. It eventually cut off. About a week later, I experienced the same issue. I called the dealer and they had me to bring my car in. I was told that they couldn't find the problem, but that the car was misfiring. They "repaired" and returned it to me. As I drove on local streets and the interstate, I have problems with acceleration. The car does not pick up speed like it should and lags behind and then suddenly jerks forward (even after battery rest times during a stop). It rides a bit rough. Occasionally, my dashboard blacks out while I'm driving. My auto-start doesn't always work, even after the fob batteries have been changed. My gas seems to disappear and I find myself gassing up more often than I should be. I would contact the dealership, they'd coordinate service around my scheduled service dates and claim that they could never find or duplicate the problems that I'm having. The problems continue. My engine light came on while I was driving and stayed on. I was told to bring in my car. The dealership kept it from July-Sept 2025, replacing parts and then returned it to me. Two days later the engine light came back on and I had to return to the dealer again for service. After leaving a parking lot (Jun 2026), two blocks down the street the TAOS began to lose power, the engine light is flashing and the EPC code (engine control malfunction) light lit up. I called VW and they dispatched a tow. My TAOS was towed to Checkered Flag VW. My safety (and others) is at risk because the power loss just happens without warning. If a driver is not paying attention, they could run into the back of me or hit me on the side during a lane change due to the slow movement.

NHTSA ID

11743911

Incident

Jun 10, 2026

The car does not accelerate when the gas is pressed. It will delay, jerk or accelerate slower than it's supposed to.

NHTSA ID

11740205

Incident

Aug 5, 2024

The vehicle has intermittent hesitation/delayed acceleration from a stop and during low-speed stop-and-go driving. At times, engine RPM increases before the vehicle responds or accelerates normally. This creates a safety concern when entering traffic, turning, merging, or accelerating from a stopped position because the vehicle does not always respond predictably to throttle input. The concern was reported to a Volkswagen dealer in writing during a prior repair process and was later formally documented on a repair order as hesitation on acceleration. The vehicle has prior Volkswagen repair history involving a coolant warning/low coolant concern, head gasket repair, and later camshaft seal/belt cover repair. After the most recent repair, the delayed acceleration/hesitation concern remained unresolved. The vehicle is currently under review with Volkswagen Customer Care, but the safety-related drivability concern has not yet been fully resolved. Supporting documents include the 2025 written report of jerking from a stop, the 2026 repair order documenting hesitation on acceleration, and post-repair emails showing the issue remained unresolved. After I notified the dealer in writing that the hesitation/delayed acceleration concern remained after the most recent repair, I did not receive a documented response or resolution, and the concern remains unresolved with Volkswagen Customer Care.

NHTSA ID

11740065

Incident

Jun 30, 2025

Vehicle: 2022 Volkswagen Taos Mileage at Incident: 61,170 On April 21, 2026, while driving shortly after leaving my home, the EPC (Electronic Power Control) warning light suddenly illuminated and the engine warning light began flashing rapidly. The vehicle immediately began jerking, hesitating, and losing power. It started slowing down unexpectedly while in motion. This created a serious safety hazard. I was forced to reduce speed and maneuver to the side of the road to avoid being rear-ended. The sudden loss of power in traffic placed me and other drivers at risk of a collision. After turning the vehicle off and restarting it, both warning lights disappeared. Notably, on April 3, 2026 (60,428 miles), I had an oil change performed. On April 6, the engine light came on and remained illuminated until April 18, then turned off without repair. Three days later, the EPC failure occurred. The dealership was unable to reproduce the issue but charged $190 for diagnostics and stated the problem was a cracked N80 valve line (small leak), quoting approximately $700 for repair. I am aware of reports involving similar issues affecting thousands of vehicles of this model year. Sudden loss of engine power while driving is a clear safety concern, especially when warning lights appear and disappear intermittently. The vehicle remains available for inspection.

NHTSA ID

11732898

Incident

Apr 21, 2026

The contact owns a 2022 Volkswagen Taos. The contact stated that while driving at an undisclosed speed, there was an exhaust system malfunction warning light illuminated. Additionally, there was engine oil on the driveway. The vehicle was taken to a local dealer and during an oil leak inspection, the dealer found a fuel leak. The dealer confirmed that fuel was leaking from the vehicle and NHTSA Campaign Number: 21V651000 (FUEL SYSTEM, GASOLINE); however, the VIN was not associated with the recall. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 52,000. The VIN was not available.

NHTSA ID

11728613

Incident

Mar 6, 2026

Mileage

52,000 mi

Giving code 23v214000 fuel pump recall code. Fuel pump went out

NHTSA ID

11724767

Incident

Mar 15, 2026

Vin # [XXX] Evap system hose-canister parts regulator valve. Check engine light stays on and this started in June 2025. Gorman McCracken Volkswagen Longview Texas diagnosed. February 1,2025 Low engine coolant light continues to come on. We have had to add coolant for the last two weeks. About 3 gallons used. The back up camera and navigation screen goes black often and has to be reset. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11719840

Incident

Feb 1, 2026

Since the purchase of my 2022 VW Taos in 2022, there has been a repeated issue of the check engine light coming on at random times. Each time it has happened the code indicates a problem with the fuel evap system. The issue has been fixed multiple times by replacing parts. There has been no fix for the issue and it still persists. Problems with the fuel evap system puts the drivers and passengers at risk. Being unable to determine an issue with the car and the safety of operating a motor vehicle due to continued negligence by the manufacturer is the opposite of a safe motor vehicle. Additionally, since buying the vehicle there have been repeated issues with the communications module. The module had to be replaced just days after purchasing it. Now, it is not working once again and if there was an emergency, the technology presented when purchasing the car, SOS, information, crash detection, location, etc, is not available to help me. VW presents these as safety features then does nothing to fix their equipment issues that ultimately render these options and functions useless.

NHTSA ID

11714787

Incident

May 1, 2022

The vehicle has had repeated issues related to the fuel system, including strong fuel odor inside the cabin, a gurgling sound coming from the fuel tank area, and recurring check engine lights shortly after a previous recall repair was completed. The most recent diagnostic from the dealer indicated a faulty fuel tank pressure sensor (G400), but I was initially told the vehicle needed a fuel pressure release valve. There has been inconsistency in the diagnostics and explanations provided to me. The fuel smell in the cabin and apparent pressure issues in the tank created a safety concern for me and my passengers, especially while driving with windows closed or using cabin heat. I am concerned about a potential fuel leak or improper tank venting. The problem has occurred multiple times, including at least five check engine lights after the recall repair. The dealer has inspected the vehicle several times, but the issue has not been fully resolved, and additional related parts (such as the tank shutoff valve) were recommended for replacement. Warning lights included repeated check engine indicators, and the fuel odor occurred each time the issue recurred. The vehicle is available for inspection upon request.

NHTSA ID

11701839

Incident

Nov 14, 2025

I've been having issues with my car since I bought it. I've taken the car in for the Power Train System, and the codes that come up are P0456 and P2421. This car has a mind of its own. I've driven it and it started lagging, and I went into limp mode just crossing a 2 way stop with ongoing traffic. I don't understand how VW doesn't address this problem when I know that if anyone were in my shoes, they wouldn't have dealt with this, going to the dealership 3,4 times a year when I should only be going in frequently for oil changes. The dealership says after my warranty is over, I have to pay out of pocket, but I don't see why, when it's been an ongoing issue and VW needs to have an extended warranty, because I know I am not the only one with issues. Reddit has thousands of complaints about VW, but it's our problem that they couldn't produce a reliable car. The dealership has been aware of this for 4 years since I bought my car in June 2021. I have had the engine light come on every 3 -5 months since June 2021, and it's always the same when they replace a whole part. I have all the paperwork and all the information on what they perform on my car. I am a regular. citizen, and I only make around 30K a year, if I were able to, I would get another car, but I've literally invested 20K in this car, and it's ridiculous how unreliable and how I constantly have to worry if the car will work. I don't have a scanner, so I uploaded how many times I've been to the dealership for one car.

NHTSA ID

11696396

Incident

Aug 15, 2021

​This statement is to formally document my ongoing and serious concerns regarding my 2022 Volkswagen Taos, which has been in and out of the Pasadena Volkswagen, California, service department for the past three weeks due to a persistent fuel smell and related fuel system issues. ​Despite the recent maintenance and attempted repairs, the vehicle continues to exhibit these dangerous problems. Most alarmingly, during a recent incident, the vehicle almost completely shut off while I was driving on the freeway. This is a critical safety hazard, and the safety of my family is paramount. I cannot accept driving a vehicle that poses such a risk of breakdown in traffic. ​Adding to my unease with the fuel issues is the fact that this specific vehicle has also previously required repair for seized rear brake calipers. Given the numerous reported complaints about the 2022 VW Taos model and the repeated, severe issues my own vehicle has experienced—from brake failure to dangerous fuel system problems—I am profoundly concerned about its reliability and long-term safety. ​The continuing issues make it difficult, if not impossible, to drive this vehicle without significant anxiety. I request an urgent and definitive resolution to these safety-critical fuel problems.

NHTSA ID

11692175

Incident

Sep 22, 2025

Stepping in the gas, the car takes about 4-5 seconds before it speeds up after each stop. When pulling out of a drive, the car sputtered and the check engine light was flashing and the Start/stop error came on. The delayed driving happens every time I drive the car. Only have about 44k miles on it. I have had multiple people almost rear end me. I have had the car for about 3 weeks now.

NHTSA ID

11689279

Incident

Sep 23, 2025

The car is telling me things are not available such as airbags, blind spot, the rear warning and the tire pressure monitoring system. As well as is has the fuel injector problem that VW has already extended the warranty on.

NHTSA ID

11687176

Incident

Sep 13, 2025

Filled my tank with gas. Got into the vehicle and started if and could almost immediately smell gas in cabin. Thought maybe I got gas the wasn’t good. Refilled twice with premium gas and smell did not go away and you could then smell it outside of the vehicle as well. Very strong, drive it to my VW Service Dealef to have it looked at then.

NHTSA ID

11682652

Incident

Aug 13, 2025

2022 VW Taos 2 instances of fuel level sensor failure. Fuel gauge reported 1/2 tank fuel level remaining when fuel tank was empty. In both instances the vehicle stalled without warning. 1) [XXX] - [XXX], fuel level sender float rod detached. 2) [XXX] - [XXX], Fuel level sensor malfunction. Both instances occurred while on state highways and car was able to be moved to the roadside safely. Had this occurred while on an interstate during heavy traffic, it is unlikely that the vehicle and driver could have been moved to safety. Dealer repaired both under warranty however, although requested, neither part was retained for customer inspection. There were no warning lamps, messages or symptoms before the vehicle stalled. Both repaired under warranty by Volkswagen of Wesley Chapel, FL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11672863

Incident

Jul 5, 2025

- The head gasket failed twice in less than one year on my 2022 Volkswagen Taos. The vehicle also experienced a fuel pump failure, rear brake pad wear down to metal-on-metal, and the underbody panel detached while driving due to being improperly secured after a dealership repair. Yes, the components may be available for inspection upon request through the dealership. - The second head gasket failure resulted in coolant loss, which can lead to engine overheating and potential failure while driving. The underbody panel detached while I was on the freeway, posing a serious safety hazard to me and other drivers. The brake system issues, including vibration and scraping noises, raise concern about brake reliability and stopping ability. - Yes, all issues were confirmed and addressed by authorized Volkswagen dealerships: DeMontrond Volkswagen (Conroe, TX) and Momentum Volkswagen (Houston, TX). - The vehicle has been inspected and repaired multiple times by Volkswagen-certified service technicians. No inspections by police or insurance have taken place. - No warning lamps appeared before the head gasket failures. The brake issues were first noticed as vibrations in the brake pedal after a service visit, followed by scraping noises, which were later diagnosed as metal-to-metal contact. The underbody panel incident occurred suddenly after leaving the dealership.

NHTSA ID

11659345

Incident

Apr 19, 2025

The contact owns a 2022 Volkswagen Taos. The contact stated that the vehicle failed to exceed above 10 MPH, with the check engine and the EPC warning lights illuminated. The vehicle was taken to a certified mechanic who diagnosed the vehicle and determined that the engine had seized and needed to be replaced. The mechanic linked the failure to failure to NHTSA Campaign Numbers: 23V214000 (Fuel System, Gasoline), 21V651000 (Fuel System, Gasoline), and Technical Service Bulletin 1523/01. The mechanic referred the contact to the dealer. The dealer was contacted and confirmed that the VIN was not included in the recalls. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer confirmed that the VIN was not covered under recall and that the vehicle had exceeded the mileage for coverage. The failure mileage was 67,168.

NHTSA ID

11643375

Incident

Feb 11, 2025

Mileage

67,168 mi

Engine has ceased at 67000 miles a mechanics has searched my VIN id number and 3 recalls have come back but Volkswagen says they are not applicable to my vehicle. I’d like to confirm this if possible

NHTSA ID

11642980

Incident

Feb 10, 2025

The fuel door release actuator seizes up and does not release fuel door. This vehicle does not have a manual fuel door release, therefore if you run out of gas you are not able to manually open the fuel door.

NHTSA ID

11627023

Incident

Nov 15, 2024

FUEL TANK SENOSOR HAS MALFUNCTIONED WITHIN 2 YEAR OF OWNING VEHICHLE. DEALER SAYS THE WHOLE FUEL TANK NEEDS TO BE CHANGED

NHTSA ID

11622521

Incident

Aug 1, 2024

The radio system constantly blanks out and will not come back on for hours even after trying to turn it off and back on. There are major issues that point to the recalls that are known for the 2022 VE Taos however, there are no recalls for my specific vehicle. The vehicle check engine light is constantly on and there is constantly an issue with the fuel system. The Taos has issues with acceleration and shifting into other gears. The Taos now has a ticking sound and is at the mile range of (50,000- 60,000) which others who have complained about engine failures. This has been a current and ongoing problem with this vehicle and has cause a headache.

NHTSA ID

11620288

Incident

Jan 1, 2024

My Hose attachment for the fuel that leads into the engine was leaking and it could have started on fire, VW Schumacher failed to catch this, a local mechanic found this problem, my check engine light keeps coming on as well.

NHTSA ID

11609763

Incident

Jul 22, 2024

I have 44,000 miles on my 2022 VW Taos. The EPC warning light came on. Took it to VW dealership. It needed a “software update”, which was still covered under warranty

NHTSA ID

11609086

Incident

Aug 16, 2024