2002 Chevrolet Avalanche Other / unspecified Problems

GM HAD REPAIRED THE RUST BRAKE DEFECTS ON MY TYPE OF VEHICLE IN MANY SALT STATES THAT ENDURE COLD WEATHER. BUT BECAUSE THERE WAS NOT ENOUGH OUTRAGE THEY DID NOT REPAIR THIS SAME DEFECT IN MY STATE. THERE IS A PROBLEM WITH THE WHEEL BEARINGS WHERE RUST CAUSES THE ANTI LOCK BRAKING SYSTEM TO NEEDLESS ENGAGE WHEN IT SHOULD NOT DURING SLOW SPEEDS SOMETIMES MAKING BRAKING DANGEROUS IN SLOW TURNING AND PARKING SITUATIONS. I HAVE ALREADY SPENT THOUSANDS OF DOLLARS FIXING THESE DEFECTS ON MY OWN BUT BECAUSE OF A FAULTY DESIGN IN THE SYSTEM THIS PROBLEM HAS A TENDENCY TO RE OCCUR. *TR

NHTSA ID

10626730

Incident

Aug 5, 2006

2002 CHEVY AVALANCHE BRAKE LINES RUSTED THROUGH. WE BOUGHT THE CAR TWO YEARS AGO IN PA. WITH THE CARFAX SHOWING IT HAS BEEN HOUSED ONLY IN NJ AND PA SINCE 2002. WE CURRENTLY LIVE IN NC MOVING HERE ONLY LAST OCTOBER. YESTERDAY WHILE DRIVING WITH MY FAMILY GOING 45 MILES PER HOUR, A CAR IN FRONT OF ME WAS MAKING A RIGHT HAND TURN AND AS PER PROPER PROCEDURE I ATTEMPTED TO SLOW DOWN. MY BRAKE PEDAL WENT COMPLETELY TO THE FLOOR BOARD OF THE TRUCK WITH NO RESISTANCE, AND I WAS UNABLE TO STOP MYSELF. I ENDED UP IN THE DITCH TO AVOID AN ACCIDENT WITH THE VEHICLE IN FRONT OF ME, AND HAVE CONTINUED TO HAVE ISSUES WITH NO RESISTANCE ON THE BRAKES. MY HUSBAND ORIGINAL THOUGHT THE ISSUE WAS THE CYLINDER. BUT AS HE WAS STARTING TO REPLACE THAT PART HE NOTICED A FLUID DRIPPING FROM THE TRUCK. AND UPON FURTHER INVESTIGATION DISCOVERED THAT IT WAS BRAKE FLUID. HE BOUGHT ALL NEW BRAKE LINES AND IS IN THE PROCESS OF THE LONG JOB OF REINSTALLING THEM. *TR

NHTSA ID

10514143

Incident

May 29, 2013

PULLING OUT OF DRIVEWAY AND BRAKES COMPLETELY WENT OUT. LUCKILY I WAS ONLY GOING AROUND 5 MPH. WAS ABLE TO USE EMERGENCY BRAKE TO SLOW TRUCK DOWN NEXT TO THE CURB. *TR

NHTSA ID

10495973

Incident

Dec 28, 2012

Mileage

113,976 mi

I WENT OFF ROAD AT 45 MPH AIRBORN STRUCK A VERY LARGE TREE WHICH CAUSED VEHICLE TO ROLL OVER VIOLENTLY LANDING ON ITS TOP. NO AIR BAGS DEPLOYED, BOTH MY WIFE AND I WERE EJECTED FROM THE SEAT BELTS ONSTAR WAS NOT NOTIFIED. I NOTICED BRAKES ACTING STRANGE JUST BEFORE LEAVING THE ROAD, THEY DIDN'T SLOW THE VEHICLE AND DIDN'T "CLICK" LIKE ANTILOCK BREAKS SHOULD. VEHICLE WAS A TOTAL LOSS, WINDSHIELD AND DRIVERS WINDOW BROKE, SEVERE BUCKLING OF HOOD, PASSENGER SIDE PUSHED BACK TO THE TIRE, FRAME TORN IN SEVERAL AREAS, DUCT AND LOWER DASH AREA DISPLACED, SDM WAS DOWNLOADED SHOWING INCOMPLETE DATA, SDM DATA DOES NOT SUPPORT THE AMOUNT OF DAMAGE AND KNOW FACTS. MY WIFE HAD TO BE AIRLIFTED TO TRAUMA CNTR WITH SERIOUS INJURIES, MY INJURIES WERE PUT ON HOLD SO THAT I COULD BE WITH HER. *NM

NHTSA ID

10147182

Incident

Nov 21, 2005

Mileage

85,689 mi

IN THE PAST YEAR, WE HAVE HAD TO REPLACE THE REAR DRIVER SIDE BRAKE PADS OF VEHICLE AND HAVE ALSO HAD TO REPLACE THE CALIPER AS IT EXPLODED. THE BRAKE PADS WERE CHANGED FOR THE 3RD TIME ON 05/23/05. LUCKILY, THE CALIPER HAS NOT EXPLODED AGAIN. THE REMAINING BRAKE PADS ON THE FRONT OF THE TRUCK AND REAR PASSENGER SIDE ARE FINE.

NHTSA ID

10122004

Incident

May 23, 2005

WATER LEAKING INTO THE PASSENGER COMPARTMENT, CAUSEING THE CARPET TO GET DRENCHED, VEHICLE IS RED IN COLOR. *AK

NHTSA ID

10067607

Incident

Jul 14, 2003

I HAVE NOT GIVEN PERMISSION TO THE DEALERSHIP SERVICE DEPARTMENT TO START REPAIRS. THEY TOLD ME IT WAS THE REAR AXLE OR REAR END THAT WAS DAMAGED BEYOND REPAIR AND MUST BE REPLACED. I WAS QUOTED A REPAIR COST OF $2,400 FOR A USED PART AND $3,000 FOR A NEW PART. THIS TRUCK HAS AROUND 42,000 MILES AND WAS PURCHASED JUNE 1, 2003. I HAVE HAD MULTIPLE PROBLEMS RANGING FROM REPLACEMENT OF CD'S TO A DOOR WINDOW MOTOR PROBLEM. I INQUIRED/COMPLAINED ABOUT A NOISE IN THE REAR END AT AROUND 25,000 MILES PRIOR TO THE BREAKDOWN. HOWEVER, THEY COULD NOT FIND THE PROBLEM. THE TAILGATE WOULD FALL OPEN WHEN LOCKED OCCASIONALLY, BUT THIS WAS ADJUSTED AFTER TAKING IT BACK FOR REPAIR. I HAVE ALSO REPLACED ONE HUB ASSEMBLY ON THE FRONT OF THE TRUCK AT A COST OF $250.00. THERE IS AN OIL USAGE PROBLEM THAT REQUIRES AN ADDITIONAL QUART TO BE ADDED BETWEEN CHANGES. I PERSONALLY THINK THAT THIS TRUCK IS A LEMON AND NEEDS TO BE RESEARCHED TO DISCERN IF IT HAS HAD SOME PREVIOUS MECHANICAL PROBLEMS. ALTHOUGH IT WAS PURCHASED NEW THERE IS A POSSIBILITY THAT IT COULD HAVE HAD SOME MALFUNCTIONS BEFORE IT WAS DELIVERED. I MISPLACED MY RECEIPTS, AND I'M NOT SURE THAT THE SERVICE DEPARTMENT WILL GIVE ME ANOTHER COPY. HOWEVER, I WILL SEARCH FOR THEM AS VERIFICATION THAT I TOOK THE TRUCK IN ON SEVERAL OCCASIONS FOR VARIOUS AND SUNDRY COMPLAINTS.

NHTSA ID

10070167

Incident

Nov 15, 2003

SIMILAR TO COMPLAINT ODI 766153. THIS OCCURRED , TWICE THIS YEAR, INITIALLY 1/10/03, BRAKES DRUMS AND ROTORS IN REAR WERE SEVERELY WORN. 2ND DATE SHOWN BELOW. OUTSIDE RIM ALSO BECAME BROWN AND CORRODED. DEALER REPAIRED AND REPLACED DUE TO 3/36 WARRANTY. *NLM

NHTSA ID

10016527

Incident

Apr 25, 2003

Mileage

20,000 mi

THE INCIDENT ON MAY 11, 2002. THE DRIVER SIDE REAR TIRE BLEW OUT WHILE TRAVELING ON THE FREEWAY GOING 65 MPH. THE VEHICLE ONLY HAD 8827 MILES AND HAD ORIGINAL WHEELS AND TIRES. THE INCIDENT ON NOVEMBER 10, 2002: THE LEFT FRONT WHEEL, INCLUDING THE DISC BRAKE MECHANISM, SEPARATED AND BEARING PARTS, ETC. WERE SCATTERED ON THE STREET. THE EXPOSED WHEEL WELL DUG INTO THE CONCRETE AND SHOCK ABSORBER AND STRUTS CLEARLY VISIBLE WITH WHEEL SEPARATED. PHOTOS ARE AVAILABLE IF NEEDED. DT

NHTSA ID

769586

Incident

Nov 10, 2002