RoadVitals

1997 Chevrolet Express

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
29
Latest Feb 22, 2016
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Apr 7, 2009
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
3
1 injuries, 0 deaths reported

Overview

Our database contains 29 NHTSA owner-reported complaints for the 1997 Chevrolet Express, most frequently naming the transmission, tires & wheels and body & structure categories. 2 safety recalls have been issued covering this model year; and 47 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Transmission618.8%
  • Tires & wheels39.4%
  • Body & structure39.4%
  • Brakes39.4%
  • Engine39.4%
  • Fuel system39.4%
  • Other / unspecified26.3%
  • Electrical26.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
09E012000

EXTERIOR LIGHTING

Apr 7, 2009
16,270 units potentially affected
The defect: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
SABERSPORTView on NHTSA.gov
00V110000

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Apr 17, 2000
109,239 units potentially affected
The defect: PASSENGER VANS. THESE VANS EXPERIENCE FUEL ODORS OR LEAKAGE.
The risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
The remedy: DEALERS WILL INSTALL A REVISED EVAPORATIVE EMISSION PIPE ASSEMBLY.
GENERAL MOTORS CORP.Manufacturer number 00031View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 29
Fuel system
Filed Feb 22, 2016

TL* THE CONTACT OWNS A 1997 CHEVROLET EXPRESS. THE CONTACT STATED THAT A FUEL ODOR CAME FROM THE VEHICLE AND THE VEHICLE LEAKED FUEL ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE. UPDATED 04/22/16*LJ UPDATED 05/31/18*JB

NHTSA ID
10837621
Incident
Dec 1, 2015
Body & structure
Filed Mar 28, 2006
1 injury reported

DT*: THE CONTACT STATED THERE IS A HOOK ON THE REAR PASSENGER SIDE DOOR. THE CONTACT'S HEAD STRUCK THE HOOK, WHICH RESULTED IN THE CONTACT LOSING CONSCIOUSNESS AND HERNIATING TWO DISCS. THE MANUFACTURER SENT A REPRESENTATIVE, WHICH DETERMINED THIS IS HOW THE VEHICLE WAS DESIGNED.

NHTSA ID
10153907
Incident
Mar 28, 2006
Mileage
200,000 mi
Tires & wheels
Filed Mar 20, 2006

DT*: THE CONTACT STATED WHILE TRAVELING 75 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS PULLED OVER INTO THE MEDIAN AND THE TIRE WAS CHANGED. TWO HUNDRED MILES LATER, THE PASSENGER SIDE REAR TIRE BLEW OUT. THE VEHICLE WAS PULLED OVER TO THE SHOULDER AND THE TIRE WAS REPLACED. THE TIRES WERE SENT TO THE MANUFACTURER WHICH DETERMINED THE BLOWOUTS WERE A RESULT OF ROAD HAZARDS. UPDATED 4/6/2006 - THE CONSUMER BELIEVES THE FAILURE WAS DUE TO TREAD SEPARATION. *NM

NHTSA ID
10153221
Incident
Feb 13, 2006
Mileage
67,000 mi
Transmission
Filed Feb 22, 2006

THE TRANSMISSION HAD AN OVERHEATING PROBLEM THAT CAUSED THE VEHICLE TO SWITCH TO "SAFE" MODE. SAFE MODE COMPENSATED THE TRANSMISSION HEAT PROBLEM BY HARD SHIFTING. THE VEHICLE WAS TAKEN TO A TRANSMISSION SPECIALTY REPAIR SHOP WHERE I LEARNED THAT THE PROBLEM WAS IN THE DESIGN OF THE TRANSMISSION. IT WAS THE OPINION OF THE REPAIR SHOP THAT GM KNEW OF THE PROBLEM BUT WOULD NOT ISSUE A RECALL BECAUSE THE ISSUE WAS NOT LIFE THREATENING. COST OF MODIFICATION WAS $1,600.*JB

NHTSA ID
10150952
Incident
Jun 15, 2005
BrakesEngineTransmission
Filed Sep 21, 2005

DT: WHILE DRIVING SERVICE ENGINE LIGHT ILLUMINATED ON THE DASH PANEL. THE CONSUMER TOOK THE VEHICLE TO A CHEVROLET DEALER, WHO PERFORMED A DIAGNOSTIC TEST WHICH SHOWED THAT TRANSMISSION WAS SLIPPING. THE DEALER NOTED THE NEXT STEP WOULD BE TO CHECK THE TRANSMISSION FLUID. DUE TO THE COLOR OF THE FLUID IT WAS DETERMINED A NEW TRANSMISSION WOULD BE NEEDED. THE DEALER REFERRED THE CONSUMER TO OTHER INDEPENDENT SHOPS, AND THEY TOO CONFIRMED WHAT THE DEALER SAID. THE CONSUMER TOOK THE VEHICLE HOME AND PARKED IT. NO CORRECTIONS OR REPAIRS WERE MADE. THE CONSUMER CALLED CHEVROLET MANUFACTURER, AND THEY SAID THERE WAS NOTHING THEY COULD DO. THE CONSUMER CONTACTED CHEVROLET AGAIN, AND THEY ESCALATED HIS CONCERNS BUT OFFERED NO FURTHER ASSISTANCE. *AK UPDATED 05/06/08 *BF THE CONSUMER STATED THE ABS AND MASS AIR FLOW SENSOR FAILED. UPDATED 05/06/08

NHTSA ID
10137203
Incident
Sep 15, 2005
Mileage
78,900 mi
Exterior lighting
Filed Sep 16, 2005

TAIL LIGHT SOCKET FAILURE, NEW SOCKETS ARE GOING TO BE INSTALLED. *JB

NHTSA ID
10136757
Incident
Sep 13, 2005
Mileage
82,000 mi
Seat belts
Filed May 16, 2005

DEFECTIVE SEAT BELT WAS MOUNTED ON MIDDLE CAPTIAN CHAIR, STARCRAFT CONVERSION VAN. CABLE BROKE FROM NORMAL USAGE?

NHTSA ID
10121014
Incident
Mar 2, 2005
Mileage
185,000 mi
Transmission
Filed Oct 4, 2004

WHILE SHIFTING TRANSMISSION DOWN SHIFTED ON ITS OWN. A LOUD NOISE WAS HEARD COMING FROM THE FRONT. CONSUMER DROVE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT TRANSMISSION NEEDED TO BE REPLACED. *AK

NHTSA ID
10095028
Incident
Oct 4, 2004

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

17-NA-073

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

PIP4723F

FUEL SYSTEM, GASOLINE; SERVICE BRAKES, HYDRAULIC

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

PIP4723D

ELECTRICAL SYSTEM

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

19NA273

ELECTRICAL SYSTEM; EQUIPMENT

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

PIC4696E

EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

17NA073

EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Chevrolet Express by model year
YearComplaintsRecallsInvestigationsIssue Index
2026030—
2025040—
2024100—
2023210—
2022410—
2021132055.4
2020161052.5
2019840—
2018116048.4
2017206047.6
2016156052.0
2015831—
2014147048.6
2013228046.1
2012136064.6
2011125054.4
2010155053.7
2009107049.4
20081410040.9
2007174057.5
20061216067.9
2005239063.5
2004217156.6
20035811264.3
2002550137.1
2001452152.7
2000841144.5
1999682044.7
1998232046.4
1997Viewing292049.8
1996153055.0
1995100—
1994000—
1993000—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.