2022 Chevrolet Silverado 1500 Brakes Problems

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that upon starting the vehicle, there was a message related to brakes. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and there was an abnormal grinding sound coming from the brakes. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The dealer informed the contact that the brake sensors had detached. The repair was not covered under warranty. The manufacturer was contacted and confirmed that the repair was not covered under warranty. The failure mileage was approximately 35,000.

NHTSA ID

11744942

Incident

Apr 1, 2026

Mileage

35,000 mi

All kinds of warning signals come up like 4 wheel drive on, off, roll up and down driver window, no brake pads detected, no washer fluid, service esc, service 4 wheel drive, traction control on and off, radio blacks out, lights dim, feels like rear wheels lock up and release, transmission feels like it's going to shake out of the truck. Dealership sold it like this and was sent back to be fixed and they said it was fixed and I was just stuck with it. They said they fixed the recalls and in fact did not

NHTSA ID

11739773

Incident

Dec 31, 1969

I replaced rear brakes and rotors after getting brake monitor warning on 2022 silverado 1500. I have been having problem with amount of force needed to stop truck for quite a while. The pads were not worn much at all but brake pad clips were broken on both sides of rear brakes. Rotors were rusted which looked as if rear brakes have not been contacting rotors. The brakes work significantly better now. I live in NC where rust is not serious problem. I feel there is a problem with rear brake hardware on these trucks

NHTSA ID

11725937

Incident

Mar 2, 2026

Truck has been experiencing intermittent stalling since 1200 miles. Was reported to the dealer and manufacturer. At approximately 20,000 miles (Spring 2025) the truck stalled out at high speed on the highway at approximately 70 mph near Tennessee during a work trip. When stalled, truck lost its ability to steer and break causing the truck to drive off the road and only stopped due to the truck rolling to a stop off-road. Luckily nothing was seriously damaged and it was a rural area with minimal traffic and flat grass lands on the side of the highway.

NHTSA ID

11715005

Incident

May 16, 2025

Was taking an exit car felt like lose control and got hit with the sign pole on the exit. I have been complaining for the safety reasons and the location and other issues in car to onstar and Chevy for months. Went to Freeport Chevy dealer and changed oil, when I bought the car pre-approved but the when I went for the service they said no oil was changed since the car was new. And I have been paying for all the warranty and extended service but they said all oil change and others will cost approx $3200. They changed the oil but I have been seeing on the Chevy app filter was never changed and the car didn’t feel same after the service.

NHTSA ID

11705741

Incident

Dec 14, 2025

Valve body failed in Dec. 2024 and they replaced it. Valve body failed again in April 2025, they replaced it with new. Valve body failed again in Oct 2025, they said they will not replace it. The brakes locked up for a few seconds making a loud noise, it would not go in reverse which i showed the mechanic all three times, and it would not go over 35mph. they told me the new transmission they put in it in April of 2025, was not warrantied. This has been an on going issue since the original recall, and they refuse to fix it correctly. You will see from the documents, it has been in the shop 6 times in 10 months. now it sits in my yard because I don't want to get in a accident if it goes out while I'm driving. I can not go south for the winter like we usually do because of the truck. Chevy doesn't seem to want to fix the on going issue which was a recall.

NHTSA ID

11705268

Incident

Dec 6, 2024

While towing a camping trailer, the brakes for the trailer kept issuing a warning saying "connected" then "not connected - check trailer brake wiring". Then "trailer brake not connected". After a while the brake system stopped working entirely. The 30 amp fuse that controls the trailer braking system blows out. This fuse is not a common fuse and not available at some auto parts stores (not really convenient while towing away from home). Evidently there is a problem with the brake control module that is factory installed. The module does not like the charging system on the trailer battery. I have spent hundreds of dollars and many hours in different shops trying to trace down this problem. It is very unsafe to have the trailer brakes not work while driving. This faulty module needs to be recalled. Part # 23306694

NHTSA ID

11685542

Incident

Apr 11, 2024

The trailer brake controller goes off and on. A message in the truck reads trailer brakes off, trailer brakes on, check wiring. Repeats every 45 seconds or so. You never know when you have trailer brakes or not. Did not have trouble prior 3 years with a different truck? I saw 2022 trucks had a safety recall but my Vin was not included, which it should have. Very dangerous.

NHTSA ID

11684573

Incident

Aug 30, 2025

While driving, speed can vary, but yesterday we were going almost 50, and the transmission or brakes lock up which causes the back axel to lock up and the tire squeal, similar to slamming on the brakes. It caused my truck to sway side to side and scare the hell out of my son. Definitely not safe. The local dealer says it is a stuck valve or something. It has caused the engine light to come on multiple times, but will go off after 24 hours or so. But it keeps occurring. Happened 3 times on 7-8-25. Give a whiplash feeling to the body as well. One coded P0747 Transmission Solenoid Valve 1 Stuck on invalid configuration Other time was P0700 Transmission Control Module Requested Malfunction Please issue a recall so this can be resolved before an accident or injury occurs.

NHTSA ID

11672146

Incident

Jul 8, 2025

Driving across town, rear wheel lock up occurred. Feels like hitting a small tree. Scary situation. Whole truck is rocked.

NHTSA ID

11664293

Incident

Jun 2, 2025

Driving across town. Going around 30 mph. Through a busy intersection and the rear wheels locked up again. Sends a jolt to anyone in the vehicle. Causing a whiplash effect. Scary as hell. Seems to happen almost daily now. Very unsafe. Worried about myself and anyone behind me. Dealer and other mechanics described it as "momentary wheel lock up". Please issue a recall.

NHTSA ID

11663763

Incident

May 29, 2025

When accelerating, it started around 35 mph, I would be driving and it would feel like hitting a speed bump, even though there wasn't a speed bump. Over the past month, it has moved to about the 45 mph, and the rear wheels completely lock up for a second, cause the tires to "squeal" as if slamming on the brakes. It gives anyone in the vehicle a whiplash effect. Any loose items in the truck will go flying. It is a scary situation and I am worried it is going to cause damage to myself or my passengers or cause an accident. The term given to me by the dealer is "Momentary Rear Wheel Lock-Up". They were very familiar with the issue, but since my VIN wasn't on the recall, they wouldn't do anything. This has happened numerous times, starting back in early March. The issue has escaladed and gotten worse. The latest date is noted below.

NHTSA ID

11663321

Incident

May 26, 2025

2022 Chevy Silverado 1500 is unable recognize that it has been placed in park consistently, essentially trapping us in the vehicle until the "Shift to Park" error gets corrected. After shifting the vehicle into park and pressing the button to turn off the vehicle, an error comes up on the dash saying "Shift to Park". In order to clear this error and have the vehicle recognize that it is safely parked, we must turn the vehicle back on, put the vehicle in reverse or drive, and depress the gas pedal to move the vehicle slightly, shift the vehicle to park again, wait at least 30 seconds to a minute, and then finally press the button to turn off the vehicle. And we must repeat this anywhere from 3 to 15 times until the brakes safely engage to park the vehicle. I worry that the vehicle wont safely go into park and will roll away on its own. This is the same error that was reported for other GM models recently and is affecting the safety, reliability, usability, and longevity of this vehicle.

NHTSA ID

11659302

Incident

May 5, 2025

We have had several issues with our vehicle from early ownership, such as, (1) signal light goes from very fast blinking to working. We have taken it to the dealership and are told they cannot duplicate the issue. It seems to correct itself when you turn off the truck and turn it back on. (2) the digital screen about the steering wheel where all all your gauges are have gone completely black. I took it to the dealership and was told that they had to keep the truck until they could duplicate the issue, but again, turning off and then turning it back on seemed to help. Sometimes it works on the first restart, and others it takes a few times and longer times between restarts. (3) OnStar has stopped communicating with my vehicle about a year, year and half in. (4) Google maps has never worked. (5) Remote starts works sometimes. (6) Auto-shut off works sometimes. (7) Air Conditioner started having issues last summer. We have to turn off and on the vehicle or rev up the engine so that it will kick in. This works sometimes and sometimes it doesn't. (7) ESC and traction control lights came on, the truck starts shaking, and brakes locked. Truck had to be towed to nearest dealership. The truck only had 12K miles when this happened. (8) Around the same mileage, an injector had to be replaced. (9) Now at 52K miles, we have the ESC, traction control, and check engine light again. Truck is shaking, feels like the gears are slipping when you press on gas, and has white smoke coming from the mufflers. These issues have been report to both local dealership and GM corporate office. these issues have left us stranded 300 miles from home and has left us without air conditioner in 3-digit weather when we had our grandbaby with us.

NHTSA ID

11646634

Incident

Mar 5, 2025

Service brake assist message on dash, with check engine light. Brakes are almost useless takes excessive force to get vehicle to stop. Resets after being parked and restarted. has happened several times but will not replicate a dealer. Started with less then 2500 miles on the truck.

NHTSA ID

11646195

Incident

Apr 15, 2023

Vehicle emergency/parking brake actuators failed which could allow the vehicle to roll-away unexpectedly or render this safety braking system inoperable in time of emergency. There is a TSB number PIT 5662G, dated March 25, 2022 that covers testing to confirm defective actuators. This is a known defect to Chevrolet and as it impacts a vehicle operating safety system should be subject to a recall.

NHTSA ID

11618178

Incident

Aug 1, 2024

While driving at highway speeds, the vehicle has spontaneously locked up the front brakes/wheels three separate times. All three times have been at 55- 65mph and have completely locked up the front brakes leaving tire marks on the pavement. No Automated Braking System engaged, just full lock up. No warning lights or OBD codes and the dealer mechanics can find nothing wrong.

NHTSA ID

11617224

Incident

Aug 29, 2024

Brake failure warning notification and brakes went soft without warning. Almost rear ended vehicle in front of me.

NHTSA ID

11587050

Incident

May 5, 2024

When my windshield wipers and headlights have been on for an extended period of time, they tend to cut out. My lights will flicker one time and my windshield wipers freeze for a brief second. Also my vehicle has around 36,000mi and recently a “monitor brake pads” has popped up. I have looked at my brakes and they have plenty of life left. I am not sure what to do. My truck should not be “glitching” and having electrical problems, especially with the amount of money it costs.

NHTSA ID

11576308

Incident

Mar 6, 2024

A wire box fell down from behind the dash, and landed behind the brake pedal. This created a severe emergency situation in that the brake pedal could not be depressed at a traffic light, almost causing a car accident. The dealership explained that they have seen this problem before, but it's not a current recall, but should be. I've also been in contact with GM Customer Care [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11575508

Incident

Mar 2, 2024

Started my truck and drove off. 10 seconds later all of the lights on instrument cluster came on and displayed steering assist reduced the. It said service brake assist. My brakes weee very spongy and hardly worked luckily I was only driving 20 mph and no one was in front of me. I had to disconnect battery and reconnect to fix the problem. What if I was on the highway doing 70 mph and had to hit my brakes suddenly. Someone or multiple people could have been injured. This truck has 13,000 miles on and it’s a year old. I have ready many reports online of this happening in earlier models. How can car manufactures get away with this ?

NHTSA ID

11566769

Incident

Jan 20, 2024

Engine stalled at highway speed 50mpr, disabled brakes, and steering. I coasted to a stop with absolutely no power. Engine would not restart for 2 minutes. No Engine lights or codes present but warning on dash read service trailer brake system disabled. I drifted to a stop with no brakes at all or power steering. We were not hauling any trailers and no trailer was connected. This was the scariest event I've ever experienced driving. Very unhappy when they're was no reason to stall. Gas tank was half full.

NHTSA ID

11565762

Incident

Jan 16, 2024

While drive 70mph on the highway the service steering column lock message displayed and the steering column locked. The service traction control warning displayed and vehicle traction control system began malfunctioning and tires began locking up. Break system failure message displayed, vehicle lost power to functional breaking capability. Trailer breaks disabled warding displayed, service required. Service ECS message displayed. Control of vehicle was lost, was able to naturally decrease speed and no accidents occurred. During this time, all control of breaking system was lost and steering function was lost. There was minimal traffic and I was able to turn my hazards on. Vehicle came to a complete stop in the right lane of the highway which could have cause a fatal crash. Intermittent steering functionality resumed after vehicle stopped allowing my to drive 5 mph to the exit ramp to move to safety. During this time, break system was not operational and potentially could have continued to cause an accident.

NHTSA ID

11554482

Incident

Nov 9, 2023

I was driving at about 40 mph and went to brake and the brake pedal went to the floor with multiple lights appearing on the dash including a warning "brake system failure max speed 43 mph" as well as "service ESC". The brake light went on as well as the ABS light and the check engine light. Brakes were not fully functional and were like old manual brakes that you had to press hard on to slow down. I was fearful getting back to the house. Multiple warnings appeared on my Chevy app. Today I started to move in the driveway to clean up as I am taking to dealer tomorrow. All lights are off and the brakes now appear to work. The warnings are off of the app now (curious as to why for such a potentially lethal event) I have screenshots of the dash warnings but neglected to get a screenshot in the app. My fear is that the dealer will blow this off and the app shows all is good only to leave me drive this for them go out again. This is a signifivant safety issue for Chevy (and for my family)

NHTSA ID

11553127

Incident

Oct 31, 2023

While driving the truck, something electrical seems to "reset" and upon that occurring, the brakes and other things quit working. This has happened in this truck twice within the last 10,000 miles. The dealership "resets the electrical system" and the truck runs fine for a period of time, but it has happened twice that the brakes have failed while going down the road.

NHTSA ID

11537445

Incident

Jun 30, 2023