2024 Chevrolet Silverado 1500 Engine Problems

My vehicle was serviced for the Chevy L87 recall a couple of thousand miles ago. It currently has 13343 miles on it and I was driving down the road and then all of a sudden the engine just stopped and my vehicle lost power leaving me stranded on a state route XXX in [XXX], which is a dangerous route with nowhere to pull off. This issue has been going on for years now and Chevy needs to make this right. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11766011

Incident

Sep 21, 2026

Got my truck back yesterday from in shop for 2 weeks from being repaired. Got to red light just stopped my engine shuts off. Dash shows engine/transmission problems. Exact same thing happened two weeks ago. Had to get towed into dealer again this am

NHTSA ID

11763787

Incident

Sep 12, 2026

The contact owns a 2024 Chevrolet Silverado 1500. The contact stated that the vehicle had been experiencing inaccurate DEF gauge readings since the purchase, and the failure mostly occurred while towing a camper or trailer. The contact stated that while driving 70 MPH on the highway and hauling a camper, the message that the DEF tank was empty and needed to be refilled was displayed, and the vehicle went into LIMP Mode and decelerated to 35 MPH. The driver continued driving and pulled over to a safe location. The vehicle was taken to a dealer, where it was determined that the DEF tank needed to be replaced; however, the manufacturer denied authorization because the required preliminary procedures had not been completed. The manufacturer General Motors LLC was notified of the failure by phone. The failure mileage was approximately 4.

NHTSA ID

11763307

Incident

Jun 15, 2024

Mileage

4 mi

6.2L/L87 engine passed PICO test in August 2025 (24,190 miles). Switched to 0W-40. Engine lost propulsion in June 2026 (32,371 miles). Towed to dealer. Engine replaced in July 2026.

NHTSA ID

11762594

Incident

Jun 14, 2026

Original 6.2L engine was replaced subsequent to NHTSA Report 11724274 from Catatrophic engine failure on January 31, 2026 at 25,274 miles. Original engine was manufactured on May 30, 2024, but Silverado HC was manufactured on June 9, 2024, so it was not captured in existing NHTSA Campaign 25V‑274 and subsequent GM 6.2L Recall and is not currently included in expanded factory 10/150,000 powertrain warranty. Due to original catastrophic engine failure due to crank and connecting rod, covered transmission damage was discovered, truck is currently on third Torque Converter and Transmission has been out of truck for repairs to Valve Body and 4-10/reverse piston twice. Replacement 6.2L engine lasted 3,900 miles before exhibiting significant Lifter Tick Bank One/Driver Side, Tear down revealed failed lifter which wiped out a lobe on Cam. GM TAC refused engine replacement, instead replaced one Cam, 16 lifters and trays on Bank One. Drove truck for approximately 300 miles after repair and Engine began exhibiting significant knocking from bottom of engine, second replacement engine is now being installed. All routine maintenance and Warranty work has been performed and documented at GM certified Dealer Service Department.

NHTSA ID

11762490

Incident

May 26, 2026

2024 Silverado 3.0 Rst turbo replacement, followed by engine replacement at 80K miles. Advised the dealership about the transmission at about 85k miles. At 103,000 miles the transmission failed. GM is denying any responbility. This is already a known issue yet GM keeps denying it. Major saftey issue from the beggining of the purchase. Every complaint has been noted by the dealership.

NHTSA ID

11762420

Incident

Jun 1, 2026

The engines lifters failed in cylinder 7 . In which the engine had to be replaced. It has had all of the proper services on time.

NHTSA ID

11761648

Incident

Jul 14, 2026

This vehicle is a 2024 Chevrolet Silverado 1500 featuring a 6.2L V8 engine and a 10 speed transmission, currently at 58,136 miles. The vehicle was experiencing a severe shudder. An official GM Technical Assistance Case (TAC) engineering case was opened on July 30, 2026 confirming a verified DFM cylinder deactivation or valve train malfunction. However, on August 21, 2026 the dealership falsified the repair log by printing ‘Concern Not Duplicated’ to the manufacturer, while physically installing an unapproved aftermarket Range Technology DFM Eliminator module into the vehicle’s engine harness to artificially override the factory emissions and cylinder deactivation programming to mask the mechanical failure. This vehicle is part of the active NHTSA Engineer Analysis EA26005, and the manufacturer’s dealer network is actively using unapproved third party hardware shortcuts to evade mandatory warranty repairs before the vehicle’s 60,000 mile factory powertrain limit expires. I called GM to report and request a warranty freeze and regional field engineer to go to a different dealership and was told they can’t freeze a warranty because the TAC was closed on August 28, 2026 as resolved even though it was not resolved.

NHTSA ID

11761073

Incident

Aug 21, 2026

July 2025. 2024 Chevrolet Silverado 1500 Vehicle mileage 18k 6.2L engine. Lack of Propulsion under normal, in-traffic, highway operation at highway speeds. Potential safety issue to myself or others, due to failure and lack of Propulsion. Issue was confirmed by dealer. Metal shavings in oil pan and oil filter. Bearing failure, recall item, however engine failure before recall engine could be replaced. Engine replaced quickly and without issue. Dealer was extremely professional, helpful, and a pleasure to deal with. UNKNOWN if vehicle was inspected by anyone other than dealer. UNKNOWN if any warning lights prior to failure. No messages or symptoms prior to failure.

NHTSA ID

11760786

Incident

Jul 26, 2025

Check engine light repeatedly comes on. Take it in, multiple Chevy dealerships “fix” the errors such as fuel line pump 5x, gear shift issues, modules that went bad and various other issues. I Routinely take care of vehicle (oil changes, tire rotations and service when needed) This truck will randomly shut off while driving (stop and go traffic ) I was told to turn off the start/stop which I do every time I get in the truck. However it recently wouldn’t turn over after going through a car wash, it would try and try till I manually stopped it. It’s running rough now and I pray everyday the check engine light doesn’t come on or that it doesn't just shut off mid drive. This truck has been hell on wheels and I bought it with 10 miles on it. Bought it from AutoNation in 12/2023.

NHTSA ID

11760615

Incident

Jul 15, 2026

Not that anything has happened to my truck but im genuinely worried that something bad will happen with my motor. With it being the 6.2L L87 motor. My truck was manufactured july 2024 which is 2 months after Gm's cut off. I love the truck but im worried about going to and from work, what if i was to turn and this truck dies and i go into oncoming traffic? What about everyone else driving their own vehicles? I hope something is done because im really thinking about getting rid of this truck in fear of something bad happening. Thank you.

NHTSA ID

11760572

Incident

Aug 28, 2026

This complaint is in relation to the investigation into the GM L87 (6.2L engine) investigation. I own a 2024 Chevrolet Silverado with the L87 engine. I had my truck inspected through the recall a few months ago and the engine passed at that time. The engine oil was changed by the dealer per the recall at that time. On August 23, 2026, I was traveling at highway speeds on an interstate highway when my truck began to lose power, downshifted hard three times and died in the middle of the highway. The truck shifted to nuetral and I was able to coast off the highway into a rest area. I attempted to start the struck but nothing happended. I had the truck towed to a dealer. They inspected it on August 25, 2026 and determined the engine had a catastrophic failure and needed to be replaced. I am currently waiting on a replacement engine

NHTSA ID

11760290

Incident

Aug 23, 2026

The contact owns a 2024 Chevrolet Silverado. The contact stated that while driving at 69 MPH when the vehicle experienced a total loss of automotive power and all of the warning lights were illuminated; a message was displayed on the instrument panel "Reduce Acceleration, Drive with Care" and the vehicle was towed to a local dealer where it was diagnosed and the contact was advised that engine had experienced catastrophic engine failure as a result of the pistons and rods exploding into the engine, and that the engine would have to be replaced. The vehicle was repaired, however the check engine warning light had remained illuminated. The manufacturer was notified of the failure. The failure mileage was 7,948.

NHTSA ID

11760151

Incident

May 4, 2026

Mileage

7,948 mi

The engine has a loud knock and tick noise, the dealership said vehicle was fine changed the oil to a thicker oil and sent me on my way. No messages or symptoms besides the loud noises engine still running but has loud knock and tick noise from time to time after the oil was replaced

NHTSA ID

11759829

Incident

May 1, 2026

The contact owns a 2024 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the vehicle stalled on several occasions. No warning light was illuminated. The vehicle was restarted and drove as intended. The vehicle was taken to the dealer several times, but no repair was performed. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling), and the vehicle was taken to the dealer for the recall repair; however, the dealer informed the contact that the manufacturer denied authorization to perform the recall inspection. The dealer informed the contact that the failure appeared to be associated with the recall and replaced the engine oil with a higher viscosity oil. The contact was provided a work order confirming that the recall repair was not completed. The manufacturer was notified of the failure and referred the contact to another dealer. The vehicle was taken to Mac Haik Chevrolet (11711 Katy Fwy, Houston, TX 77079); however, the stalling failure could not be duplicated, but there were abnormal engine sounds confirmed. The second dealer requested authorization to disassemble the engine, but the manufacturer denied the request. The contact stated that the manufacturer failed to honor the recall repair, denied a buyback request, and offered monetary compensation, which the contact declined. The vehicle was not repaired and was traded in. The failure mileage was approximately 5,000.

NHTSA ID

11759340

Incident

Sep 25, 2024

Mileage

5,000 mi

Engine shut down. Last thing I saw on my screen was engine oil hot engine shutting down and engine shut down and had no electrical power.

NHTSA ID

11758912

Incident

Apr 3, 2026

2024 Silverado ZR2 with the 6.2L engine was involved in the GM safety recall N252494003 for L87 Engine Loss of Propulsion. Vehicle taken to local dealership where inspection was performed. Passed inspection on 11/11/2025 resulting in the dealership changing to higher viscosity oil per safety recall instructions. 27,000 miles on vehicle at time of recall inspection. On 2/24/2026 was using the on ramp to get up to speed on the interstate. Got vehicle up to 70 mph and suddenly without any warning had loss of propulsion and vehicle began to decelerate quickly in front of a tractor trailer. Fortunately the semi driver was able to swerve around me as I pulled the vehicle off to the side of the road. Vehicle towed to the dealership where I purchased the truck and diagnosed with engine failure. Multiple bearings went out sending metal fragments throughout the engine. Vehicle had 28,500 miles at time of failure. Dealership had truck for roughly a month to perform complete engine replacement. Truck currently has 32,000 miles on it and seems to be running okay. We have lost some trust in the GM brand after this whole issue. Another uneasy problem is that my wife’s 2025 GM SUV has the same 6.2L engine in it. We bought my wife’s vehicle in May of last year and are unable to move out of it due to being in negative equity at the moment with that vehicle.

NHTSA ID

11758798

Incident

Feb 24, 2026

6.2L engine stopped working on the highway.

NHTSA ID

11758616

Incident

Jul 25, 2026

Had the Motor replaced under recall / warranty at a certified chevy dealer. ~41k miles. 6.2L L87. GRAFF chevy of Chesterton Indiana. After long lead times and getting the run around, the truck was "done". picked it up and many things were still wrong/incorrect. They were able to take care of it. A day later, the truck died in the road. towed to another GRAFF dealer. 2 days later it was found to be a bad ground. fixed. Fast forward ~3k miles later. the transmission went out and locked up on a main roadway. Towed to another dealer (West Herr chevy Orchard Park NY). They found the root cause was due to transmission cooler lines coming loose from faulty installation during motor swap. There were also many other items found that were broken or loose under the hood of the vehicle from faulty workmanship. I am being told it is not covered under warranty because of the previous dealer's workmanship (GRAFF Indiana) I was able to get the truck put of the roadway and to a safe place, but this very well could've caused an accident, and I would like to document it.

NHTSA ID

11757909

Incident

Aug 8, 2026

Vehicle suddenly stalls and reduces speed at different times with no warning. At first it would show that message after car washes or rainy days but now randomly it’ll reduce speed in unexpected moments causing safety concerns. It reduces speed, stalls, drives forcefully, and shows a “reduced acceleration drive with care”. Sudden stalls have become a danger to my family and myself as we depend on this car to get to and from on a daily basis. Dealership states it’s the TCM but not covered under warranty. But the vehicle is new how is it that it already has defects

NHTSA ID

11757318

Incident

May 1, 2026

The contact owns a 2024 Chevrolet Silverado 1500. The contact stated that while driving 45 MPH uphill with a boat hitched on a trailer, while depressing the accelerator pedal, the engine overheated and the vehicle was pulled over and the idol warning message was displayed. The contact pulled over to the right side of the road, however the vehicle lost power with the boat trailer wheel still on the highway. A dealer was contacted. The vehicle was towed to the dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was 21,000.

NHTSA ID

11756821

Incident

Aug 9, 2026

Mileage

21,000 mi

The contact owns a 2024 Chevrolet Silverado 1500. The contact stated that while driving 70 MPH, the RPM became elevated; however, the vehicle decelerated abnormally, causing the vehicle to lose power. The contact pulled over on the side of the road, turned off and restarted the vehicle, but the vehicle failed to operate as intended. The vehicle was towed to the dealer. The vehicle was serviced under NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING) by the owner, but the remedy failed to fix the vehicle. The manufacturer was not notified of the failure. The failure mileage was 28,500.

NHTSA ID

11753977

Incident

Nov 21, 2025

Mileage

28,500 mi

The contact owns a 2024 Chevrolet Silverado 1500. The contact stated that while driving approximately 45 MPH, the transmission upshifted as intended; however, the vehicle then suddenly downshifted to a lower gear. No warning light was illuminated. In addition, the contact stated that the failure worsened and jolted the occupants inside the vehicle. The vehicle was taken to a local dealer where it was diagnosed; however, no cause for the failure was found. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,278.

NHTSA ID

11753466

Incident

Jul 24, 2026

Mileage

47,278 mi

The contact owns a 2024 Chevrolet Silverado 1500. The contact stated that while driving at 75 MPH, the engine shut off without warning. The contact safely coasted to the shoulder of the road and requested assistance from 911 to secure the vehicle from oncoming traffic. The vehicle was then towed to a dealer, where a diagnostic assessment confirmed a total engine failure, requiring replacement. The contact had previously taken the vehicle to a dealer for NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the inspection yielded no visible issues, and the recall was marked as completed. The vehicle remained at the dealer and had yet to be repaired. The manufacturer had not been notified of the failure. The failure mileage was approximately 25,500.

NHTSA ID

11748744

Incident

Jul 2, 2026

Mileage

25,500 mi

Engine seized middle of road had to coast off into a safe spot to park

NHTSA ID

11746039

Incident

Jun 2, 2026