2024 Chevrolet Silverado 2500 Brakes Problems

The contact owns a 2024 Chevrolet Silverado 2500. The contact stated that after turning off the vehicle with a trailer hitched to the vehicle, the trailer brake lights failed to turn off. The contact disconnected the trailer from the vehicle for the trailer brake lights to turn off. Additionally, the electric trailer brakes and turn signals intermittently failed to function properly. The vehicle was taken to the dealer; however, the dealer could not determine where the wiring harness 120-Volt power was going and was unable to repair the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000.

NHTSA ID

11753265

Incident

Jul 1, 2025

Mileage

45,000 mi

The contact owns a 2024 Chevrolet Silverado 2500. The contact stated that the trailer brake control module failed to operate as needed while hauling a trailer, causing the trailer to lose braking capability. The vehicle was taken to a local dealer where it was diagnosed, and the contact was advised that the trailer control module was faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 63,500.

NHTSA ID

11673344

Incident

Apr 23, 2025

Mileage

63,500 mi

Truck keeps losing trailer brakes, intermittent as i am towing a 10,000 lb camper. Very unsafe

NHTSA ID

11668850

Incident

Jun 22, 2025

While pulling my Vilano fifth wheel trailer to Alabama from my home state of Texas the driver information center alerted me that the trailer brakes were disconnected. Then a short while later it alerted that trailer brakes were connected. This situation continued for the entire trip to Alabama. When the info center indicated trailer brakes were disconnected, they were indeed not working. Several times I almost rear ended cars stopping in front of me. (The vehicle had a recall notice urging to take it in and replace the brake module shortly after purchasing it. I did this.) Once I arrived in Alabama I took the vehicle to the Chevrolet dealership in Foley, Alabama to check the braking system. They told me there was no problem with the braking system. I retrurned to my home in Little Elm, Texas with the problem occurring the entire trip. I finally made it home and today took the vehicle to James Wood Chevrolet in Denton, Texas to have the braking systme checked again. They told me there was nothing wrong with the braking system. The service writer did say that because the trailer has LED lights the braking system does not recognize the voltage from the trailer and that is why the brakes are disconnecting. Please help me find out how to correct this extremely dangerous condition while I am towing my 16,000 pound fifth wheel trailer.

NHTSA ID

11664955

Incident

May 7, 2025

Brake pad failure, at 22,000 miles brake pads are almost worn out and leave extreme amounts of brake dust on wheels. This issue has been happening since 500 miles. Was told by dealer that it's a cheaper pad that the manufacture uses and the wear is normal. Steering wheel shakes when brakes are applied and when you're pulling a load the vehicle starts vibrating and jumping. Now rotors are warped due to the faulty pads wearing out so soon. Dealer and GM refuses to fix it, dealer says it's not covered and not a safety issue and GM has no explanation for their rejection the claim.

NHTSA ID

11658361

Incident

Mar 17, 2025

When hooked to 5th wheel trailer the brakes work good for a day then info center says check trailer brakes. The trailer bakes are not operational at that time. A few minutes later trailer brakes are back working again.The truck keeps shutting off the trailer brakes and sometimes they do not come back on at all. It happens every time I hook up to 5th wheel trailer. I have had it back to dealership 6 times and they can’t fix it.

NHTSA ID

11655615

Incident

Apr 15, 2025

While towing our 25ft travel trailer, I began getting warning from the trailer brake controller which repeatedly disconnected and, thankfully reconnected them after a brief interval. Luckily, the times when I had no trailer brakes did not require rapid stops. That said, towing a 7000 # trailer thru the mountains in a driving rain storm with no brakes randomly caused a bit of concern. After researching this I find this is a known defect and has TSB’s and voluntary recalls in place. (TSB 23-NA-149 and N232414840 respectively) However I was never notified by GM as my VIN was not included in the above. We could have been seriously injured or worse. This tsb is almost 2 years old. Why were we not informed/included? Our issue is identical to the tsb.

NHTSA ID

11653987

Incident

Apr 6, 2025

Intermittent loss of trailer brakes. Trailer has small break away battery

NHTSA ID

11650669

Incident

Mar 26, 2025

Intermittent lose of trailer brakes.

NHTSA ID

11649850

Incident

Mar 22, 2025

Intermittent lose of trailer brakes. Dealerships are unable to duplicate issue, will not replace under factory warranty. Chevy has not issued a recall for this specific vin. But other 2024 Chevy 2500 have had recalls for it. Would like a recall for my vin die to this being an issue if an accident occurs. Traveling with multiple 10K pound trailers and no brakes.

NHTSA ID

11649836

Incident

Mar 21, 2025

My trailer brake controller routinely does not allow me to adjust the brake gain. Multiple times (and on recorded video), I’ve had instances where I could not increase gain while hauling heavy loads in the trailer and this has caused me to lose my ability to stop the vehicle effectively. This has nearly cause accidents a few times while hauling on the interstate, and down my mountain road. The driver must be able to adjust trailer gain at any point while operating the vehicle. This issue has happened with multiple trailers. I’ve taken the vehicle in multiple times and had the brake controller components replaced but this issue still exists and the dealerships are unable to resolve. I was informed I have trailer issues even though this only occurs in this vehicle while towing and not other vehicles pulling the trailers. This is a major safety issue and will cause an accident if it isn’t resolved. My only option at this point is to purchase an aftermarket brake controller as my factory brake controller is unsafe. I have multiple videos of this issue and nearly had the trailer push me over my mountain from the issue. This issue has happened since I purchased the vehicle and continues to happen. There are multiple service records which show I requested the brake controller to be fixed. This isn’t a one time date or speed. I’m unable to upload videos I’ve taken on my phone but I can send them in. Reach out to [XXX] for videos. The manufacturer and service centers aren’t helping resolve this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11649674

Incident

Mar 21, 2025

Intermittent lose of trailer brakes. Dealer failed to diagnose and fix issues. Stayed if they can not replicate it, they will not warranty it.

NHTSA ID

11649623

Incident

Mar 20, 2025

intermittent lose of trailer brakes.

NHTSA ID

11649557

Incident

Mar 18, 2025

Trailer brake control module in vehicle will have intermittent loss of trailer brakes. Dealership stated they will not fix the issue if they are unable to replicate it. Even with video or picture evidence. Dealership has been uncooperative during the process.

NHTSA ID

11648991

Incident

Mar 17, 2025

Vehicle’s braking system for the trailer constantly disconnects while driving. The trailer will then lose all braking capabilities. Multiple service trailer brake system, check trailer wiring harness, trailer brake connected messages. Issues started shortly after purchasing the truck new at only 55 miles on the odometer

NHTSA ID

11648624

Incident

Mar 16, 2025

Drove to a residence to make a delivery. Turned truck back on and went to back out of driveway and the truck started shaking very violently and could not turn truck right or left. Chevrolet technician is stating the power steering pump fell apart sending metal through engine.

NHTSA ID

11639394

Incident

Jan 28, 2025

I was towing a dump trailer with gravel in it down a gravel road grade (downhill around 5-7mph) and received a warning on the DTC about the trailer brake being disconnected. All of the lights on the trailer were still working, however the trailer brakes no longer functioned and all of the braking was transferred to the truck. The trailer slowly pushed the rear end of the truck around causing the vehicle to jackknife and causing significant damage to the bumper and bed. After researching this post incident, there appears to be numerous complaints and TSB from chevy regarding a faulty brake controller when towing a trailer where the voltage can backfeed into the vehicle causing the vehicle brake controller to disable. Currently working with insurance to come up with a damage quote. Bulletin # 23-NA-149

NHTSA ID

11622718

Incident

Oct 25, 2024

While driving with a trailer connected the display in the truck will say trailer disconnected. Then the light will go away and come back on. The trailer plug and the trailer are connected and the plug is tight. When this happens the trailer braking system is disabled (trailer has no brakes) I can plug the same trailer to Ford or Dodge with no issues. Have had the Chevy to the dealer 4 times now and they are unable to duplicate the problem. I have researched the problem on the internet and there are a lot of discussions of other people having the same issue. GMC has replaced the trailer control module, but this did not fix my problem. I am at the point the dealer and GMC are giving me the run around. I bought this truck for commercial use and frequently haul trailers. It is very unsafe when the brakes on the trailer are disabled.

NHTSA ID

11616812

Incident

Sep 13, 2024

I would like to report a hazardous issue with the 2024 Chevrolet Silverado trailer braking power mode. The trailer braking system turns on and off when the loaded trailer is connected; this represents a security hazard since this truck is used for work and we move heavy pieces of metal and glass. This issue was reported several times to the dealership Lou Bachrodt Chevrolet in Coconut Creek, FL. Also, the manufacturer provided a letter indicating the replacement of some parts. As indicated, I took the truck to Lou Bachrodt Chevrolet in Coconut Creek, FL, on [XXX] for the corresponding service; however, the truck is still presenting the same issues. We tried different trailers, including a U-Haul trailer, and still had the same dysfunctionality. Please advise how to proceed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11616715

Incident

Aug 23, 2023

The contact owns a 2024 Chevrolet Silverado 2500 used for hauling a 2024 Grand Design RV. The contact stated that on several occasions while towing the trailer, the messages that the "Trailer Brakes Disconnected "and "Trailer Brakes Reconnected" were displayed but disappeared every 5 minutes. The vehicle was taken to the dealer; however, the failure could not be replicated. The manufacturer was notified of the failure. The failure mileage was approximately 2,000.

NHTSA ID

11616599

Incident

Sep 6, 2024

Mileage

2,000 mi

The contact owns a 2024 Chevrolet Silverado 2500. The contact stated while driving 65 MPH hauling a trailer, the brake control disabled message was displayed. There were no warning lights illuminated. The contact decelerated. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 7,000.

NHTSA ID

11611162

Incident

Jun 28, 2024

Mileage

7,000 mi

See attached document for complaint.

NHTSA ID

11609897

Incident

Jul 7, 2024

When pulling trailer trailer brakes keep disconnecting

NHTSA ID

11609651

Incident

Aug 16, 2024

When pulling trailers I frequently get warning to check trailer wiring. I have gotten this warning with every trailer I have towed to include, my travel trailer(camper), livestock trailer, car hauler trailer and enclosed cargo trailer. It is intermittent but frequent. I am unsure if trailer brakes will engage during this failure.

NHTSA ID

11599325

Incident

Jun 1, 2024

The contact owns a 2024 Chevrolet Silverado 2500. The contact stated while driving at an undisclosed speed and towing a trailer, the trailer brake lights became inoperable. The service trailer brake system warning light was illuminated. The vehicle was taken to the dealer several times; however, the failure could not be duplicated. The vehicle was not repaired. The contact stated that the trailer was replaced with another trailer; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 26,000.

NHTSA ID

11598376

Incident

Dec 11, 2023

Mileage

26,000 mi