2024 Chevrolet Silverado 2500 Fuel system Problems

Due to the Fuel Pump Power Control Module (Part number 13554821) failure, my vehicle stalled in the middle of a turn while pulling a 10,000 pound RV. This caused me to lose both power steering and braking capabilities. From what I gather, this part is part of a "phased" initiative recall (see N252516900 Fuel Pump Power Control Module). This part was seemingly installed in all or most of GM SUVs and Trucks since 2021. Unfortunately, only some 2021-2023 models are under recall due to the "phased" nature of this recall. Meanwhile, all Heavy Duty trucks are driving around on our roadways, highways, and interstates, just like I was, towing heavy machinery, equipment, and RVs because both you and GM are dragging your feet on demanding these flawed modules be removed from these vehicles. In summation, virtually every GM SUV and truck on the road produced since 2021 is a ticking time bomb that could stall at any moment and disable both power steering and braking capability. If thats not bad enough, concerned owners, such as myself, are stonewalled with the words "there is no active recall on your vehicle " both by GM and your very website. The "phased" nature of this recall is unacceptable and is putting lives at risk. Had I been traveling at highway speeds when this failure occurred, while towing a heavy load, with braking traffic in front of me or a sharp turn, I would not have been able to stop or turn. This is an urgent matter and should be addressed accordingly, not in a "phased" manner.

NHTSA ID

11752781

Incident

Jul 17, 2026

My 2024 Chevrolet 2500HD Duramax experienced a forced emissions derate event with a speed-limited countdown. The vehicle suddenly lost normal operating capability and became unsafe and undrivable. The truck was disabled in Enid, Oklahoma and had to be recovered and transported to a dealership. Prior to failure, the vehicle showed abnormal DEF/emissions behavior. The failure involves the SCR/DEF emissions system. I later confirmed this vehicle has a completed Product Emissions Recall for SCR Fault Detection. Despite that recall, the emissions system failed and triggered a derate and loss-of-mobility event. The truck is currently at Classic Chevrolet in Owasso, OK for diagnosis.

NHTSA ID

11710700

Incident

Jan 6, 2026

2024 Chevrolet 2500 HD purchased new. Delivered with missing capless fuel adapter. Pointed out missing capless adapter defect to Chevrolet dealer. Dealer refused to correct defect. When the vehicle ran out of fuel on busy roadway a large quanity of fuel splashed on the owner, the vehicle and the road creating the potential risk of serious fire, injury and environmental hazard. Owner had to purchase the capless adapter from the dealer service department when #1 it should have been included with vehicle purchase #2 Dealer should have corrected this serious safety issue when customer brought it to their attention.

NHTSA ID

11709190

Incident

Apr 4, 2023

The fuel pump inside the tank shorted out and left us stranded. This is the same pump that was used on the the 2022 Duramax systems however they upped the fuel pressure on the 2024 refresh and it has become a known problem of shorting out.

NHTSA ID

11682545

Incident

Jul 26, 2025

With 19,000 miles on my Silverado 2500 HD I was traveling down a hill towards a stop sign at a T intersection. About 100 yeads from the stop sign I had many flashing errors on the dash, very little brake and very little steering. The engine just shot off. Fortunately I was able to stop the vehicle right at the stop sign while traffic from right and left had no stop sign. The truck would not start after. It did have electrical power. I tow was needed. The next day the Chevy dealer did find a bulletin for a wire in the engine compartment chaffed. Symptoms were the same as what I experienced. Repair was made. Bulletin #24-NA-124. There is no doubt a bulletin should be issued but I believe this is a real safety issue with the engine just randomly shutting off leaving no power to brakes and steering. Had this happened while I was towing our camper I would not have stopped and t boned another vehicle causing damage and no doubt injury to others and myself. If traveling on an interstate at 70 MPH this could have been even worst. This is a known problem and should be a recall and not just a bulletin. Thanks.

NHTSA ID

11666785

Incident

Jun 12, 2025

Complete engine and emission fail while driving. Complete loss of power. Created a serious safety issue while driving due to other traffic and inability to move vehicle from road side to safe area. Problem was confirmed by mechanic. Contact to GMC resulted in no response. Mechanic has reported numerous other GMC trucks with the same issue. Check engine light came on shortly before and then went off again. Contact was made with dealer as well as GMC directly regarding the issue.

NHTSA ID

11645960

Incident

Jul 17, 2024

Truck sends safety lights on dash one day and the next day they go off. Truck is running rough and has subpar fuel mileage driving 55 to 65 miles per hour. Esc light comes on and steering wheel changes sides to drive straight. Information screen goes black and flashes while driving. I have been in contact with gmc and they said I have to report to you before they will do anything. There was a recall for my type of Truck for poor fuel consumption but my vin was not included. I feel my truck has fell through the cracks and is in need of serious repairs. 72k for this truck and now I am having nothing but problem I feel used... please help! Thanks , [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11570573

Incident

Nov 15, 2023

After 3 days of using the truck I parking the vehicle with a trailer and I stop the truck and turn off to check the back and when I try to start the engine don’t work and all the lights turn on low battery,no key,service service esc, traction control, and I stuck with the whole cabin outside of the drive way , pedestrians must use the street to instead of the sidewalk, take it to the dealer and they say it is the computer must be replace it .

NHTSA ID

11568911

Incident

Jan 29, 2024

The contact owns a 2024 Chevrolet Silverado 2500. The contact stated that while starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer, where the battery was disconnected temporarily to reset the ECM. The check engine warning light was reset; however, the failure reoccurred while driving. Additionally, the contact stated that the vehicle was experiencing abnormal fuel consumption. The contact stated that the fuel economy was 8.2 - 9 miles per gallon while driving and hauling a trailer. The contact related the failure to an unknown GM voluntary recall for Faulty Fuel Injector Flow Rate. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 400.

NHTSA ID

11557393

Incident

May 15, 2023

Mileage

400 mi