Owner-reported complaints naming the powertrain system, filed with NHTSA
Data refreshed
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials. Every record below is an owner-reported complaint about the 2004 Chevrolet Silverado submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 19 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
STEEL BRAKE, FUEL AND TRANSMISSION LINES ARE EXTREMELY RUSTY AND FAILURE APPEARS TO BE IMMINENT, ESPECIALLY ON BRAKE LINES. THIS SHOULD BE A SAFETY RECALL. *TR
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE REDUCED ENGINE POWER WARNING MESSAGE ILLUMINATED AS THE VEHICLE DECELERATED TO 15 MPH. THE CONTACT DEPRESSED THE ACCELERATOR PEDAL ALL THE WAY TO THE FLOORBOARD BUT THE VEHICLE WOULD NOT ACCELERATE. THE FAILURE RECURRED INTERMITTENTLY THROUGH OUT THE YEARS AND THE DEALER REPLACED THE ELECTRICAL HARNESS, THE THROTTLE GROUNDING WIRE, THROTTLE BODY AND THE FUEL CAP, BUT TO NO AVAIL. THE DEALER COULD NOT DIAGNOSE THE PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. THE CONTACT STATED THAT TRANSMISSION FLUID WAS LEAKING FROM THE HYDRO BOOST WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN STATED THAT THE HYDRO BOOST WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 120,000.
I WAS DRIVING HOME FROM ERRAND RUNNING AND FOUND THE BRAKE PEDAL GOING ALMOST TO THE FLOOR. FOUND A PUDDLE OF BRAKE FLUID UNDER THE TRUCK NEAR THE BACK OF THE CAB AND BED OF TRUCK. CALLED MY SERVICE PERSON AND HE SAID IT WAS PROBABLY A RUPTURED BRAKE LINE, AND FROM THE DESCRIPTION OF WHERE THE PUDDLE WAS IT WAS PROBABLY ABOVE THE GAS TANK WHERE THE LINE IS SECURED TO THE FRAME. HE ALSO STATED THAT HE HAS REPAIRED MULTIPLE CHEVY TRUCKS WITH THE SAME PROBLEM. I HAVE SEEN THE UNDERSIDE OF MY TRUCK AND ALL THE LINES ARE RUSTED, INCLUDING FUEL AND TRANSMISSION COOLING LINES. *TR
APPLIED BRAKES AT A STOP SIGN AND THE BRAKE PEDAL WENT TO THE FLOOR. TOTAL LOSS OF STOPPING ABILITY. AFTER USING THE PARKING BRAKE TO STOP. LOOKED UNDER THE TRUCK TO SEE BRAKE FLUID DRIPPING FROM THE FRAME OF THE TRUCK. ALL BRAKE LINES AND THE TRANSMISSION COOLER LINES CORRODED AND 2 BURST. ALL NEED TO BE REPLACED. CLEARLY THE SILVERADO HAS AN ISSUE WITH THIS AND THE ENTIRE UNDERCARRIAGE RUSTING BEYOND COMPARABLE YEAR & MILEAGE TRUCKS. I HAVE NEVER HAD A VEHICLE UNDER CARRIAGE IN THIS CONDITION REGARDLESS OF AGE AND THIS TRUCK HASN'T ACHIEVED 10 YEARS OFF THE LOT YET. *TR
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. THE CONTACT STATED THAT AFTER PARKING AND EXITING THE VEHICLE, SHE HEARD AN ABNORMAL CLICKING NOISE AS THE VEHICLE STARTED TO ROLL AWAY IN REVERSE. WHILE ATTEMPTING TO STOP THE VEHICLE, THE DRIVER'S DOOR OPENED AND SLAMMED HER TO THE GROUND, TRAVELING OVER BOTH OF HER LEGS. THE VEHICLE THEN CRASHED INTO A FENCE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED DAMAGE TO THE NERVES AND ARTERIES OF HER LEGS. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 154,000.
MY VEHICLE IS A 2004 CHEVROLET SILVERADO K2500 EXT LWB 4WD WITH APPROXIMATELY 21,000 MILES. I HAVE USED THE FOUR WHEEL DRIVE FEATURE OFF AND ON AS NEEDED TO NEGOTIATE SLICK ROAD CONDITIONS WITHOUT ANY PROBLEMS PRIOR TO THIS INCIDENT, WHICH OCCURRED ON 12/23/08: WHILE DRIVING IN FOUR WHEEL DRIVE, HIGH RANGE, AT APPROXIMATELY 20 MPH ON AN ICE COVERED ROAD THE FRONT WHEELS LOCKED UP WITHOUT WARNING, CAUSING ME TO LOSE CONTROL AND SKID OFF THE ROAD. HAD I BEEN GOING FASTER, OR IF I HAD BEEN IN A TRAFFIC SITUATION, THERE COULD HAVE BEEN A SERIOUS ACCIDENT, POSSIBLY RESULTING IN INJURIES OR DEATH. THIS FRONT WHEEL LOCK UP CONDITION IS STILL PRESENT AS LONG AS THE FOUR WHEEL DRIVE SELECTOR IS IN EITHER HIGH OR LOW RANGE. IN TWO WHEEL DRIVE THE PROBLEM IS NOT EVIDENT. I HAVE MADE AN APPOINTMENT WITH THE SELLING DEALER TO DIAGNOSE THE PROBLEM, BUT AS YET I DO NOT KNOW THE ROOT CAUSE OF THIS MALFUNCTION. ALTHOUGH THIS INCIDENT WAS A NEAR MISS, I AM REPORTING IT BECAUSE OF THE SERIOUS NATURE AND THE HOPE THAT A SAFETY RECALL MAY BE ISSUED SO THAT OTHER ACCIDENTS MAY BE AVOIDED. *TR
LEFT FRONT HUB ASSEMBLY TOTAL FAILURE. APPARENTLY HUB STAYED LOCKED IN FOUR WHEEL DRIVE AND DESTROYED HUB. THE FAILURE WAS NOTED WHEN EXTREME VIBRATION AND LACK OF STEERING RESPONSE OCCURRED. FAILURE WAS AT 49,750 MILES. HUB ASSEMBLIES SHOULD LAST LIFE OF VEHICLE. REPAIRED AT MY OWN COST AFTER CHEVROLET REFUSED TO REPAIR. *JB
2004 CHEVY SILVERADO XCAB 4X4 1500 SHUTTER IN REAR CAB AREA?REPLACED DRIVE SHAFT/NOW INSTRUMENT CLUSTER BROKE/CHANGED OUT SHOCKS/CHANGED FACTORY TIRES/WILL NOT BRAKE MANUFACTURES GMVW+TOW PACKAGE/HAVE SUED CHEVROLET FOR $6000/I'LL DO IT AGAIN!DRIVERS SIDE STEERING /SHOCK/TIRE POUNDING IN 50000 MILES HIGHWAY WHAT NEXT IN 2 YEARS. *JB
DT*: THE CONTACT STATED WHILE MAKING A LEFT OR RIGHT HAND TURN THE STEERING WHEEL BECAME DIFFICULT TO TURN. THIS OCCURRED ON NORMAL ROADS DURING NORMAL STEERING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. UPON INSPECTION, THE DEALERSHIP REPLACED THE STEERING SHAFT HOWEVER, THE PROBLEM STILL EXISTS. THE MANUFACTURER WAS ALERTED. UPDATED 3/9/2006 - LEFT FRONT AXLE FRONT SEALS LEAKED. THE CONSUMER HEARD NOISE IN THE REAR END. THE POWER STEERING PUMP FLOW CONTROL WAS REPLACED. THE BODY CONTROL MODULE WAS REPLACED. THE FRONT DIFFERENTIAL SHAFT SEAL WERE REPLACED. THE TIRES WERE CHOPPED DUE TO ALIGNMENT BEING OUT OF ADJUSTMENT. DRIVER'S DOOR HAD TO BE REALIGNED. MASTER CYLINDER WAS REPLACED. *NM
DT*: THE CONTACT STATED WHILE IN MOTION THE TRANSMISSION SLIPPED AND JERKED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE LOCAL DEALERSHIP FOR INSPECTION. THE DEALER GREASED THE DRIVESHAFT WITH HI-TEMPERATURE GREASE ON THE SPLEEN. AT 2000 MILES LATER, WHILE DRIVING AT 70 MPH, THE DRIVESHAFT SHEARED, BROKE AWAY FROM THE TRANSMISSION AND REAR END. THE CONTACT LOST CONTROL OF THE VEHICLE. HOWEVER THE VEHICLE WAS ABLE TO BE PULLED ONTO THE EMERGENCY LANE. THE VEHICLE WAS TOWED TO THE LOCAL DEALERSHIP WHERE THE DEALER REPLACED THE DRIVESHAFT AND TRANSMISSION. *AK
EARLY 2004 SILVERADO 3500 DIESEL. THE EXTENSION HOUSING BETWEEN THE TRANSMISSION AND THE TRANSFER CASE CRACKED DUE TO VIBRATION FROM THE DRIVE SHAFT U-JOINT FAILURE. TECHNICAL BULLETINS FROM CHEV ADDRESS THIS AS A COMMON PROBLEM. THEY HAVE REDESIGNED THE PARTS BUT WILL NOT STAND BEHIND THEIR PRODUCT TO REPAIR ANY EXISTING PROBLEMS. *NM
DT: THE CONTACT'S HUSBAND HEARD A NOISE IN THE VEHICLE. SHE THOUGHT IT WAS THE BRAKES BECAUSE IT SOUNDED LIKE METAL TO METAL. WHEN THE VEHICLE WAS CHECKED AT THE DEALERSHIP ONE COULD PULL THE TIRE OUT BECAUSE THE PIN THAT HELD THE AXLE HAD DROPPED DOWN INTO THE DIFFERENTIAL UNIT. THIS COULD HAVE CAUSED A SERIOUS ACCIDENT. THE CONTACT PURCHASED AN EXTENDED WARRANTY. THE DRIVER SIDE WAS REPLACED UNDER WARRANTY BUT THE EXTENDED WARRANTY COMPANY WOULD NOT AGREE TO REPLACE THE PASSENGER SIDE EVEN UNDER THE WARRANTY. *AK
2004 CHEVY SILVERADO 2500 DIESEL, FOUR MONTHS OLD(4000MILES) REAR AXILE WENT OUT. SAID DEFAULT FROM THE MANUFACTOR. TOOK FOURTEEN DAYS TO GET NEW ONE.CHEVROLET BUILT NEW FROM ST.LOUIS AND SHIPPED IT TO BE PUT ON. THEY GAVE ME A LITTLE CAR TO DRIVE. 27000 MILES AND NOW REAR AXILE LEAKING. TOOK TO DEALER. THEY SAID NOTHING BUT NORMAL LEAKAGE COMING OUT. ( WHATS NORMAL LEAKAGE ON A AXILE? THEY ARE NOT SUPOSED TO LEAK ON THE BRAKES.) LOOKED LIKE IT WAS ON FIRE SMOKING SO BAD AND COULD SMELL AXILE GREASE. SEEN SOME ON TIRES. BUT THIS IS NORMAL LEAKAGE.WAS TOLD TO DRIVE IT TILL IT BRAKES DOWN.ALSO EVERTHING IN THE DASH STOPS WORKING THEN IT WILL JUST COME BACK ON.
MY 4 WHEEL DRIVE PICKUP HAS SHIFTED FROM 2 WHEEL DRIVE TO LOW 4 WHEEL DRIVE WITHOUT COMMAND. IT IS NOW IN THE SHOP FOR THE THIRD TIME FOR THE SAME PROBLEM. THIS COULD BE DEADLY AT HIGH SPEEDS. I AM AWAIR OF ONE TRUCK OF THE SAME MAKE AND MODEL THAT CRASHED INTO A DITCH WHEN THIS HAPPENED.
ACCELERATING AFTER START UP THE FRONT AXLE LOCKED UP IN 4 WHEEL DRIVE. THE FRONT AXLE WAS REPAIRED. *AK VEHICLE OPERATED IN 2 WHEEL DRIVE. *AK
I HAVE A CLUNK NOISE IN THE TRANSMISSION. I HAVE TAKEN MY VECHICLE TO THE DEALER MANY TIMES THEY SAID THERE IS NO FIX FOR THIS PROBLEM. THEY HANDED ME A DOCUMENT ID# 1430424 AND WILL NOT FIX THEY TRUCK.*AK
CLUNKING NOISE SOUNDING LIKE A U-JOINT IN BOTH REVERSE AND DRIVE FROM FIRST TO SECOND GEARS. HAPPENS AT ANY SPEEDS. TWO REPAIR CENTER/CHEVROLET DEALERS STATED THIS IS A COMMON NOISE AND FEELING. THERE WAS A BULLETIN FROM CHEVROLET ABOUT IT AND THERE IS NOT REPAIR. TOLD THAT YOU HAVE TO LIVE WITH THE NOISE. *NM
FRONT AXLE ASSEMBLY FAILED CAUSING THE VEHICLE TO VERE LEFT INTO A TELEPHONE POLE IN MY DRIVEWAY. I WAS TRAVELING ACCORDING TO THE COMPUTER 20 MPH.*AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .