2003 Chevrolet Tracker

IN OCTOBER 2007, GM INITIATED A SPECIAL COVERAGE PROGRAM FOR ALL MY 1999 THROUGH 2004 CHEVROLET TRACKER VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT-BELT STATES.THE PROGRAM EXTENDS THE WARRANTY COVERAGE FOR FRONT SUSPENSION CROSSMEMBER CORROSION TO 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM IS ADMINISTERING THE PROGRAM IN PHASES DUE TO PART AVAILABILITY.THE FIRST PHASE STARTED IN OCTOBER 2007 AND COVERS THE MY 1999 AND 2000 VEHICLES.OWNERS OF MY 2001 THROUGH 2004 VEHICLES WILL RECEIVE LETTERS AT A FUTURE DATE, BUT ARE ELIGIBLE TO RECEIVE FREE REPAIRS FROM THE PROGRAM IF THE CROSSMEMBER REQUIRES REPLACEMENT.GM'S PROGRAM PROVIDES FREE INSPECTIONS FOR CONSUMERS EVERY 12 MONTHS THROUGH THE TERMS OF THE POLICY ADJUSTMENT.COPIES OF THE DEALER BULLETIN AND OWNER LETTER FOR GM'S SPECIAL COVERAGE PROGRAM ARE ATTACHED TO THE CLOSING REPORT FOR THIS INVESTIGATION. THE RATE OF CONFIRMED LCA SEPARATIONS AT 5 YEARS IN SERVICE IS LESS THAN 10 PER 100,000 VEHICLES, WHICH IS LOW RELATIVE TO OTHER INVESTIGATIONS OF FRONT SUSPENSION ISSUES PREVIOUSLY INVESTIGATED BY ODI. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.

CORROSION AND RUST PROOFING CAUSING THE SUBFRAME AND CONTROL ARMS TO CORRODE AND DETACH

NHTSA ID

11434068

Incident

Sep 1, 2021

FUSES AND BRAKERS KEEP POPPING/BLOWING ABOUT ONCE A MONTH. WHEN POPPED THE VEHICLE LOSES THE ABILITY FOR THE BRAKES TO ILLUMINATE BRIGHTER WHEN YOU PUT YOUR FOOT ON THE BRAKE, AS WELL AS THE ABILITY TO USE THE HORN. RECENTLY I HAD A DIFFERENT FUSE POP THAT CUT ALL ELECTRICAL FUNCTIONS INSIDE OF THE VEHICLE AS WELL AS AFFECTING SOME ON THE OUTSIDE. THE FOLLOWING FAILED. THE BREAK LIGHTS WERE NOT VISIBLE WHEN TURNED ON OR WHEN YOU PUT YOUR FOOT ON THE BREAK, EMERGENCY FLASHERS DID NOT WORK, ALL DASHBOARD LIGHTING FAILED, DOOR LOCKS DID NOT WORK, WHEN YOU OPEN THE DOOR THE LIGHT WOULD NOT TURN ON INSIDE OF THE CAR, WHEN THE CAR WAS PARKED I HAD TO MANUALLY ENGAGE THE SHIFTER BY GOING UNDERNEATH OF THE SHIFTER AND RELEASING THE LOCK WHILE MY FOOT WAS ON THE BREAK AND THEN MOVE THE SHIFTER TO NEUTRAL AT THE SAME TIME TO GET THE VEHICLE INTO DRIVE. THESE HAVE BEEN RECURRING ISSUES WITH REGULAR SHOP MATNEINCE THE VEHICLE HAS ONLY 135000 MILES ON IT CURRENTLY. IT HAS PLENTY OF LIFE IN IT AND THERE IS NO REASON FOR THESE CONTINUED ISSUES. HELP!!!

NHTSA ID

11270495

Incident

Jul 22, 2018

Mileage

11,300 mi

MY AIRBAG LIGHT HAS BEEN ON FOR ALMOST 2 YEARS. THERE ARE NO CODES, AND THE MECHANICS CAN'T FIGURE OUT HOW TO FIX THIS.

NHTSA ID

11270277

Incident

Oct 1, 2017

Mileage

200,000 mi

FRONT SUSPENSION CROSS MEMBER RUSTED THROUGH

NHTSA ID

11098307

Incident

May 22, 2018

FEONT SUSPENSION CROSSMEMBER BROKE ON RIGHT SIDE.

NHTSA ID

11084384

Incident

Mar 1, 2018

Mileage

135,000 mi

VEHICLE HAS A KNOWN AND SERIOUS SAFETY MANUFACTURING DEFECT PREVIOUSLY COVERED UNDER A "SPECIAL COVERAGE - #06186" FOR CORROSION AND RUST PROOFING CAUSING THE SUBFRAME AND CONTROL ARMS CORRODE AND DETACH. GM REFUSES TO HONOR PREVIOUSLY EXPIRED SPECIAL COVERAGE AND CONSIDERS THIS AN "OUT OF POCKET" EXPENSE.

NHTSA ID

10960362

Incident

Mar 13, 2017

Mileage

50,000 mi

TL* THE CONTACT OWNS A 2003 CHEVROLET TRACKER. WHILE DRIVING APPROXIMATELY 55 MPH AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE VEERED TO THE LEFT AND THE FRONT DRIVER SIDE WHEEL BEGAN TO SHAKE. WHILE INSPECTING UNDER THE VEHICLE, THE CONTACT DISCOVERED THAT THE A-ARM SUSPENSION FRACTURED DUE TO RUST AND CORROSION. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 162,000.

NHTSA ID

10944990

Incident

Jan 12, 2017

Mileage

162,000 mi

I HAD A SEVER CAR ACCIDENT AND THE AIR BAG NEVER OPEN AND PROBLEM WITH THE SUSPENSION AND STEERING WHEEL AND THE BRAKES GOT LOCK AFTER WE WERE HIT ON THE REAR OF THE TRACKER. AND LAST CONTROL

NHTSA ID

10892693

Incident

Apr 8, 2012

Mileage

50 mi

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.