2002 Chevrolet Venture Fuel system Problems

The contact owns a 2002 Chevrolet Venture. The contact stated that while the vehicle was parked, a fuel odor was detected inside the cabin of the vehicle. Additionally, the vehicle was consuming an excessive amount of fuel. The contact's neighbor, an independent mechanic, diagnosed that there was fuel leaking between the connection of the fuel line and fuel tank. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

NHTSA ID

11439369

Incident

Oct 28, 2021

Mileage

80,000 mi

SUDDENLY MY VEHICLE HAD A STRONG GASOLINE ODOR WHEN I WALKED UP ON IT IN THE MORNING I SMELLED IT 3 FEET AWAY FROM MY VEHICLE. IT HAPPENED JUST LIKE THAT ALL OF A SUDDEN. I SCHEDULED MY INSPECTION WITH MY MECHANIC AND I TOLD HIM I SUDDENLY WAS SMELLING A STRONG ODOR OF GAS. MY MECHANIC CALLED AND INFORMED ME THERE WAS A CRACK IN MY GAS TANK AND IT IS LEAKING SO THAT IS WHY I WAS SMELLING GAS SO BADLY. WE ORDERED ANOTHER 2002 CHEVROLET VENTURE GAS TANK FROM A SALVAGE YARD. THEY SHIPPED THE GAS TANK AND WHEN MY MECHANIC OPENED IT IT WAS BROKE IN THE SAME EXACT PLACE. THIS IS WHY I THOUGHT LOOKING UP FOR POSSIBLE RECALL. I FOUND RECALL 07V349000. STATED THE FUEL TANK INLET CHECK VALVE CAN CRACK AND LEAK. STATED AFFECTED CHEVROLET VENTURE 2001, 2002, 2003, 2004. I HAVE 2002. MY PROBLEM IS IT'S VIN SPECIFIC ACCORDING TO CHEVROLET THE NUMBER THAT I WAS GIVEN TO CALL ABOUT THE RECALL. 18006302438. MY VIN NUMBER WAS NOT INCLUDED. MY PROBLEM FITS THE DESCRIPTION PERFECTLY BUT THEY CLAIM THEY CAN'T HELP ME. THIS IS A SERIOUS SAFETY PROBLEM FOR ANYONE. I NOW HAVE TO PAY OVER 1,000.00 FOR A NEW GAS TANK OR HAVE NO CAR. I DO NOT HAVE ANY TRANSPORTATION NOW. MY CHEVROLET VENTURE IS SITTING AT MY MECHANICS.

NHTSA ID

11123646

Incident

Aug 23, 2018

Mileage

133,000 mi

FUEL FILLER NECK CRACKED WHERE IT IS ATTACHED TO THE GAS TANK. FUEL LEAKING OUT OF NECK.

NHTSA ID

11022916

Incident

Sep 8, 2017

Mileage

140,000 mi

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE THE VEHICLE WAS PARKED, THERE WAS STRONG FUEL ODOR EMITTED IN AND AROUND THE VEHICLE. EACH TIME THE VEHICLE WAS PARKED, A PUDDLE OF FUEL WAS SEEN ON THE GROUND. THE CONTACT'S BROTHER, A CERTIFIED MECHANIC, DIAGNOSED THE VEHICLE AND STATED THAT THE TANK WAS CRACKED AT THE INLET CHECK VALVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WAS NO OPEN RECALL PER THE VIN. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

NHTSA ID

10980552

Incident

Dec 17, 2014

Mileage

140,000 mi

FUEL LEVEL GAUGE DOES NOT WORK EVER SINCE I HAD THIS VAN AND FUEL PUMP UNEXPECTEDLY WENT BAD AT ABOUT 83000 MILES

NHTSA ID

10891897

Incident

Jun 21, 2012

Mileage

83,000 mi

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT NOTICED AN ABNORMALLY STRONG FUEL ODOR COMING FROM THE VEHICLE. THE CONTACT OBSERVED FUEL PUDDLES UNDER THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 51,000.

NHTSA ID

10873233

Incident

May 9, 2016

Mileage

51,000 mi

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT ALL THE FUEL FILLER NECKS WERE FRACTURED, WHICH CAUSED FUEL TO LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 160,000.

NHTSA ID

10787669

Incident

Jun 3, 2013

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT THERE WAS A FUEL LEAK COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE INLET CHECK VALVE AND THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE: STORAGE). THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

NHTSA ID

10748161

Incident

Jan 1, 2015

Mileage

140,000 mi

TEMP GAUGE TRYS GO HOT HAD CHECK NOTHING ENGENE MISFIRE HAD CHECK 7 TIMES NOW. REPLACE MASS AIR TEMP SENSORE TWICE THROTTLE POSITION SENSORS. PLUGS AND WIRES TWICE IN ONE MONTH HAS WIRE SHORTAGE FOR AC AND WE HAVE PAID OUT ALOT OF MONEY FROM DAY 2 OF OWNING THIS WAS GOING SELL BUT I WOULD SELL THIS CRAP TO NO ONE.. NOW SAYS O2 SENSORE LEFT WHEEL SENSOR AND MUCH MORE CODES JUNK LIKE THIS DONT NEED TO BE SOLD..

NHTSA ID

10745619

Incident

Jul 1, 2014

Mileage

159,000 mi

ICV (IN LINE CHECK VALVE) HOUSING ON FUEL TANK HAS STARTED CRACKING AND LEAKING FUEL. CHEVROLET SAYS THIS UNIT IS NOT AFFECTED BY RECALL 07V349000. IT APPEARS TO BE THE SAME AS MY OTHER VENTURE WE HAD THE RECALL PERFORMED ON LEAKING AT SAME SPOT. THIS IS A FIRE HAZARD AND GM SHOULD REPAIR THIS ON ALL VENTURE VANS. I HAVE RUN ACROSS HUNDREDS OF PEOPLE IN DISCUSSION WITH SAME ISSUE AND NOT WITHIN GM'S VIN BREAKS. I THINK GM NEEDS TO LOOK AT THIS AGAIN. I HAVE PICTURES TO PROVE WHAT IS GOING ON. *TR

NHTSA ID

10643504

Incident

Sep 25, 2014

Mileage

216,000 mi

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. UPON REFUELING THE VEHICLE, FUEL STARTED LEAKING FROM THE FUEL TANK. THE CONTACT MENTIONED THAT THE FAILURE PROGRESSIVELY WORSENED. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED A SMALL FRACTURE WHICH MAY HAVE ALLOWED FUEL VAPORS AND SMALL DROPLETS OF FUEL TO PASS THROUGH. THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 214,000.

NHTSA ID

10640418

Incident

Sep 1, 2014

Mileage

214,000 mi

I BOUGHT THIS CAR USED AND DISCOVERED THAT I COULDN'T FILL THE GAS TANK MORE THAN 1/3 OF THE WAY OR IT WOULD LEAK FROM A CRACK IN THE PLASTIC GAS TANK WHERE THE FILLER PIPE CONNECTS TO THE TANK. I LOOKED IT UP ON THE INTERNET AND DISCOVERED IT WAS A COMMON PROBLEM; HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2003/CHEVROLET/VENTURE/FUEL+TANK I TALKED TO MY LOCAL CHEVROLET DEALER AND HE SAID THAT THERE WAS A RECALL, BUT MY VIN NUMBER WAS NOT INCLUDED. NOW WHAT? *TR

NHTSA ID

10598658

Incident

Jan 1, 2014

I PURCHASED A USED 2002 CHEVY VENTURE WITH ONLY 84,000 AND THE FIRST THING I DID WAS FILL IT WITH GAS FOR THE NEXT DAY OF SCHOOL DROP OFFS AND PICK UPS . I GOT HOME PARKED IT AND THE NEXT DAY A SMALL PUDDLE OF GAS WAS UNDER DRIVERS SIDE SLIDING DOOR. I LOOKED ON LINE AND FOUND A RECALL SO I CALLED THE CHEVY DEALER AND THEY SAID MY VIN # WAS NOT ONE THAT WAS COVERED. SO NOW WE HAVE OUR NEW VAN SITTING IN OUR DRIVE WAY WITH NO MONEY TO FIX IT TILL NEXT WEEK. I THINK GM REALLY NEEDS TO STEP UP AND FIX THEIR PROBLEM... I FOND SEVERAL PEOPLE IN THE SAME BOAT. AND STILL AFTER THEY BOUGHT A NEW TANK A WEEK OR TWO LATER THE SAME THING OCCURRED.. SO NOW WHAT... WHO IS KEEPING THE AUTOMOTIVE COMPANIES ACCOUNTABLE.. DOES SOME SMALL CHILD HAVE TO BE INJURED OR GOD FORBID LOOSE THEIR LIFE... SOME ONE NEEDS TO DO SOMETHING.... *TR

NHTSA ID

10556731

Incident

Dec 19, 2013

Mileage

84,000 mi

I NOTICED FUEL MILEAGE BEING REALLY OFF AND A VERY STRONG GASOLINE SMELL AND HAD IT CHECKED @ OUR LOCAL REPAIR SHOP AND WAS TOLD GAS TANK WELD HAD FAILED; WE WERE ALSO TOLD WE WERE VERY LUCKY THAT WE GOT IT IN AS SOON AS WE DID. VERY DANGEROUS! WAS ALSO TOLD BY MECHANIC THAT THERE HAD BEEN RECALLS ON THIS VERY THING AND ALSO EVEN MORE SERVICE BULLETINS. I CONTACTED GM AND WAS TOLD YES THERE HAD BEEN RECALLS BUT NOT OUR VIN NUMBER GROUP! NOW IT'S TIME TO DO THIS BEFORE SOMEONE DIES OR IS MAIMED. THEY TOLD ME THEY WERE VERY SORRY BUT GLAD NO ONE WAS HURT! I WAS ALSO TOLD TO SAVE ALL MY PAPER WORK JUST IN CASE @ WHICH TIME I TOLD THEM I SAVE EVERYTHING! THEY WERE MORE CONCERNED ABOUT WHY I HAD TAKEN IT TO OUR REPAIR SHOP RATHER THAN ONE OF THEIR DEALERS; I TOLD THEM THAT THE ONLY THING I EVER GOT FROM THEIR DEALERS WERE THAT THEY COULD NOT EVER REPLICATE THE PROBLEM; THEN OUR REPAIRMAN WOULD FIX WHAT THEY COULDN'T EVEN IDENTIFY. *TR

NHTSA ID

10465889

Incident

Jun 20, 2012

Mileage

111,000 mi

THE GAS GAUGE STOPPED WORKING, WENT FROM FULL TO EMPTY IN ABOUT 3 SECONDS. CHEVY REFUSED TO HELP. I HAVE CARRIED A NOTEBOOK IN THE VEHICLE SINCE THAT TIME, WRITING DOWN THE DATE, PLACE OF PURCHASE, MILEAGE, TOTAL COST, COST PER GALLON, AND HOW MANY GALLONS. THIS IS TO MAKE SURE I DON'T RUN DRY, SINCE THE IDIOT GOING GOES OFF WHENEVER IT PLEASES. (CAR WAS PURCHASED NEW, FROM PARAMUS CHEVROLET IN OCTOBER, 2001). *TR

NHTSA ID

10461997

Incident

Jul 10, 2004

Mileage

57,500 mi

THE FUEL GAUGE EITHER SHOWS FULL OR EMPTY. IT WILL SHOW FULL WHILE DRIVING, BUT WHEN SITTING STILL, EVEN IF YOU JUST FILLED UP THE LOW FUEL LIGHT WILL COME ON AND THE GAUGE WILL DROP TO EMPTY. OTHER THAN SETTING THE TRIP, YOU HAVE NO WAY OF KNOWING HOW MUCH GAS IS IN THE TANK. WHEN YOU GET TO HALF A TANK OR SO, THE LIGHT WILL COME ON CONSTANTLY AND DING. HAVE TRIED MANY THINGS TO FIX THIS PROBLEM BUT NOTHING SEEMS TO WORK. I HAVE HEARD THIS ON A LOT OF THIS SAME TYPE VEHICLE. *JS

NHTSA ID

10458497

Incident

Feb 22, 2011

Mileage

88,000 mi

CHEVY VENTURE 2002 W/83732 MILES. TO WHOM IT MAY CONCERN: ON APRIL 28, 2002 I TOOK VAN TO HAVE IT TEST IT FOR THE EMISSIONS. IT FAILED WITH P0446 CODE, EVAP VENT PERFORMANCE. ON MAY 2, 2002, I TOOK THE VAN TO MY LOCAL DEALERSHIP TO HAVE IT DIAGNOSED FOR SERVICE ENGINE LIGHT AND ABS LIGHT ON. THEY ADVISED ME THAT IN ORDER FOR THEM TO FURTHER DIAGNOSED THIS ISSUE, THAT THEY WOULD NEED TO REMOVE THE FUEL TANK FOR A TOTAL OF $776.51 COST. SERVICE ADVISOR REQUESTED AN IMMEDIATE PAYMENT OF $345.00 FOR THEM TO FURTHER DIAGNOSE THE ISSUE WHICH I DECLINED. I THEN CALLED GM TO INQUIRED ABOUT ANY SERVICE BULLETINS AND/OR RECALLS ON MY MINIVAN, GM FOUND NONE AND THEY DECLINED TO ASSIST WITH THIS REPAIR. BASED ON MY RESEARCH, IT SEEMS THAT A LOT OF CHEVY VENTURE OWNERS ARE EXPERIENCING THE SAME ISSUE WITH THE EMISSIONS SYSTEM. I DO FEEL THAT THERE IS A DEFECTIVE PART WITHIN THE EMMISIONS SYSTEM AND MORE SPECIFICALLY THE VENT VALVE AND OR THE FUEL TANK PRESSURE SENSOR IN THE FUEL TANK. I WILL NOT BE BUYING ANOTHER GM PRODUCT. I WOULD BE VERY HAPPY TO SEE A RECALL ON THIS ISSUE. CUSTOMER SHOULDN'T HAVE TO BE PUT IN A FINANCIAL POSITION WHERE THE FUEL TANK ON THE VEHICLE NEEDS REMOVAL IN ORDER TO HAVE A FUEL EMISSIONS SYSTEM DIAGNOSED. THANK YOU VERY MUCH FOR YOUR ATTENTION TO THIS MATTER. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS

NHTSA ID

10457176

Incident

May 2, 2012

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT SMELLED GASOLINE FUEL FROM THE VEHICLE WHILE PARKED. WHEN HE ATTEMPTED TO REFUEL THE VEHICLE, IT WOULD TAKE THIRTY MINUTES TO ADD TWO GALLONS TO THE TANK. IN ADDITION, THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE DEALER INFORMED THE CONTACT THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 07V349000 ( FUEL SYSTEM, GASOLINE:STORAGE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. NO REPAIRS WERE PERFORMED. THE CURRENT AND THE FAILURE MILEAGES WERE UNKNOWN.

NHTSA ID

10437487

Incident

Oct 17, 2011

FUEL GAUGE READS ERRATICALLY. *TR

NHTSA ID

10435384

Incident

Nov 13, 2011

Mileage

139,000 mi

I WAS DRIVING AND NOTICE THE VAN SLOWING DOWN ON ME AND THEN IT STOPPED SUDDENLY. I TOOK IT TO A MECHANIC AND WAS TOLD IT NEEDED GAS. TWO WEEKS AFTER I NOTICE THE ODOMETER WOULD JUMP FROM EMPTY TO FULL BACK AND FORTH. THEN I NOTICE WHENEVER I TRY TO FILL IT UP WITH GAS IT WOULD NOT TAKE MORE THAN $5.00 WORTH. *TR

NHTSA ID

10386072

Incident

Feb 20, 2011

Mileage

218,000 mi

HAVE FUEL LEAKING FROM STORAGE TANK, TECHNICIAN SAYS IT IS COMING FROM AROUND THE INLET, AND THAT THERE IS A RELATED SAFETY CAMPAIGN ON MY VEHICLE (NHTSA CAMPAIGN ID NUMBER: 07V349000). THE DEALERSHIP TELLS ME THAT MY VEHICLES IS NOT ONE THAT IS INVOLVED IN THE CAMPAIGN (2002 CHEVROLET VENTURE [XXX]). IT WOULD SEEM THAT GM MISREPORT THE SCOPE OF THE PROBLEM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10361246

Incident

Oct 16, 2010

Mileage

189,000 mi

TL*THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT WHEN EVER HE ADDED FUEL TO ITS CAPACITY AND PARKED THE VEHICLE IN HIS GARAGE, HE SMELLED FUEL. HE ALSO STATED THAT HE DOESN'T SMELL FUEL WHILE THE VEHICLE IS BEING DRIVEN. THE FAILURE ONLY OCCURRED WHEN THE FUEL TANK WAS FULL. THE DEALER STATED THAT THERE WAS A RECALL FOR THE FUEL SYSTEM; HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS REPAIRED AT THE OWNERS EXPENSE. THE FAILURE RECURRED WHICH ALSO REVEALED A CRACK ON THE INLET VALVE. NHTSA CAMPAIGN ID 07V349000, FUEL SYSTEM, GASOLINE: STORAGE IS RELATED TO THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 131,000.

NHTSA ID

10282912

Incident

Aug 25, 2009

Mileage

131,000 mi

AIR CONDITIONER CONDENSER FAILED, GM NEW OF THE PROBLEM IN DECEMBER, 2002, BUT KEPT THEIR MOUTH SHUT UNTIL THE WARRANTY EXPIRED. THE GAS GAUGE DOES NOT WORK, IT FLIPS FROM FULL TO EMPTY, I HAVE TO KEEP A MILEAGE NOTEBOOK IN ORDER TO KNOW WHEN TO FILL UP. MY WARNING LIGHT ON THE DASH CONTINUES TO FLASH "REAR HATCH AJAR, SIDE DOOR AJAR, LOW BRAKE FLUID." THERE IS NOTHING WRONG WITH ANY OF THE ITEMS. THE FRONT BRAKES WENT BAD AT 32,000, REQUIRING NEW PADS AND ROTORS. THE WINDOW BUTTON ON THE DRIVER SIDE WILL PUT THE PASSENGER WINDOW DOWN, BUT NOT UP. THE REAR WINDOW WASHER DOES NOT WORK. I AM SO GLAD THAT GM IS GOING BANKRUPT. I BOUGHT AN AMERICAN CAR, TO TRY AND HELP THE WORKERS STAY EMPLOYED, BUT NOW REALIZE THAT ALL I DID WAS TO KEEP SOME OVERPAID, LAZY SLOBS ON THE JOB FOR MUCH LONGER THAN THEY SHOULD HAVE BEEN EMPLOYED. THE DEALER HAS BEEN A COMPLETE LOSS, WITH GM CUSTOMER SERVICE HAVING THE ATTITUDE THAT, "SINCE THE WARRANTY HAS EXPIRED, YOU CAN STICK IT, BECAUSE WE DON'T CARE. *TR

NHTSA ID

10268960

Incident

Jul 28, 2004

Mileage

32,000 mi

IN JULY 06' I BOUGHT AND INSTALLED A WIX BRAND #33183, PLASTIC BODY, GASOLINE LINE FILTER ON MY 02' CHEVY VENTURE. IN THE SPRING OF 08' I FOUND THAT IT WAS LEAKING GASOLINE ON THE FLOOR OF MY GARAGE. I BELIEVE A LEAK HAD DEVELOPED IN THE PLASTIC BODY. I CONTACTED WIX IN APRIL 08' AND TURNED OVER THE FILTER FOR EVALUATION. I HAVE YET TO RECEIVE A REPORT BACK AFTER NUMEROUS INQUIRIES. *TR

NHTSA ID

10247481

Incident

Apr 1, 2008

FRONT BRAKES FAILED PREMATURELY--ROTORS WERE DESTROYED AT 34,000 MILES. AIR CONDITIONER CONDENSER FAILED, GM KNEW OF PROBLEM IN DEC. OF 2002 BUT KEPT QUIET UNTIL WARRANTY RAN OUT. NEEDED TO REPLACE CONDENSER AND DRYER WITH NEW PARTS, GM WOULD NOT HELP. FUEL GAUGE DOESN'T WORK, HAVE TO KEEP PAPER ECORD OF FUEL CONSUMPTION. REAR WINDOW WASHER HAS FAILED, DOES NOT SPRAY. *TR

NHTSA ID

10239574

Incident

Jul 16, 2007

Mileage

43,000 mi