1997 Dodge Ram

ON APRIL 17, 1997, THE CHRYSLER CORPORATION FILED A DEFECT INFORMATION REPORT CONCERNING APPROXIMATELY 800,000 1994 THROUGH 1997 DODGE RAM PICKUPS EQUIPPED WITH V6 OR V8 ENGINES AND AUTOMATIC TRANSMISSIONS, 1995 THROUGH 1997DODGE RAM PICKUPS EQUIPPED WITH THE V10 ENGINE AND AUTOMATIC TRANSMISSION, AND THE 1995 AND 1996 DODGE RAM VAN/WAGON EQUIPPED WITH AUTOMATIC TRANSMISSION.ODI HAS RECEIVED ELEVEN REPORTS CONCERNING TRANSMISSION LEAKAGES FROM THE QUICK CONNECTOR JOINTS RESULTING IN EIGHT FIRES.THE REPORTED VEHICLES INCLUDED ARE THE 1994 AND 1995 JEEP WRANGLER, 1995 AND 1996 CHEROKEE, 1993 THROUGH 1996 GRAND CHEROKEE, AND 1994 AND 1995 DODGE DAKOTA.THE PURPOSE OF THIS INVESTIGATION IS TO EXAMINE THE SCOPE OF RECALL 97V-084.CLOSING SUMMARY: FURTHER INVESTIGATION OF CONSUMER REPORTS REVEALED THAT SOME OF THE TRANSMISSION LEAKAGE WAS DUE TO OTHER CONNECTIONS ALONG THE COOLING LINES.IN THE FIRE INCIDENTS, THERE WERE INDICATIONS THAT SOME OF THESE VEHICLES WERE EITHER USED BEYOND THE VEHICLE'S TOWING CAPABILITY OR HAD IMPROPER TRANSMISSION REPAIR.IN ADDITION, THE RECALLED RAM PICKUP TRUCKS, 98V-084, HAVE AN EXHAUST MANIFOLD NEAR THE PLASTIC QUICK CONNECTOR JOINTS WHICH EFFECTIVELY PRESENTS A HEAT SOURCE TO IGNITE THE HOT TRANSMISSION FLUID IN THE EVENT OF A LEAKAGE.THE SUBJECT VEHICLES' QUICK CONNECTOR JOINTS ARE EITHER TOO FAR, OR POSITIONED COMPLETELY AWAY, FROM A HEAT SOURCE OR EXHAUST COMPONENTS.CONSEQUENTLY, THE FIRE REPORTS OF THE SUBJECT VEHICLES ARE SIGNIFICANTLY LESS THAN THOSE OF THE DODGE RAM PICKUP TRUCKS.BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.

ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.

ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%

ALLEGED PLASTIC CLUTCH TUBE MAY FAIL FROM EXPOSURE TO EXHAUST HEAT, RESULTING IN LOSS OF CLUTCH FUNCTION AND POSSIBLE VEHICLE FIRE.

CRACKED DASH.

NHTSA ID

10424812

Incident

Sep 1, 2011

TL* THE CONTACT OWNS A 1997 DODGE RAM. THE CONTACT STATED THAT THE FUEL TANK FRACTURED AND DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER AND THE CONTACT WAS INFORMED THAT THE FAILURE WAS CAUSED BY NORMAL WEAR AND TEAR. THE DEALER STATED THAT THE CONTACT SHOULD HAVE PAID MORE ATTENTION TO THE STRAPS BECAUSE THEY ARE DESIGNED TO EVENTUALLY WEAR OUT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 109,000.

NHTSA ID

10400036

Incident

May 6, 2011

Mileage

109,000 mi

PARK POSITION WITH IGNITION KEY IN THE LOCK POSITION, VEHICLE SHIFTER MOVED OUT OF PARK , KNOCKED OWNER DOWN AND RAN OVER ME, CONTINUED TO ROLL BACK HIT SECOND CAR, CONTINUED TO KEEP GOING UNTIL IT HIT A CURB. THIS WAS A VERY DANGEROUS AND COULD HAVE CAUSED OTHER ACCIDENTS. CONSUMER SENT IN A FAX COPY OF THE INTERNET VOQ. *KB *JB

NHTSA ID

10234636

Incident

May 14, 2004

Mileage

144,678 mi

TL*THE CONTACT OWNS A 1997 DODGE RAM. AFTER STOPPING THE VEHICLE, THE ENGINE AND OIL LIGHTS ILLUMINATED. THE DEALER DIAGNOSED THE FAILURE ON THREE OCCASIONS AND STATED THAT THE COMPRESSOR SENSORS WERE LOW AND ADVISED THE CONTACT TO ADD TWO QUARTS OF OIL PER WEEK. HOWEVER, THE OIL LIGHT CONTINUED TO ILLUMINATE INTERMITTENTLY. THE CONTACT DID NOT CONFIRM IF THE VEHICLE HAD ANTILOCK BRAKES. THE VIN WAS CONFIRMED, BUT APPEARS TO BE INVALID. THE FAILURE MILEAGE WAS 133,200 AND CURRENT MILEAGE WAS 134,400.

NHTSA ID

10220647

Incident

Mar 7, 2008

Mileage

133,200 mi

1997 DODGE RAM LEFT FRONT TIRE HAD TREAD SEPARATION. *KB THE SEPARATION CAUSED DAMAGED TO THE VEHICLE. OHIO TRAFFIC CRASH REPORT. *JB

NHTSA ID

10201495

Incident

Jul 4, 2007

97 DODGE RAM CUSTOMER STATES THAT THE DASH HAS MANY CRACKS AND THE FRONT SPEAKERS ARE NOT WORKING AND WITH SEVERAL UNEXPLAINED ELECTRICAL ISSUES**CC *TR

NHTSA ID

10193171

Incident

Jan 1, 1901

THE 1997 DOGE RAM DASHBOARD STARTED CRACKING, AND NOW THERE WAS A LARGE HOLE IN THE CENTER OF THE DASHBOARD. *AK

NHTSA ID

10191167

Incident

May 18, 2007

TL*THE CONTACT OWNS A 1997 DODGE RAM. THE CONTACT STATED THAT THE VEHICLE'S DASHBOARD HAS BEGUN TO CRACK. THE CRACK TRAVELS FROM THE WINDSHIELD DOWN TO THE FRONT OF THE DASHBOARD. THE DASHBOARD HAS CONTINUED TO CRACK INTO TINY PIECES. THE ENGINE SIZE AND NUMBER OF CYLINDERS ARE NOT AVAILABLE. THE CURRENT MILEAGE IS 169,000 AND FAILURE MILEAGE WAS 100,000. THE DEALER CONTACT INFORMATION IS ALSO UNAVAILABLE.

NHTSA ID

10190339

Incident

Apr 1, 2006

Mileage

100,000 mi

ILLUMINATED MIL AS THE RESULT OF A DIAGNOSTIC TROUBLE CODE (DTC) P0420 - CATALYST EFFICIENCY, OR MAY HAVE FAILED A CALIFORNIA SMOG OR STATE I/M TEST BUT WITHOUT AN ILLUMINATED MIL, OR A RATTLING SOUND FROM THE UNDERSIDE OF THE VEHICLE. CATALYTIC CONVERTER EXTENDED WARRANTY TO REPLACE THE CATALYTIC CONVERTER. *TT

FLASH PROGRAMMING FAILURE RECOVERY. *SLC

SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT

CUSTOMER MAY COMPLAIN OF HIGH OIL CONSUMPTION, GREY OIL SMOKE COMING OUT OF THE EXHAUST OR BREATHER TUBE, OR MECHANICAL KNOCKING. *TT

AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ

SOME CUSTOMERS MAY EXPERIENCE A SITUATION IN WHICH THE REAR OF THE VEHICLE SITS TOO HIGH TO ATTACH THEIR FIFTH WHEEL OR GOOSE NECK TRAILER TO THE TRAILER HITCH TURNABLE. *JB