1989 Ford Aerostar Problems

MY FORD AEROSTAR CAUGHT FIRE LAST NIGHT FOR NO APPARENT REASON. MY DAUGHTER HAD RETURNED FROM SCHOOL AND PARKED IT IN THE DRIVEWAY. APPROXIMATELY 2 HOURS LATER, A NEIGHBOR RANG THE DOOR BELL AND FRANTICALLY SAID "YOUR VAN IS ON FIRE". WE CALLED 911 AND THE FIRE DEPARTMENT WAS THERE WITHIN 3 MINUTES TO PUT IT OUT. *JB

DT: THE CONTACT RECEIVED NHTSA RECALL 96V071000 CONCERNING THE IGNITION SWITCH. WHEN HE CONTACTED FORD, THEY COULD NOT FIND THE VIN. THIS STARTED A COUPLE OF MONTHS AGO. THE SWITCH STARTED TO COME APART, CAUSING THE VEHICLE NOT TO START. HE REPAIRED IT HIMSELF, AND IT IS CURRENTLY WORKING.*AK UPDATED 12/27/2005. *NM

NHTSA RECALL 98V190000 CONCERNING FUEL SYSTEM STORAGE TANK ASSEMBLY: CONSUMER INTERMITTENTLY SMELLED A STRONG ODOR OF GASOLINE ON THE OUTSIDE OF THE VEHICLE. T CONSUMER EXAMINED THE GAS TANK AND FOUND THAT FUEL WAS LEAKING FROM THE TOP OF THE TANK WHEN IT WAS FULL. MANUFACTURER CLAIMED THAT THIS VEHICLE WAS NOT A PART OF THE RECALL.*AK

THE MANUFACTURER WAS REFUSING TO HONOR RECALL 98V190000 FOR FUEL TANK CRACKS BECAUSE THE WARRANTY PERIOD ENDED. *AK

I WOULD LIKE MY 5 YEAR OLD SON TO BE SAFE IN THE BACK OF MY VAN. THE ONLY PROBLEM IS I ONLY HAVE LAP BELTS IN THE BACK. I NEED SHOULDER HARNESS BELTS FOR HIM TO BE SAFE IN HIS BOOSTER SEAT. I CONTACTED A FORD DEALERSHIP ABOUT HAVING IT INSTALLED. THEY WANTED AN OUTRAGEOUS AMOUNT OF MONEY TO PUT ONE IN. CAN ANYBODY HELP ME WHITH THIS?*AK

WHILE DRIVING ON THE ROAD DRIVER'S SEAT BELT ALL OF SUDDEN UNHOOKED. THE DRIVER'S SEAT BELT WILL NOT LATCH BACK. *AK

91V189000/TRANSMISSION AUTOMATIC: PARKED VEHICLE IN DRIVWAY, AFTER 15 -20 MINUTES LOCAL POLICE ARRIVED TO INFORM CONSUMER THAT VEHICLE HIT A PARKED VEHICLE, AND THAT GEAR WAS NOTICED IN DRIVE POSITION. NOTIFIED MANUFACTURER, AND INFORMED THAT VEHICLE WAS NOT COVERED UNDER THAT RECALL DUE TO VIN. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS. *AK

RECALL 91V189000; WHILE VEHICLE WAS PARKED IT JUST ROLLED FRONT DOWN THE HILL, AND HIT A BRIDGE. *AK

WE OWE A 1989 FORD AEROSTAR MINI-VAN THE LONG EDITION. WE HAVE HAD IT A LITTLE OVER YEAR. WE HAVE BEEN HAVING A SERIOUS PROBLEM WITH THIS VECHICLE STALLING WHEN DRIVING ON THE HIGHWAY TO AND FROM WORK. IT HAPPENS A LOT MORE OFTEN WHEN IT IS COLD AS OPPOSED TO WHEN IT IS WARMER. *JB

WHEN TRAVELING A LONG WAY VEHICLE GETS OVERHEATED AND VEHICLE WILL SHUT OFF WITH PRIOR NOTICED. THE DEALERSHIP WILL BE NOTIFIED. *AK

BRAKE LINE NEXT TO GAS TANK FAILED ON HIGHWAY, BRAKING ABILITY WAS GREATLY REDUCED. *JB

THE CONSUMER STATED THAT BACK IN 1998 SHE HAD A ACCIDENT WITH HER FORD AEROSTAR. SHE STATED THAT WHEN SHE PULLED INTO A PARKING SPACE AND HIT THE BRAKES, THE VEHICLE SURGED FORWARD AND HIT A BUILDING. SHE SAID SHE HAD THE VEHICLE TOWED TO THE DEALER WHO STATED THAT THEY THOUGHT THE PROBLEM WAS A FAULTY IDLE AIR CONTROL. SHE SAID IT WAS REPAIRED AND SHE TOOK THE PART AND SENT IT TO THE MANUFACTURER. NOW THE PROBLEM HAS COME UP AGAIN AND SHE WAS ASKED TO BE A WITNESS, BECAUSE SOMEONE WAS KILLED, WHEN THEIR VEHICLE DID THE SAME THING. *JB IT WAS DETERMINED THAT THE THROTTLE AIR BY PASS VALVE ASSEMBLY WAS NOT ONE OF FORD'S PARTS.

THE SECOND ROW RIGHT SIDE CAPTAIN CHAIR ROCKS AND SHAKES IN ITS MOUNT. MANUFACTURING DATE IS APRIL 1989. *AK

VEHICLE CAUGHT ON FIRE FROM ELECTRICAL SHORT UNDER THE DASHBOARD, AND WHOLE VEHICLE BURNED. FIRE DEPARTEMENT HAD TO COME OUT AND PUT OUT THE FIRE. *AK

THE CONSUMER STATED THAT BACK IN 1998 SHE HAD A ACCIDENT WITH HER FORD AEROSTAR. SHE STATED THAT WHEN SHE PULLED INTO A PARKING SPACE AND HIT THE BRAKES, THE VEHICLE SURGED FORWARD AND HIT A BUILDING. SHE SAID SHE HAD THE VEHICLE TOWED TO THE DEALER WHO STATED THAT THEY THOUGHT THE PROBLEM WAS A FAULTY IDLE AIR CONTROL. SHE SAID IT WAS REPAIRED AND SHE TOOK THE PART AND SENT IT TO THE MANUFACTURER. NOW THE PROBLEM HAS COME UP AGAIN AND SHE WAS ASKED TO BE A WITNESS, BECAUSE SOMEONE WAS KILLED, WHEN THEIR VEHICLE DID THE SAME THING. *JB IT WAS DETERMINED THAT THE THROTTLE AIR BY PASS VALVE ASSEMBLY WAS NOT ONE OF FORD'S PARTS.

CONSUMER STATES ENGINE WAS ON AND IN THE PARK POSITION, CONSUMER PRESSED BRAKE TO PUT VEHICLE INTO REVERSE AND VEHICLE TOOK OFF IN REVERSE. CONSUMER STATES VEHICLE HIT TWO PARKED CARS AND WAS TOTALLED. PLEASE PROVIDE ANY FURTHER INFORMATION.*JB

ANOTHER VEHICLE HIT THE CONSUMER'S VEHICLE ON THE DRIVER'S SIDE AT ABOUT 30 MPH CAUSING THE VEHICLE TO ROLL ONTO IT'S RIGHT SIDE AND SLIDE ABOUT A FOOT OR TWO. NLM

STRUCTURE PROBLEMS

THE AIR CONDITIONER IS MALFUNCTIONING. DEALER HAS INSTALLED FREON AND STILL NO SOLUTION. *AK

WHEN DRIVING VEHICLE WAS OVERHEATING.CONSUMER HAD HEATER CORE/RADIATOR AND WATER PUMP REPLACED.CONSUMER HAD TO HAVE VEHICLE SERVICED FOUR TIMES . *AK

THE ALTERNATOR FAILED SHORT CIRCUIT. MASSIVE AMOUNTS OF CURRENT PASSED FROM THE BATTERY THROUGH THE ALTERNATOR, WHICH BURST INTO FLAMES. THE FAULT CAUSED THE ENGINE TO STALL DUE TO LACK OF IGNITION AND IT WAS EXTREMELY DIFFICULT TO STEER AND STOP THE VEHICLE AS A RESULT OF LOSS OF POWER STEERING AND POWER BRAKES. SMOKE WAS POURING FROM THE FRONT OF THE VEHICLE. WHEN I MANAGED TO STOP AND OPEN THE HOOD, THE ALTERNATOR, WHICH WAS GLOWING RED INSIDE, BURST INTO FLAMES AND SET FIRE TO CABLES AND RUBBER HOSES AROUND IT. I RECEIVED BURNS TO MY HANDS TRYING TO PUT THE FIRE OUT. LUCKY FOR ME ANOTHER MOTORIST STOPPED AND HE HAD AN EXTINGUISHER. I HAVE NOW HAD TWO FIRES OF THIS TYPE, ONE ON EACH OF MY VEHICLES. YESTERDAY I WENT TO AN ALTERNATOR REMANUFACTURING COMPANY HERE IN MONTERREY, AND THE MANGER TOLD ME THAT HE HAS HAD FIVE ENGINE BAY FIRES IN AEROSTAR MINIVANS IN RECENT MONTHS. IN THE 'GOOD OLD DAYS' UNDERSTAND THERE WAS A FUSIBLE LINK BETWEEN THE ALTERNATOR CHARGING LINE AND THE BATTERY + TERMINAL. THERE SHOULD BE A FUSE IN THIS CIRCUIT BECAUSE IT IS CONNECTED DIRECTLY TO THE BATTERY!! NOT ONLY IS THE FIRE A VERY SERIOUS PROBLEM, BUT THERE IS A SERIOUS RISK IN THE EVENT OF THIS FAULT, THAT THE OVERLOAD ON THE BATTERY WILL CAUSE IT TO BURST, SHOWERING EVERYTHING AND EVERYONE AROUND IT WITH HOT SULFURIC ACID. PLEASE NOTE ALTHOUGH THE VEHICLE WAS PURCHASED IN THE USA I AM CURRENTLY LIVING IN MONTERREY, MEXICO. MY PHONE IS 01152-8-349-7152 AND EMAIL IS [email protected]. *AK

CONSUMER REPORTING AN ONGOING PROBLEM WITH ENGINE ACCELERATION INTERMITTENTLY APPROXIMATELY SIX MONTHS. PROBLEM STILL OCCURRING. DEALER WAS NOTIFIED AND REPAIRS/INSPECTION WAS MADE CONTINUALLY, BUT THE PROBLEM WAS NEVER RESOLVED. *AK CONSUMER STATES VEHICLE IS EXPERIENCING ELECTRICAL PROBLEMS AND CAN SMELL SOMETHING LIKE WIRES BURNING, CONSUMER STATES THAT THE RADIO, FAN BLOWER, AND DASH LIGHTS GO ON AND OFF, AT TIMES THE RADIO WILL NOT WORK AT ALL, BATTERY FAILED AND WAS REPLACED, LOW OIL SENSOR FAILED AND WAS REPLACED. VEHICLE HAS EXPERIENCED SEVERAL BRAKE PROBLEMS, BRAKES PULSATE, MASTER CYLINDER LEAK, PROPORTIONING VALVE LEAK, BRAKES GRAB, AND WERE NOT STOPPING THE VEHICLE. SEVERAL ENGINE RELATED PROBLEMS, CONSUMER STATES THE ENGINE WAS NOISY, OIL WAS LEAKING FROM BOTH SIDES OF ENGINE, THE THERMOSTAT, GASKET SEAL, MAIN SEAL, REAR MAIN SEAL, PAN GASKET, BELTS, AND OTHER ENGINE COMPONENTS HAVE BEEN REPLACED. THE LEFT DOOR CORRODED AND RUSTED. FUEL FILTER WAS REPLACED, EXHAUST SYSTEM WAS REPLACED, IAC AND THROTTLE BODY WERE REPLACED, CONSUMER STATES SHE WOULD HAVE TO CONSTANTLY KEEP FOOT ON BRAKE DUE TO HIGH RPMS AND LOUD WHINING, CONSUMER STATES VEHICLE WOULD ACCELERATE SUDDENLY IF FOOT WERE OFF THE BRAKE, THERE WERE TIMES WHEN THE BRAKES WERE NOT STOPPING VEHICLE. RIGHT FRONT TIRE SEPARATED, CAUSING STEERING WHEEL TO WOBBLE, FRONT BEARING NEEDED PACKED, RIGHT REAR AXLE WAS LOOSE. DIFFERENTIAL CARRIER ASSEMBLY WAS OUT, CAUSING A LOUD TICKING AND THUD NOISE. AIR CONDITIONER WAS BLOWING HOT AIR, THE HEATER MODE SELECTOR IS SLOW TO RETURN FROM THE VENT WHEN CHANGED. OUTER TIE ROD ENDS NEEDED REPLACED. *SLC

ON JULY 2, 2002 THE TREAD CAME OFF THE TIRE WHILE ON THE FREEWAY. THE TIRE HAD 49,000 MILES ON IT AND IT WAS WARRANTIED FOR 80,000. IT CAUSED $2,700 IN DAMAGE. BRIDGESTONE CLAIMS THE TIRE WAS OPERATED W/ LOW AIR PRESSURE, THIS IS NOT TRUE! THE FRONT TIRES WERE REPLACED BY PEP BOYS 6 MONTHS PRIOR DUE TO TREAD SEPARATION. I AM HAVING BRIDGESTONE SEND ME THE TIRE BACK. I DO HAVE PHOTOS OF THE TIRE AND VAN DAMAGE. TS

RIGHT REAR TREAD SEPARATION ON INTERSTATE CAUSING LOSS OF CONTROL OF MINIVAN. AEROSTAR ROLLS OVER AND EJECTS THIRD SEAT PASSENGER CAUSING SERIOUS INJURIES. *AK (DOT NUMBER: U9T9B6H018 TIRESIZE: 205/70R14)

THE VEHICLE HAS ALLOY WHEELS AND THE INCORRECT LUG NUTS WERE INSTALLED ON ALL WHEELS AT THE FACTORY, THIS HAS CAUSED ABNORMAL WEAR .

LEFT REAR WHEEL LOCKED UP.

CONSUMER REPORTING AN ONGOING PROBLEM WITH ENGINE ACCELERATION INTERMITTENTLY APPROXIMATELY SIX MONTHS. PROBLEM STILL OCCURRING. DEALER WAS NOTIFIED AND REPAIRS/INSPECTION WAS MADE CONTINUALLY, BUT THE PROBLEM WAS NEVER RESOLVED. *AK CONSUMER STATES VEHICLE IS EXPERIENCING ELECTRICAL PROBLEMS AND CAN SMELL SOMETHING LIKE WIRES BURNING, CONSUMER STATES THAT THE RADIO, FAN BLOWER, AND DASH LIGHTS GO ON AND OFF, AT TIMES THE RADIO WILL NOT WORK AT ALL, BATTERY FAILED AND WAS REPLACED, LOW OIL SENSOR FAILED AND WAS REPLACED. VEHICLE HAS EXPERIENCED SEVERAL BRAKE PROBLEMS, BRAKES PULSATE, MASTER CYLINDER LEAK, PROPORTIONING VALVE LEAK, BRAKES GRAB, AND WERE NOT STOPPING THE VEHICLE. SEVERAL ENGINE RELATED PROBLEMS, CONSUMER STATES THE ENGINE WAS NOISY, OIL WAS LEAKING FROM BOTH SIDES OF ENGINE, THE THERMOSTAT, GASKET SEAL, MAIN SEAL, REAR MAIN SEAL, PAN GASKET, BELTS, AND OTHER ENGINE COMPONENTS HAVE BEEN REPLACED. THE LEFT DOOR CORRODED AND RUSTED. FUEL FILTER WAS REPLACED, EXHAUST SYSTEM WAS REPLACED, IAC AND THROTTLE BODY WERE REPLACED, CONSUMER STATES SHE WOULD HAVE TO CONSTANTLY KEEP FOOT ON BRAKE DUE TO HIGH RPMS AND LOUD WHINING, CONSUMER STATES VEHICLE WOULD ACCELERATE SUDDENLY IF FOOT WERE OFF THE BRAKE, THERE WERE TIMES WHEN THE BRAKES WERE NOT STOPPING VEHICLE. RIGHT FRONT TIRE SEPARATED, CAUSING STEERING WHEEL TO WOBBLE, FRONT BEARING NEEDED PACKED, RIGHT REAR AXLE WAS LOOSE. DIFFERENTIAL CARRIER ASSEMBLY WAS OUT, CAUSING A LOUD TICKING AND THUD NOISE. AIR CONDITIONER WAS BLOWING HOT AIR, THE HEATER MODE SELECTOR IS SLOW TO RETURN FROM THE VENT WHEN CHANGED. OUTER TIE ROD ENDS NEEDED REPLACED. *SLC

REPLACED FRONT BRAKES. *AK

I PURCHASED THIS VAN TO ACCOMODATE MY FAMILY OF 7. THE A/C AND TRANSMISSION HAD BEEN REPAIRED BY LICENSED TECHNITIONS. THE GAS TANK HAS A SMALL 'HAIRLINE' CRACK THAT I HAVE TRIED TO PATCH MYSELF. I FEEL THE GAS TANK LEAK LOCATED AT THE EDGE OF THE TANK IS A DESIGN FLAW, BUT WHAT DO I KNOW? I JUST WANT MY WIFE TO DRIVE MY FAMILY TO AND FROM THEIR DESTINATIONS SAFELY. I HAVE LIMITED FUNDS FOR ALL THE REPAIRS. THANKS FOR LISTENING. REGARDS, TIMOTHY J. SHINN, PH#602-265-4323

CONSUMER PURCHASE CAR NEW THE DRIVER SIDE SEAT BELT BUCKLE BROKE AND THE AIR CONDITIONER WENT OUT WITHIN AN HOUR. TT

CONSUMER REPORTING AN ONGOING PROBLEM WITH ENGINE ACCELERATION INTERMITTENTLY APPROXIMATELY SIX MONTHS. PROBLEM STILL OCCURRING. DEALER WAS NOTIFIED AND REPAIRS/INSPECTION WAS MADE CONTINUALLY, BUT THE PROBLEM WAS NEVER RESOLVED. *AK CONSUMER STATES VEHICLE IS EXPERIENCING ELECTRICAL PROBLEMS AND CAN SMELL SOMETHING LIKE WIRES BURNING, CONSUMER STATES THAT THE RADIO, FAN BLOWER, AND DASH LIGHTS GO ON AND OFF, AT TIMES THE RADIO WILL NOT WORK AT ALL, BATTERY FAILED AND WAS REPLACED, LOW OIL SENSOR FAILED AND WAS REPLACED. VEHICLE HAS EXPERIENCED SEVERAL BRAKE PROBLEMS, BRAKES PULSATE, MASTER CYLINDER LEAK, PROPORTIONING VALVE LEAK, BRAKES GRAB, AND WERE NOT STOPPING THE VEHICLE. SEVERAL ENGINE RELATED PROBLEMS, CONSUMER STATES THE ENGINE WAS NOISY, OIL WAS LEAKING FROM BOTH SIDES OF ENGINE, THE THERMOSTAT, GASKET SEAL, MAIN SEAL, REAR MAIN SEAL, PAN GASKET, BELTS, AND OTHER ENGINE COMPONENTS HAVE BEEN REPLACED. THE LEFT DOOR CORRODED AND RUSTED. FUEL FILTER WAS REPLACED, EXHAUST SYSTEM WAS REPLACED, IAC AND THROTTLE BODY WERE REPLACED, CONSUMER STATES SHE WOULD HAVE TO CONSTANTLY KEEP FOOT ON BRAKE DUE TO HIGH RPMS AND LOUD WHINING, CONSUMER STATES VEHICLE WOULD ACCELERATE SUDDENLY IF FOOT WERE OFF THE BRAKE, THERE WERE TIMES WHEN THE BRAKES WERE NOT STOPPING VEHICLE. RIGHT FRONT TIRE SEPARATED, CAUSING STEERING WHEEL TO WOBBLE, FRONT BEARING NEEDED PACKED, RIGHT REAR AXLE WAS LOOSE. DIFFERENTIAL CARRIER ASSEMBLY WAS OUT, CAUSING A LOUD TICKING AND THUD NOISE. AIR CONDITIONER WAS BLOWING HOT AIR, THE HEATER MODE SELECTOR IS SLOW TO RETURN FROM THE VENT WHEN CHANGED. OUTER TIE ROD ENDS NEEDED REPLACED. *SLC