2013 Ford Edge Engine Problems

I am filing a consumer complaint against Ford Motor Company regarding a known, severe safety defect in my 2013 Ford Edge 3.5L AWD. The internal water pump has failed, leaking green coolant onto the ground and threatening catastrophic engine failure. Ford designed this vehicle with an internal water pump that dumps coolant into the engine oil when it fails, hiding the defect from consumers until the powertrain is destroyed. Furthermore, the All-Wheel Drive Power Transfer Unit (PTU) is overheating due to a design that labels the fluid 'lifetime' and prevents standard servicing. I purchased this vehicle for $14,400 and have invested $4,000 in maintenance, and I am seeking state consumer protection advocacy regarding Ford's deceptive engineering practices."

NHTSA ID

11746866

Incident

Jun 27, 2026

I have several different things going on. First of all my rear turn signals do not work, nor do my rear hazard lights. I've taken it to a mechanic who has extensively looked at this and has determined that it's the body control modular and is suggested replacement. I have been waiting for several months for this part to come in but he keeps telling me it's on back order. Also, my radiator fan/assembly went bad and had to be replaced. Upon the mechanic installing the new fan assembly, I had numerous fuses blown and that is when my blinker and hazard light issue started. This is a major safety concern as signaling the direction that you're turning is very important to other drivers. Additionally, it is against the law not to use signals. I'm constantly in fear that someone is going to rear in me because of my inability to signal when switching lanes and or turning. Additionally, my back up camera stopped working shows a black screen with a notice to contact the dealer. Another issue I have is that my door ajar light is illuminated all the time. I often feel unsafe and fear that the door may just come open at any time, I am unable to lock my doors with the internal lock , which means my doors are left unlocked while I'm in the vehicle. Also, the interior lights stay on for awhile when car turned off, thus putting more strain on the battery, which I've just replaced. Plus, the dome light will not go off until you accelerated to about 20 mph, however, when putting the car in reverse there's no way to get the lights to turn off in this causes visibility issues at night. That in conjunction with my backup camera not working makes it a very dangerous situation when going in reverse. I also detect the odor of gasoline which lingers in my vehicle for some time after getting fuel. I'm scared that there's a leak and if so the potential of a fire is very concerning. And I've noticed that my gas mileage is not really good and I'm not sure if that's related.

NHTSA ID

11722586

Incident

Dec 1, 2025

I purchased this vehicle used in August 2025 from the estate of a friend's relative. The records show it was meticulously maintained and no recall notices have been unaddressed. The prior owner used it infrequently and it still has just under 90k miles. There were no major engine issues when my local repair shop (over 12 years and 3 vehicles) inspected all systems, and the vehicle passed for PA state inspection and emissions. However, driving more, I noticed that the brakes would intermittently become "mushy" or "hard" and overall less responsive. I needed to use a lot of force to fully stop over a longer distance. There was also a hissing noise while braking and sometimes the cabin air fan would blast on suddenly. Then, while stopped at a red light and applying the brakes, the engine shut off and check engine light came on. My mechanic detected O2 sensor codes P2195/P2197 indicating "stuck lean." But nothing about the brake booster, and so we cleaned it up a bit and tried to get more of an understanding of the issue. Now I know that the compromised engine vacuum from the booster air leak is impacting the fuel/air balance. Extremely unsafe. This has now happened MANY times while I try to get a good diagnosis and help. It's scary, and makes city driving very challenging. On multiple occasions I feared I would hit other vehicles or would have to "creep" at a light to alleviate the airflow issues from braking. If I have to be at a light for more than a moment, I will put the car in park and foot off the brake. I'd rather risk being honked at or hit, than have the engine dying on me in traffic. When I was able to get to a dealership, I was informed that it was the brake booster. The first thing I found when looking up that part for the 2013 Ford Edge was the recall. The dealership says my VIN was not covered, but it seems more than coincidence that this is the exact problem, now confirmed by the dealership. The part is faulty, and should be replaced by OEM.

NHTSA ID

11703726

Incident

Dec 4, 2025

Since the day I bought my 2013 Edge I have had nothing but problems ranging from Backup Camera always has a distorted image, appears upside down or it will just be blank. For the last year I have had my car looked at, changed everything that could possibly be changed to now my car can be going down the road running 55-60 MPH and the car will just shut down and flash random warnings on the dash but the scariest & most unsafe part is how the steering wheel locks up or I lose power steering making it hard to move or coast off the road to safety. At this point I don't know what else to do. Questions below are asking for dates but unfortunately there are so many dates that my car does this as it happens almost daily so I will put date for the last day I drove it. Right now it has been sitting at a mechanic's place for the last 3.5 weeks.

NHTSA ID

11688651

Incident

Aug 24, 2025

Water pump failure coolant leaking out of it Was driving at 10mph in parking garage when temperature gauge went to hot on cluster instrument everyone was ok had have had vehicle for about a month before breakdown private dealer did say there were no issues car has not been checked by a certified dealership.

NHTSA ID

11685279

Incident

Aug 23, 2025

The contact owns a 2013 Ford Edge. The contact stated that while his wife was driving 80 MPH, the vehicle lost motive power while the RPMs exceeded 5,000 RPM. The contact stated that the check engine warning light was flashing. The driver was able to pull over to the side of the road. The contact stated that his wife turned off and restarted the vehicle, and the vehicle was on LIMP Mode. The contact's wife was able to drive to the residence. A mobile mechanic diagnosed the vehicle at the residence and informed the contact that there was a misfire in cylinder #2. The mechanic advised the contact that the failure could be related to the coil packs, the fuel injectors, or the fuel lines. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and a case was filed. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 170,000.

NHTSA ID

11664318

Incident

May 23, 2025

Mileage

170,000 mi

The contact owns a 2013 Ford Edge. The contact stated that while driving 50 MPH, the brake pedal was depressed, and there was an abnormal grinding sound coming from the vehicle, and the vehicle failed to respond. The brake failure and general warning lights were illuminated. The contact stated that the brakes eventually responded. The vehicle was then taken to an independent mechanic, who diagnosed the vehicle; however, the independent mechanic refused to repair the vehicle. The independent mechanic informed the contact the failure should be covered under recall. The independent mechanic stated that he would be liable if the brakes failed again, and the contact was involved in a crash. The vehicle was then taken to a dealer, where it was diagnosed with brake booster failure. The vehicle received repair for a bent push rod, motor craft, motor, brake fluid, and the upper intake was replaced. After the repair, the failure recurred two more times, and the vehicle was repaired two more times. The vehicle was pending further repairs. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 164,301.

NHTSA ID

11656519

Incident

Dec 21, 2022

Mileage

164,301 mi

The contact owns a 2013 Ford Edge. The contact stated that upon inspection of the vehicle, the contact discovered an unknown fluid leak. There was no warning light illuminated. Due to the failure, the vehicle was towed to the dealer and the contact was informed that the water pump had failed and caused radiator fluid to leak from the vehicle. The contact was provided an estimate for the replacement of the water pump. The vehicle was repaired. The manufacturer was notified of the failure and the contact was informed that there were no recalls or warranties on the vehicle. The failure mileage was 70,450.

NHTSA ID

11626465

Incident

Sep 13, 2024

Mileage

70,450 mi

The contact owns a 2013 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power inadvertently. The driver was able to pull to the shoulder of the roadway, where the failure persisted. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed that the turbo had failed. The vehicle was not repaired. No further information was provided. The manufacturer was notified of the failure, but no assistance was provided . The failure mileage was 135,000.

NHTSA ID

11620577

Incident

Oct 11, 2024

Mileage

135,000 mi

The contact owns a 2013 Ford Edge. The contact stated that after arriving at her destination, the check engine warning light illuminated. The contact stated upon further inspection, she noticed a leak coming from the engine compartment. The vehicle was taken to a local independent mechanic who advised the contact to take the vehicle to a local dealer for assistance. The vehicle was taken to a local dealer where it was diagnosed and determined that the water pump had failed, and that the front of the engine and the timing belt needed to be removed to reach the parts needed to be replaced. Additionally, the bearing behind the water pump needed to be replaced. The vehicle was not repaired due to the costs. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 114,000.

NHTSA ID

11612584

Incident

Jul 18, 2024

Mileage

114,000 mi

The contact owns a 2013 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle shuddered abnormally. No warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that there was coolant intrusion into the cylinders, and that the engine needed to be replaced. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 135,000.

NHTSA ID

11608486

Incident

Aug 8, 2024

Mileage

135,000 mi

Backfiring and brakes don’t work.

NHTSA ID

11595408

Incident

Feb 15, 2023

The contact owns a 2013 Ford Edge. The contact stated while driving and approaching a stop light, the brake pedal was depressed but the vehicle was slow to respond. The contact applied additional pressure to the brake pedal to stop the vehicle. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic and the contact was informed that there was a slice in the vacuum pump and that the brake booster needed to be replaced. The vehicle was taken to the local dealer, where it was diagnosed that the brake booster needed to be replaced. The vehicle was not repaired. The contact stated that the failure was related to TSB: 13N02. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 180,000.

NHTSA ID

11593617

Incident

Jun 3, 2024

Mileage

180,000 mi

coolant leak from water pump

NHTSA ID

11586772

Incident

May 2, 2024

Liquid was leaking below the 2013 Ford Edge engine in our garage. A reputable independent repair center checked it out and found it to be the water pump leaking; which is located inside the Ford Cyclone engine. The engine would need to be taken apart to replace the defective water pump. It was explained to me that driving the vehicle may cause water to mix into the oil causing even more problems. I checked with a local Ford service center and was told they only have one person who can do this type of job and it would be over a month before it could be done. I opted for the reputable independent repair center who could do it in a week. The vehicle has been driven only 60,663 miles and is well maintained. The repair was done [XXX] and the cost of the repair was approximately $2,000. A certified letter was sent to James Farley (CEO & President of Ford) on [XXX] asking for reimbursement of the $2,000 due to the defective water pump. Shortly after sending the letter, Ford customer service emailed and asked for more information. More information was sent and am still waiting for a response No warning lights came on, the part has been disposed of and not was not inspected by Ford, Police or insurance reps. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11578346

Incident

Feb 26, 2024

The contact owns a 2013 Ford Edge. The contact stated while driving approximately 60 MPH, the vehicle lost motive power and stalled. The driver was able to steer the vehicle unto the shoulder and restart the engine. After restarting the vehicle, the vehicle operated normally. The failure had occurred on three separate occasions. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure but no assistance was offered. The failure mileage was 111,000.

NHTSA ID

11575355

Incident

Jan 8, 2024

Mileage

111,000 mi

The contact owns a 2013 Ford Edge. The contact stated while driving the vehicle at an undisclosed speed the vehicle did not immediately stop when the contact depressed the brakes. No warning lights illuminated. The vehicle was taken to the dealer where a diagnostic was performed. The dealer stated the eco booster failed and needed to be replaced. The vehicle was not repaired due to cost. The contact referenced Ford's Customer Satisfaction Program 13N02 as a possible solution however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was approximately 110,000.

NHTSA ID

11571739

Incident

Feb 13, 2024

Mileage

110,000 mi

Put car in for regular service, and to investigate burning smell and transmission slippage. Mechanic found that the Power Transfer Unit (PTU) was completely filled with a paste-like sludge. (he has pictures) Mechanic says that the PTU is too close to the catalytic converter, therefore overheating the PTU and literally boiling the transfer fluid. He was able to clean the module, but says there's still a leak around the PTU seal. The work required to replace the seal, would also merit replacing the PTU. BUT, this is a $800 part! The safety risk would have been my transmission completely seizing up and causing an accident due to mechanical failure. The vehicle has had all of it's regular and milestone service work performed. No warning lights went off. I'm on borrowed time with this part and/or new transmission. Will there be a remedy to prevent this in the future?

NHTSA ID

11569758

Incident

Jan 30, 2024

The contact owns a 2013 Ford Edge. The contact stated that upon coming to a complete stop, the temperature gauge indicated that the vehicle was overheating. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular failure. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who was unable to determine the cause for the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 15V813000 (Electrical System), but the VIN was not included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 122,000.

NHTSA ID

11554894

Incident

Oct 15, 2023

Mileage

122,000 mi

Break booster with leak noted requiring replacement. Turbo boost needing replacement. After turbo boost replacement, began having a shudder during acceleration between 40-48 mph. Now needing torque converter replaced.

NHTSA ID

11554717

Incident

Jul 11, 2023

Mileage

128,447 mi

Vehicle will not idle at the correct rpms. Replaced battery and alternator had everything checks by a certified mechanic. The battery light will come on while driving and the car will begin to stall out while driving. Cannot run ac or any electric component in the car. Really scary when you have kids in the car driving down the road and it begins to shut down but still going the same rate of speed.

NHTSA ID

11538888

Incident

Aug 16, 2023

While driving the 2013 Edge Sport/vehicle just stalls out, tool light appears on for a couple of seconds then shuts off, vehicle doesn't accelerate, and then vehicle shuts off. Vehicle does start back up. This happen more than one occasion. Called dealership - Waiting to get my vehicle in the shop. Very dangerous because I was in the middle lane and almost got rear-ended and but myself and my son in danger along with other drivers. No prior engine light or any other light on beforehand.

NHTSA ID

11538048

Incident

Jul 27, 2023

My daughter was driving the car and the vehicle stalled out. A warning light for low oil pressure came on however the oil was change 1 week ago. This is very dangerous because she was on a very busy highway. Also when putting gas in the car it sometimes will not start.

NHTSA ID

11533131

Incident

Jul 18, 2023

I took very good care of my car's engine and while driving on the highway the engine block cracked open immediately shutting the car down, almost causing a crash and spilling oil all over the road for no apparent reason. There were no issues with the engine and no check engine lights were on.

NHTSA ID

11527233

Incident

Apr 15, 2023

2013 Ford edge sport water pump defect leaking into the engine causing it to stop in traffic which was dangerous because oil and antifreeze mixed together now it want run.

NHTSA ID

11526649

Incident

Apr 14, 2023