2020 Ford Edge Owner Complaints

Car stutters, shudders, and hesitates from stopped position. Vehicle does not excelerate smoothly. Safety concern when pulling out into traffic, crossing intersection, or leaving stop. Paducah Ford said it is torque converter and independent mechanic says that as well. Ford issued tech service information concerning shudder for Ford Edge 8F35 transmission and provides a repair procedure for torque converter and output planetary assembly. I am concerned because it may represent a recurring safety related defect affecting other Ford Edge vehicles

NHTSA ID

11756196

Incident

Jul 19, 2026

Our 2020 Ford Edge SEL has experienced ongoing shuddering and hesitation while driving. The Ford dealership inspected the vehicle and diagnosed the torque converter as the likely cause, recommending approximately $4,500 in repairs. The torque converter has not been replaced and is available for inspection. We obtained a second opinion from an independent repair shop, which replaced the EGR sensors and updated them in an attempt to resolve the issue. The problem has created a safety concern because the vehicle does not always accelerate or operate normally while driving. The exact cause remains UNKNOWN, and the issue has not been inspected by police or insurance representatives.

NHTSA ID

11755790

Incident

Jul 21, 2026

XXX, I parked my Edge car around 11am. I always put the car into park mode before turning off vehicle! The road was flat, good weather and had no previous issues/warnings. I went into building. My gray Ford Edge 2020 ST with 105,000. miles is a wonderful vehicle! I came out of appointment about an hour later and my Edge had rolled backwards 6 to 8 feet! It almost hit another vehicle, parked behind my car! I immediately took my car to local Ford dealership service, Baugh Ford, [XXX]. I was told I needed to pay 1500 dollars for the vehicle to be taken apart to get an estimate of what needed to be fixed? I don’t have 1500 dollars to just give to ford service for them to look online and find what other years and other Ford models have had with this exactly same safety recall! This is a HUGE safety issue and FORD DOES NOT want to fix because this is a vehicle that I paid off in 7 years, have been only driver and never been in any accidents! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755508

Incident

Aug 5, 2026

Transmission shutter caused by faulty torque converter. Vehicle hesitates at times leading to unsafe conditions when merging or pulling out into traffic.

NHTSA ID

11754082

Incident

Jul 1, 2026

The contact owns a 2020 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle jerked roughly while turning right or left, with a grinding sound coming from the vehicle. The contact stated that the vehicle was driving sluggishly. The contact stated that the brakes had been recently serviced but might be the issue. The vehicle was taken to a dealer where it was diagnosed with a rear axle failure caused by inadequate lubrication in the rear axle. The contact associated the failure with NHTSA Campaign Number: 21V011000 (Power Train); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 94,000.

NHTSA ID

11754015

Incident

Jun 20, 2026

Mileage

94,000 mi

While driving the HVAC stops working, radio locks at current setting (cannot turn volume up or down, etc.), screen goes blank or locks, windows do not open or close. Their are multiple warnings about sensors not working. Malfunctioning driver assist jerks wheel when driving through a restaraunt drive-thru. Had the sensor replaced for the adaptive cruise control and it did not correct the cruise issue. The issue initially started with the monitor screen going blank randomly and then progressing to the above issues. This had been happening for the last 2 or 3 years before the above accured.

NHTSA ID

11753565

Incident

May 11, 2026

The vehicle hesitates, jumps, and then surges into gear when accelerating from low speed, which I believe makes it difficult and hazardous merging into traffic and other driving situations. Due to the hesitation it is unable to get up to speed very easily or quickly on busy interstate roads. The hesitation, jumping, and surging has gotten progressively worse and occurs at higher speeds now. It seems like it now does this during each gear shift. I am a longtime Ford owner I previously drove a 2001 F150 with little to no problems, it reached around 280,000 miles before it's trade in. I now have a 2020 Edge SEL 2.0 AWD and have really enjoyed this car until this problem started. It was bought in March of 2024 with 62k miles and it now has 92k. The problem initially only surfaced after the car had bene on and moving for a while and it was very subtle. I could not tell if it was engine or tranny and it was only barely noticeable. But the issue has remained and now occurs at all periods of time when being driven. I have had this vehicle inspected by multiple service centers now, both of which confirm the problem being that when shifting gears the internal parts of the transmission slip causing wear and extra heat generation, leading to the slipping and jumping. The transmission needs to either be rebuilt or replaced due to its faulty initial construction. I have been told by these mechanics that they have had to do this exact replace on many of this exact same model of car, and similarly each time they've done it the models are typically around 80,000-90,000 miles not even making it to 100,000. There were no warning lights or messages and there still aren't any even after getting it looked at twice.

NHTSA ID

11752692

Incident

Mar 20, 2026

The transmission has been serviced regularly. It is starting to jerk at lower speeds. I have had two auto mechanics from different shops and locations inspect the transmission. Both have found shaved metal in the transmission fluid. After a call to two different Ford dealerships, the auto mechanics were informed that it is a problem with these transmissions, but Ford has not issued a recall. If I have to replace the transmission, I will be contacting an attorney for assistance. There have been no warning lights or alarms indicating that there are problems with the transmission. Because there are no warning lights on the dashboard, it has been hard to diagnose the actual problem. Of course, I am approximately 6000 miles over the extended warranty. At the time I took the car to the shop, the mileage was 79,465.

NHTSA ID

11752478

Incident

Jul 9, 2026

Torque Converter failed Car jerks at low speeds. Car was unsafe to drive, vehicle had trouble accelerating when needed. Ford Garage inspected vehicle and diagnosed the problem. There was no warning lamps or messages.

NHTSA ID

11751793

Incident

Jun 9, 2026

Recently had the torque converter replaced for shuddering/shifting weird. Although there is no more shuddering, the car still does not seem to be shifting correctly. It hesitates between shifting gears and will then accelerate quickly. It was seen at the shop again today and they could not find any issues with it although I was told it will likely do it again for me and to let them know. There have not been an indicator lights.

NHTSA ID

11751570

Incident

Jan 1, 2026

Hesitation with shifting when driving at low speeds. The powertrain control system has detected one of the transmission clutches did not apply within the expected time as expected. Some transmission gears may not being available resulting in delayed or harsh shifts into another gear.

NHTSA ID

11751326

Incident

Jul 7, 2026

At approximately 100,000 miles vehicle began shuddering at 25mph and 35mph. At 103,000 miles the transmission needs a full rebuild. Im told this is a $7,500 repair job and I still owe over $20,000.00.

NHTSA ID

11751247

Incident

Jul 1, 2026

The contact owns a 2020 Ford Edge. The contact stated that the rearview camera was inoperable. There was no warning light illuminated. The local dealer was contacted and confirmed that the VIN was not under recall. The vehicle had not been diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 98,000.

NHTSA ID

11751012

Incident

Jul 15, 2026

Mileage

98,000 mi

I own a 2020 Ford Edge ST with approximately 62,460 miles. My vehicle has developed a loud noise coming from the rear differential, particularly when turning at low speeds. On July 6, 2026, I had the vehicle inspected by my independent mechanic, Kenny's Quick Service. Ford Motor Company has not inspected my vehicle. My mechanic documented the following: "Customer has a noise in the rear of vehicle. Checked vehicle and found noise in rear differential, when turning at low speeds. Checked fluid and fluid is not at proper level, differential could possibly come apart. Differential needs to be replaced." Based on this inspection, my mechanic advised me not to continue driving the vehicle because of the condition of the rear differential. I was advised that if the differential completely fails, the vehicle could stop moving and potentially create a dangerous situation, including the possibility of an accident. The vehicle is currently not being driven because of this safety concern. This issue concerns me because Ford previously issued Safety Recall 21S02 involving certain 2020-2021 Ford Edge vehicles and a low-fluid condition in the rear drive unit. According to the recall information, inadequate lubrication could cause the rear drive unit to seize, resulting in loss of drive and/or loss of vehicle control and increasing the risk of a crash. My vehicle is a 2020 Ford Edge ST, but my VIN is not included in the 21S02 recall. Despite not being included in the recall, my independent mechanic has now diagnosed a rear differential problem involving an improper fluid level and a condition requiring replacement of the differential. The similarity between the recalled condition and the condition diagnosed in my vehicle concerns me greatly. The estimated cost to replace the rear differential has been verbally stated to be approximately $3,000 to $5,000. I have not yet received a formal written repair estimate. I have contacted Ford Motor Company regarding this issue. Ford opened

NHTSA ID

11750994

Incident

Jul 4, 2026

Transmission Shutter. Lose of transfer of power. Needed rebuild transmission eventually. Told all was in working order untill it wasn't.

NHTSA ID

11750681

Incident

Jun 26, 2026

The contact owns a 2020 Ford Edge. The contact stated that while parked on two occasions, the driver's seatbelt failed to retract and was inoperable. The contact stated that after a few attempts to pull the seatbelt, the seatbelt retracted. The vehicle was taken to a dealer where the failure could not be replicated. The contact stated that the seatbelt was kept latched when exiting the vehicle. The manufacturer was not notified of the failure. The failure mileage was approximately 30,500.

NHTSA ID

11749253

Incident

May 19, 2026

Mileage

30,500 mi

I was on a highway going 75 and my car just slowed down and i was in front of a semi truck then the gears wouldn’t shift i was stalled in that lane everything else worked but the gears wouldn’t shift into place i got it in neutral and pushed it to the side

NHTSA ID

11748766

Incident

Jul 6, 2026

transmission, skipping and shuttering and according to dealership not catching gear occurs during slow speeds. When in drive car will roll backwards and when in reverse car will roll forward. Transmission runs high until gear catches. Engine will then go in to neutral until clutch catches.in according to dealership repair will cost $7000-$11,000. i was told this is unusual. And none of it is covered under warranty

NHTSA ID

11748726

Incident

Jul 2, 2026

Car is glitching, jerking between 20-40 mph there is a burnt smell also Car jerks when put in drive and reverse. Car jerks when driving FORD and AAMCO SAID WE NEED NEW REBUILD TRANSMISSION AND TORQUE FOR $7,500 car only has 53,400 miles 6 years old

NHTSA ID

11746958

Incident

Jun 15, 2026

Complainant: [XXX] Vehicle: 2020 Ford Edge VIN: [XXX] Current Mileage: Approx. 152,000 miles Target of Complaint: Ford Motor Company / [Don Chalmers Ford] Subject: Request for Goodwill Financial Assistance Due to Documented, Inherent Transmission Manufacturing Defect I am filing this dispute to request financial assistance/cost-sharing from Ford Motor Company for a total transmission failure on my 2020 Ford Edge. While the vehicle is past its standard powertrain warranty, the failure is directly caused by an inherent manufacturing defect that Ford has internally acknowledged and documented. The dealership has quoted $9,000 for a full replacement, an unreasonable financial burden for a known, pre-existing mechanical flaw. The vehicle is experiencing severe shifting difficulties, specifically when attempting to transition the vehicle out of Park into any other gear. A formal diagnostic inspection conducted by the authorized Ford dealership confirmed a total transmission failure. Crucially, the dealership verified that the vehicle's symptoms and mechanical failures match Technical Service Bulletin (TSB) 857 / 20-2190 (tel:857%20/%2020-2190). This internal Ford bulletin specifically addresses harsh engagements, shifting faults, and component degradation within this vehicle's transmission model. The dealership initially denied financial assistance because this vehicle’s specific VIN is not included in safety recall Campaign 20S47. I wish to clarify that I am not arguing a violation of a safety recall. I understand that Campaign 20S47 is a narrow, VIN-specific safety mandate. Instead, my case rests on the fact that the dealership’s own diagnostics verified the exact mechanical failure described in Ford’s internal Technical Service Bulletins. A TSB proves that Ford is fully aware of a widespread, systemic manufacturing defect in these units. The exclusion of my VIN from a safety recall does not negate the fact that my vehicle suff INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

NHTSA ID

11745831

Incident

Apr 1, 2026

Failed torque converter, diagnosed and confirmed by local certified Ford dealer in Portage, Wisconsin. Vehicle can potentially leave is stranded with additional repair costs if not addressed.

NHTSA ID

11745776

Incident

Jun 5, 2026

For over a year, engine shudders/jerks when accelerating. I see this has been a repeated complaint by many for a few years now. How is this not a recall?????

NHTSA ID

11745654

Incident

Apr 6, 2026

Car shutters and jerks. Transmission has completely shut done.

NHTSA ID

11744549

Incident

May 4, 2026

My vehicle is a 2020 Ford Edge with only 41,000 miles and the transmission is failing. Currently I have had the torque converter replaced; however, the issues are not completely resolved. I’m taking the vehicle back to the repair shop today.

NHTSA ID

11744380

Incident

May 23, 2026

Over a dozen times, when my car sits outside in the sun on a hot day, my drivers side seat belt becomes locked in the retracted position. I am unable to use my seatbelt until my car cools down which takes appoximately 15-20 of my AC running on MAX AC. During this time, I either have to sit in my car and not drive or I have to drive without a seatbelt until it unlocks. This is a safety hazard because as a healthcare worker, I need to be able to get to my job when I need to be there. At any given time, I should be able to get into my vehicle and drive immediately with my seatbelt on. No warning lights come up on my dash when this occurs, I just can't put my seatbelt on. I brought the vehicle to the dealership and they said I need to replace my seatbelt for the price of ~$950. This is something that needs to be recalled and repaired at the cost of FORD. I have read numerous people online complaining of the exact same issue with their driver side seatbelt.

NHTSA ID

11743453

Incident

Jun 26, 2025