2020 Ford Edge

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.

Car stutters, shudders, and hesitates from stopped position. Vehicle does not excelerate smoothly. Safety concern when pulling out into traffic, crossing intersection, or leaving stop. Paducah Ford said it is torque converter and independent mechanic says that as well. Ford issued tech service information concerning shudder for Ford Edge 8F35 transmission and provides a repair procedure for torque converter and output planetary assembly. I am concerned because it may represent a recurring safety related defect affecting other Ford Edge vehicles

NHTSA ID

11756196

Incident

Jul 19, 2026

Our 2020 Ford Edge SEL has experienced ongoing shuddering and hesitation while driving. The Ford dealership inspected the vehicle and diagnosed the torque converter as the likely cause, recommending approximately $4,500 in repairs. The torque converter has not been replaced and is available for inspection. We obtained a second opinion from an independent repair shop, which replaced the EGR sensors and updated them in an attempt to resolve the issue. The problem has created a safety concern because the vehicle does not always accelerate or operate normally while driving. The exact cause remains UNKNOWN, and the issue has not been inspected by police or insurance representatives.

NHTSA ID

11755790

Incident

Jul 21, 2026

XXX, I parked my Edge car around 11am. I always put the car into park mode before turning off vehicle! The road was flat, good weather and had no previous issues/warnings. I went into building. My gray Ford Edge 2020 ST with 105,000. miles is a wonderful vehicle! I came out of appointment about an hour later and my Edge had rolled backwards 6 to 8 feet! It almost hit another vehicle, parked behind my car! I immediately took my car to local Ford dealership service, Baugh Ford, [XXX]. I was told I needed to pay 1500 dollars for the vehicle to be taken apart to get an estimate of what needed to be fixed? I don’t have 1500 dollars to just give to ford service for them to look online and find what other years and other Ford models have had with this exactly same safety recall! This is a HUGE safety issue and FORD DOES NOT want to fix because this is a vehicle that I paid off in 7 years, have been only driver and never been in any accidents! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755508

Incident

Aug 5, 2026

Transmission shutter caused by faulty torque converter. Vehicle hesitates at times leading to unsafe conditions when merging or pulling out into traffic.

NHTSA ID

11754082

Incident

Jul 1, 2026

The contact owns a 2020 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle jerked roughly while turning right or left, with a grinding sound coming from the vehicle. The contact stated that the vehicle was driving sluggishly. The contact stated that the brakes had been recently serviced but might be the issue. The vehicle was taken to a dealer where it was diagnosed with a rear axle failure caused by inadequate lubrication in the rear axle. The contact associated the failure with NHTSA Campaign Number: 21V011000 (Power Train); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 94,000.

NHTSA ID

11754015

Incident

Jun 20, 2026

Mileage

94,000 mi

While driving the HVAC stops working, radio locks at current setting (cannot turn volume up or down, etc.), screen goes blank or locks, windows do not open or close. Their are multiple warnings about sensors not working. Malfunctioning driver assist jerks wheel when driving through a restaraunt drive-thru. Had the sensor replaced for the adaptive cruise control and it did not correct the cruise issue. The issue initially started with the monitor screen going blank randomly and then progressing to the above issues. This had been happening for the last 2 or 3 years before the above accured.

NHTSA ID

11753565

Incident

May 11, 2026

The vehicle hesitates, jumps, and then surges into gear when accelerating from low speed, which I believe makes it difficult and hazardous merging into traffic and other driving situations. Due to the hesitation it is unable to get up to speed very easily or quickly on busy interstate roads. The hesitation, jumping, and surging has gotten progressively worse and occurs at higher speeds now. It seems like it now does this during each gear shift. I am a longtime Ford owner I previously drove a 2001 F150 with little to no problems, it reached around 280,000 miles before it's trade in. I now have a 2020 Edge SEL 2.0 AWD and have really enjoyed this car until this problem started. It was bought in March of 2024 with 62k miles and it now has 92k. The problem initially only surfaced after the car had bene on and moving for a while and it was very subtle. I could not tell if it was engine or tranny and it was only barely noticeable. But the issue has remained and now occurs at all periods of time when being driven. I have had this vehicle inspected by multiple service centers now, both of which confirm the problem being that when shifting gears the internal parts of the transmission slip causing wear and extra heat generation, leading to the slipping and jumping. The transmission needs to either be rebuilt or replaced due to its faulty initial construction. I have been told by these mechanics that they have had to do this exact replace on many of this exact same model of car, and similarly each time they've done it the models are typically around 80,000-90,000 miles not even making it to 100,000. There were no warning lights or messages and there still aren't any even after getting it looked at twice.

NHTSA ID

11752692

Incident

Mar 20, 2026

The transmission has been serviced regularly. It is starting to jerk at lower speeds. I have had two auto mechanics from different shops and locations inspect the transmission. Both have found shaved metal in the transmission fluid. After a call to two different Ford dealerships, the auto mechanics were informed that it is a problem with these transmissions, but Ford has not issued a recall. If I have to replace the transmission, I will be contacting an attorney for assistance. There have been no warning lights or alarms indicating that there are problems with the transmission. Because there are no warning lights on the dashboard, it has been hard to diagnose the actual problem. Of course, I am approximately 6000 miles over the extended warranty. At the time I took the car to the shop, the mileage was 79,465.

NHTSA ID

11752478

Incident

Jul 9, 2026

This bulletin supersedes 26-2171. Reasons for update: update the Parts list to add a note to clarify the application of the part numbers W520102-S442 and 4S4Z-3N324-AA "FWD Only". Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder condition, most noticeable at speeds below 60 mph (100 km/h)  No relevant diagnostic trouble codes (DTC) present  Traceable shudder event with IDS/FDRS reading *(Figure 1)* This condition may be perceived/felt as an engine misfire. This may be due to a concern with the output planetary assembly.

This bulletin supersedes 26-2194. Reason for update: update the Parts list to correct a part description " Loctite 638", update the claim quantity for the drain/fill plug, update the claim quantity of the wheel hub bolts (Corsair) and limited the parts list for Edge/Nautilus to only the rear drive unit fluid. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No relevant diagnostic trouble codes (DTCs) present This may be due to internal rear drive unit (RDU) fluid contamination.

This bulletin supersedes 25-2627. Reason for update: To add a Step to reprogram the all-wheel drive (AWD) module for Bronco Sport vehicles. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No relevant diagnostic trouble codes (DTCs) present This may be due to internal rear drive unit (RDU) fluid contamination.

This article updates TSB 25-2154. Reasons for update: *Parts List *Service Procedure to replace the output planetary carrier assembly *Added 2023-2024 model year vehicles Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder condition, most noticeable at speeds below 60 mph (100 km/h)  No relevant diagnostic trouble codes (DTC) present  Traceable shudder event with IDS/FDRS reading *(Figure 1)* This condition may be perceived/felt as an engine misfire. This may be due to a concern with the output planetary assembly.

Various 2020-2026 Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may experience an inoperative blind spot monitoring with a "Blind Spot System Fault" message displayed in the instrument panel cluster (IPC). This may also be accompanied by diagnostic trouble codes (DTCs) B118C:11 and/or B118C:15 stored in the driver door module (DDM), and/or B118D:11 and/or B118D:15 stored in the passenger door module (PDM). This may be due to the wiring connector from the mirror to the BLIS module. If diagnostics lead to an internal mirror wiring harness fault, a new lower level BLIS light pigtail is now released for service. It is not necessary to replace the exterior mirror assembly. Use part number SC3Z-14A411-B to resolve the concern.

Advance Notice – Customer Satisfaction Program 25N17 Certain 2015-2025 Model Year Multiple Vehicle Lines Rear View Camera Replacement If Required After Dealer Evaluation