2000 Ford Excursion Tires & wheels Problems

Michelin Defender LTX M/S size 265/75R16. 4 new tires installed less than 60 days and 1,800 miles by Costco before incident. Tire air pressure checked prior to a trip. On the trip, 1 tire rapidly deflated without warning on the freeway in Arizona. Barely had enough time to pull off the freeway and onto the shoulder. The tire showed no punctures, or tread separation, but the tire sidewalls were wrinkled and distorted. Took tire to Costco for warranty and the tire shop could not find any internal punctures and were unable to determine as to why the tire went flat. They said they have never seen a tire fail like this.

NHTSA ID

11449011

Incident

Jan 18, 2022

TL* THE CONTACT OWNS A 2000 FORD EXCURSION EQUIPPED WITH FIRESTONE STEELTEX TIRES, SIZE: 385/65-R18 (NA). WHILE DRIVING 70 MPH, THE TREAD ON THE TIRES SEPARATED AND THE CONTACT LOST CONTROL OF THE VEHICLE. AS A RESULT, A CRASH OCCURRED AND THREE OCCUPANTS SUSTAINED MAJOR AND MINOR INJURIES. ONE INJURY WAS FATAL. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VIN AND DOT NUMBER WERE NOT AVAILABLE. THE VEHICLE FAILURE MILEAGE WAS 150,000 AND THE TIRE FAILURE MILEAGE WAS 3,000.

NHTSA ID

11076641

Incident

Aug 10, 2017

Mileage

150,000 mi

TL* THE CONTACT OWNS A 2000 FORD EXCURSION EQUIPPED WITH MASTERCRAFT COURSER AWT TIRES, SIZE: LT265/75/R16 (NA). WHILE DRIVING AT APPROXIMATELY 65 MPH, THE CONTACT FELT A VIBRATION. THE VEHICLE VEERED FROM LEFT TO RIGHT, THE TREAD SEPARATED, AND THE REAR PASSENGER SIDE TIRE BLEW OUT. THE TIRE WAS REPLACED. THE FOLLOWING DAY, WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE VIBRATED AND VEERED FROM LEFT TO RIGHT. THE TREAD SEPARATED AND THE REAR DRIVER SIDE TIRE BLEW OUT. THE TIRE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE VEHICLE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 104,027. THE TIRE FAILURE MILEAGE WAS 95,404. UPDATED 09/10/15*LJ

NHTSA ID

10733638

Incident

Jul 10, 2015

Mileage

104,027 mi

I HAVE A SET OF AUTOGUARD TIRES SIZE 265/78/16 THAT WERE INSTALLED ON MY SUV APX NOVEMBER OF 2013 IN OCTOBER OF 2014 THE TIRES STARTED TO DEVELOPED CRACK ALONG THE BEAD LINE ABOVE THE RIM. THIS IS THE SAME EFFECT OR DEFECT THAT RESULTED IN THE RECALL OF AUTOGUARD TIRE SIZE 245/75/16. BOTH THE TIRE THAT WERE THE SUBJECT OF THE RECALL AS WELL AS THE TIRES THAT WERE INSTALL ON MY SUV WERE MANUFACTURES IN THE SAME TIME PERIOD AND I BELIEVE HAVE THE SAME DOT NO OF 4412. *TR

NHTSA ID

10652499

Incident

Oct 13, 2014

Mileage

242,000 mi

TL* THE CONTACT OWNS A 2000 FORD EXCURSION EQUIPPED WITH FIRESTONE TIRES, TIRE LINE: STEEL TEX RADIAL A/T, TIRE SIZE: LT 265/75R16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH ON A DIRT ROAD, THE REAR DRIVER'S SIDE TIRE EXPLODED. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND DISCOVERED THAT THE TREAD WAS SEPARATED FROM THE TIRE. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000 AND THE TIRE FAILURE MILEAGE WAS 200. THE DOT NUMBER WAS VNW81XL049. DJR

NHTSA ID

10617226

Incident

Jul 22, 2014

Mileage

190,000 mi

A GOODYEAR TREVA LT245/75R16 WITH 1000 MILES ON IT HAS SUFFERED SEPARATION OF THE RUBBER NEAR THE BEAD. THE INTERNAL TIRE CONSTITUENTS ARE VISIBLE. THE DEFECT RUNS (ON THE OUTSIDE OF THE TIRE) ABOUT 8" AND THE DELAMINATION GAP IS ABOUT 1/4". THE INSIDE OF THE WHEEL DEFECT IS 1" LONG AND 1/8" GAP. PICTURES OF HE DEFECT ARE AVAILABLE. NO ACCIDENT OR VEHICLE DAMAGE HAS OCCURRED. DEALER WAS NOT RESPONSIVE TO REMEDIATION ALTHOUGH ITS BEEN REPORTED THAT GOODYEAR LOAD RANGE E LIGHT TRUCK TIRES HAVE HAD MANY "SILENT RECALLS". *TR

NHTSA ID

10376773

Incident

Jan 15, 2011

Mileage

240,000 mi

TL* THE CONTACT OWNS A 2000 FORD EXCURSION. THE VEHICLE HAS COOPER DOMINATOR SPORT A/T TIRES, LINE SIZE LT265/75/R16, DOT NUMBER UPW8XDJ3007. THE CONTACT STATED WHEN DRIVING AT SPEEDS OF 25 MPH AND OVER, THE STEERING WHEEL WOULD BECOME EXTREMELY WOBBLY. THE FAILURE PERSISTED AND BECAME PROGRESSIVELY WORSE OVER TIME. THE TIRES WERE TAKEN TO A TIRE SPECIALIST AND THE MECHANIC ADVISED THE TIRES EXHIBITED EXCESSIVE TREAD SEPARATION. ONE OF THE FRONT TIRES EXHIBITED VISIBLE TREAD SEPARATION AND WAS REPLACED AT THE MANUFACTURER'S EXPENSE. THE REMAINING THREE TIRES WOULD BE REPLACED AT THE CONTACT'S EXPENSE. THE CONTACT WAS ABLE TO LOCATE A RECALL FOR HIS BRAND AND LINE OF TIRES HOWEVER, THE RECALL DID NOT COVER HIS SPECIFIC TIRE SIZE (NHTSA CAMPAIGN ID NUMBER: 06T016000: TIRES: TREAD/BELT). THE REMAINING FOUR TIRES WERE NOT YET REPLACED. THE TIRES WERE PURCHASED IN 2008 AND THE TIRE FAILURE MILEAGE WAS 27,000. THE CURRENT AND FAILURE MILEAGE OF THE VEHICLE WAS 136,000.

NHTSA ID

10343067

Incident

Jun 20, 2010

Mileage

27,000 mi

MASTERCRAFT TIRE LT265/75R SEPARATION AND FAILURE RESULTING IN PROPERTY DAMAGE AND TEMPORARY LOSS OF CONTROL. THIS TIRE WAS THE SECOND TO FAIL. THE FIRST FAILED AND WAS REMOVED BEFORE TOTAL FAILURE. THE 2ND TIRE THAT FAILED WAS INSPECTED 10 MILES BEFORE TOTAL FAILURE. TWO OF THE 4 MASTERCRAFT TIRES FAILED WHILE OPERATING AT CORRECT PRESSURES AND LOADS WITH SPEEDS UNDER 60MPH. *TR

NHTSA ID

10331519

Incident

May 15, 2010

Mileage

155,000 mi

THIS COMPLAINT CONCERNS GOODYEAR A/T TIRES ON A 2000 FORD EXCURSION. WHILE RIDING IN THE VEHICLE ON 7/14/09, THE VEHICLE BEGAN TO VIBRATE. THERE WAS A HUGE IMPACT ON THE RIGHT SIDE REAR QUARTER PANEL. THE TREAD HAD SEPARATED FROM THE TIRE CAUSING EXTENSIVE DAMAGE TO THE RIGHT REAR QUARTER PANEL. NO ACCIDENT OR INJURY RESULTED. *TR

NHTSA ID

10276730

Incident

Jul 14, 2009

Mileage

130,000 mi

2000 FORD EXCURSION HAD CRACKS IN THE SIDEWALLS OF ALL FOUR TIRES. *KB THE CRACKS WERE 2-3 INCHES LONG AND IN MULTIPLE SPOTS ON ALL FOUR TIRES. *NM

NHTSA ID

10163676

Incident

Jul 1, 2005

WHILE TRAVELING SOUTH IN THE OUTSIDE LANE OF INTERSTATE 380 AT APPROXIMATELY 1:00 P.M. CDT ON SATURDAY, MAY 20, 2006, 1/2 MILE NORTH OF MILE MARKER 29, THE LEFT FRONT TIRE OF MY 2000 FORD EXCURSION LIMITED SUFFERED A CATASTROPHIC FAILURE DUE TO TREAD SEPARATION. THE TIRE WAS A FIRESTONE STEELTEX R4S LT265/75R16D, SERIAL NUMBER 31350 EX BM20118-4. TIRE IS IN THE CUSTODY OF CERNY & IVEY ENGINEERING, ATTN: MR. STEVE SMITH, 5650 PEACHTREE PARKWAY, NORCROSS, GA 30092. CERNY & IVEY ANALYZED THE TIRE AND HAVE DETERMINED THAT THE TIRE FAILED DUE TO A MANUFACTURING DEFECT THAT HAD WORSENED OVER TIME UNTIL THE TIRE FAILED. ACCIDENT REPORT IS ON FILE WITH THE LINN COUNTY SHERIFF'S OFFICE; REPORT NUMBER 06-13921. *NM

NHTSA ID

10161765

Incident

May 20, 2006

Mileage

78,898 mi

DT*: THE CONTACT STATED THAT ALL FOUR OF THE TIRE SIDEWALLS ARE SPLITTING. THE TIRES ARE THE ORIGINAL TIRES THAT THE VEHICLE WAS PURCHASED WITH. THE TIRES PRESSURE HAS BEEN KEPT AT THE RECOMMENDED LEVELS. THE TIRES WERE REGULARLY SERVICED, ROTATED AND HAD THE PRESSURE CHECKED ON THEM. THERE HAS BEEN NO VIBRATION WHILE DRIVING AND NO ABNORMAL BULGING. THE CONTACT HAS PICTURES OF SIDE WALL SPLITTING AVAILABLE UPON REQUEST. A REPRESENTATIVE OF THE FIRESTONE COMPANY CONTACTED THE CONSUMER AND INFORMED HIM THAT THE PROBLEM WAS USUALLY CAUSED BY UNDER INFLATED OR OVER LOADED TIRES. THE REPRESENTATIVE ALSO STATED THAT FORD RECOMMEND PSI WAS 35. THE CONSUMER STATED HE HAS ALWAYS KEPT 65 PSI IN THE TIRES AS STAMPED ON THE SIDEWALL OF THE TIRES. IT WAS ALSO STATED THAT THE VEHICLE SHOULD HAVE LOAD E RANGE TIRES INSTEAD OF D LOAD RANGE. UPDATED 07/07/06. *JB

NHTSA ID

10160394

Incident

Jun 1, 2005

Mileage

34,000 mi

DT*: THE CONTACT STATED WHILE DRIVING 70 MPH ON DRY ROADS THE TWO DRIVER'S SIDE TIRES BLEW OUT WITHIN TWO HOURS OF ONE ANOTHER. THERE WERE NO WARNING SIGNALS PRIOR TO THE INCIDENT. UPON INSPECTION OF THE OTHER TIRES THE CONTACT NOTICED TIRES OVER INFLATED AND BULGED. WHEN A SERVICE DEALER WAS CONSULTED, THEY WERE UNABLE TO PROVIDE ASSISTANCE. THE VEHICLE MANUFACTURER WAS ALSO CONTACTED, AND THEY WERE UNABLE TO PROVIDE ASSISTANCE. WHEN THE TIRE MANUFACTURER WAS CONTACTED THEY DETERMINED THOSE WERE THE WRONG TIRES FOR THIS TYPE OF TRUCK. UPDATED 05/16/2006. *AK *NM

NHTSA ID

10152115

Incident

Feb 11, 2006

Mileage

57,500 mi

WHILE DRIVING MY FORD EXCURSION, THE DRIVER SIDE REAR TIRE, A FIRESTONE STEELTEX R4S, SUFFERED A TREAD SEPARATION. AS A RESULT OF THE SEPARATION, THE VEHICLE ROLLED OVER. *JB

NHTSA ID

10147618

Incident

Aug 26, 2005

FIRESTONE STEELTEX TIRE FAILURE X2. *JB

NHTSA ID

10134794

Incident

May 7, 2004

Mileage

68 mi

TRAVELING ON INTERSTATE 75 IN FLORIDA WHEN THE TREAD SEPERATED FROM THE DRIVERS SIDE REAR TIRE ON MY 2000 EXCURSION. THIS CAUSED THE VEHICLE TO SKID ON THE HIGHWAY, BUT I WAS ABLE TO MAINTAIN CONTROL AND DID NOT CRASH. DAMAGED WAS CAUSED TO THE VEHICLE FROM THE TREAD HITTING THE SIDE AND REAR OF THE VEHICLE.

NHTSA ID

10128949

Incident

Apr 4, 2005

Mileage

47,689 mi

CONSUMER COMPLAINT REGARDING REFUND REIMBURSEMENT FOR STEELTEX RADIAL TIRE RECALL.***NO ANSWER REQUIRED*** *MR *SC *JB

NHTSA ID

10121587

Incident

May 1, 2005

TRAVELING NORTH IN LIGHT RAIN ON IH 55 AT BROOKHAVEN, MS ON SUNDAY AFTERNOON, MARCH 20, 2005. I EXPERIENCED A SUDDEN FAILURE OF A FIRESTONE STEELTEX R4S RADIAL TIRE. LUCKILY IT WAS ON THE REAR OF MY 2000 FORD EXCURSION, AND I WAS ABLE TO GET TO THE SHOULDER QUICKLY AND SAFELY. THE TIRE TREAD HAD SEPARATED FROM THE PLY FOR ABOUT A THIRD OF THE WAY AROUND THE TIRE ON THE INSIDE. THE TIRE HAS 34,000 MILES ON IT. THIS SUDDEN FAILURE IN A SIMILAR MODE AS THE OTHER FIRESTONE FAILURES LEADS ME TO BELIEVE PERHAPS THEY SHOULD BE RECALLED ALSO. THIS TIRE IS AN ORIGINAL TIRE THAT WAS INSTALLED AT THE FACTORY, AND IS A LOAD RANGE D TIRE. MY EXCURSION IS A DIESEL MODEL.*AK

NHTSA ID

10114425

Incident

Mar 20, 2005

Mileage

34,000 mi

SIDEWALL TIRE FAILURE WITH INSTANT RELEASE OF PRESSURE, VEHICLE WAS STATIONARY AT TIME OF FAILURE.*AK

NHTSA ID

10106087

Incident

Nov 18, 2004

I PURCHASED 4 BIG O BIG FOOT AT TIRES IN AUGUST 2003. IN THE FOUR MONTHS BETWEEN JULY 2004 AND NOVEMBER 2004, I EXPERIENCED 3 SEPARATE HIGH-SPEED CATASTROPHIC BLOW OUTS ON 3 OF THE TIRES. IN EACH CASE, I WAS TRAVELING AT HIGHWAY SPEED (65 MPH) WITH MY FAMILY IN THE VEHICLE. THE FIRST WAS ON A WARM SUMMER DAY, THE SECOND WAS ON A MODERATE DAY, THE THIRD WAS AT ABOUT 35 DEGREES. THE FIRST TWO BLOW-OUTS OCCURRED ON THE FRONT PASSENGER SIDE. THE THIRD WAS ON THE REAR DRIVER'S SIDE. AFTER THE REPLACEMENT OF EACH OF THE FIRST TWO TIRES, THE REMAINING THREE WHEELS WERE ROTATED. IN EACH CASE, IT WAS A STUGGLE TO MAINTAIN CONTROL OF THE VEHICLE, BUT IN THE THIRD CASE (REAR TIRE), THE CAR SKIDDED DANGEROUSLY OUT OF CONTROL AS THE REAR END SWAYED BACK AND FORTH. HAD I NOT STEERED INTO THE SKID, I AM CERTAIN THE VEHICLE WOULD HAVE ROLLED OVER. THE BIG O DEALERSHIP REPLACED THE TIRES EACH TIME, BUT INSISTED THAT THE FAILURES COULD ONLY HAVE BEEN CAUSED BY ENCOUNTERING SOME ROAD HAZARD WHICH CAUSED THE TIRES TO DE-PRESSURIZE QUICKLY, HEAT UP AND THEN BLOW. HOWEVER, THREE HIGH-SPEED BLOWOUTS IN FOUR MONTHS INDICATES NOT AN ISOLATED CIRCUMSTANCE OR COINCIDENCE, BUT A DANGEROUS AND POTENTIALLY DEADLY PATTERN.*AK

NHTSA ID

10098843

Incident

Jul 13, 2004

I PURCHASED 4 BIG O BIG FOOT AT TIRES IN AUGUST 2003. IN THE FOUR MONTHS BETWEEN JULY 2004 AND NOVEMBER 2004, I EXPERIENCED 3 SEPARATE HIGH-SPEED CATASTROPHIC BLOW-OUTS ON 3 OF THE TIRES. IN EACH CASE, I WAS TRAVELING AT HIGHWAY SPEED (65 MPH) WITH MY FAMILY IN THE VEHICLE. THE FIRST WAS ON A WARM SUMMER DAY, THE SECOND WAS ON A MODERATE DAY, THE THIRD WAS AT ABOUT 35 DEGREES. THE FIRST TWO BLOW-OUTS OCCURRED ON THE FRONT PASSENGER SIDE. THE THIRD WAS ON THE REAR DRIVER'S SIDE. AFTER THE REPLACEMENT OF EACH OF THE FIRST TWO TIRES, THE REMAINING THREE WHEELS WERE ROTATED. IN EACH CASE, IT WAS A STRUGGLE TO MAINTAIN CONTROL OF THE VEHICLE, BUT IN THE THIRD CASE (REAR TIRE), THE CAR SKIDDED DANGEROUSLY OUT OF CONTROL AS THE REAR END SWAYED BACK AND FORTH. HAD I NOT STEERED INTO THE SKID, I AM CERTAIN THE VEHICLE WOULD HAVE ROLLED OVER. THE BIG O DEALERSHIP REPLACED THE TIRES EACH TIME, BUT INSISTED THAT THE FAILURES COULD ONLY HAVE BEEN CAUSED BY ENCOUNTERING SOME ROAD HAZARD WHICH CAUSED THE TIRES TO DE-PRESSURIZE QUICKLY, HEAT UP AND THEN BLOW. HOWEVER, THREE HIGH-SPEED BLOWOUTS IN FOUR MONTHS INDICATES NOT AN ISOLATED CIRCUMSTANCE OR COINCIDENCE, BUT A DANGEROUS AND POTENTIALLY DEADLY PATTERN. *JB

NHTSA ID

10098834

Incident

Sep 25, 2004

I PURCHASED 4 BIG O BIG FOOT AT TIRES IN AUGUST 2003. IN THE FOUR MONTHS BETWEEN JULY 2004 AND NOVEMBER 2004, I EXPERIENCED 3 SEPARATE HIGH-SPEED CATASTROPHIC BLOW-OUTS ON 3 OF THE TIRES. IN EACH CASE, I WAS TRAVELING AT HIGHWAY SPEED (65 MPH) WITH MY FAMILY IN THE VEHICLE. THE FIRST WAS ON A WARM SUMMER DAY, THE SECOND WAS ON A MODERATE DAY, THE THIRD WAS AT ABOUT 35 DEGREES. THE FIRST TWO BLOW-OUTS OCCURRED ON THE FRONT PASSENGER SIDE. THE THIRD WAS ON THE REAR DRIVER'S SIDE. AFTER THE REPLACEMENT OF EACH OF THE FIRST TWO TIRES, THE REMAINING THREE WHEELS WERE ROTATED. IN EACH CASE, IT WAS A STRUGGLE TO MAINTAIN CONTROL OF THE VEHICLE, BUT IN THE THIRD CASE (REAR TIRE), THE CAR SKIDDED DANGEROUSLY OUT OF CONTROL AS THE REAR END SWAYED BACK AND FORTH. HAD I NOT STEERED INTO THE SKID, I AM CERTAIN THE VEHICLE WOULD HAVE ROLLED OVER. THE BIG O DEALERSHIP REPLACED THE TIRES EACH TIME, BUT INSISTED THAT THE FAILURES COULD ONLY HAVE BEEN CAUSED BY ENCOUNTERING SOME ROAD HAZARD WHICH CAUSED THE TIRES TO DE-PRESSURIZE QUICKLY, HEAT UP AND THEN BLOW. HOWEVER, THREE HIGH-SPEED BLOWOUTS IN FOUR MONTHS INDICATES NOT AN ISOLATED CIRCUMSTANCE OR COINCIDENCE, BUT A DANGEROUS AND POTENTIALLY DEADLY PATTERN. *JB

NHTSA ID

10098833

Incident

Nov 13, 2004

BRIDGESTONE/FIRESTONE TIRE FAILURE, TIRE BLEW FOR NO APPARENT REASON. *BF THE CONSUMER RECEIVED A RECALL NOTICE FOR THE TIRES AND WAS TOLD ALL FOUR OF THE TIRES HAD TO BE REPLACED. THE CONSUMER WAS REASSURED HE WOULD BE REIMBURSED FOR THE TWO TIRES HE HAD PURCHASED. THE CONSUMER RECEIVED ANOTHER NOTICE IN THE MAIL WHICH STATED THEY WOULD NOT BE REIMBURSED FOR THE TIRES HE HAD PURCHASED BECAUSE THE CONSUMER WOULD HAVE NEEDED TO PURCHASE THE TIRES AT AN INDEPENDENT FIRESTONE DEALER. *JB

NHTSA ID

10099941

Incident

Jun 17, 2003

FIRESTONE STEELTEX TIRES EXPERIENCED FAILURE. *BF THE LEFT REAR TIRE EXPLODED. THE CONSUMER DECIDED TO REPLACE ALL THE TIRES. *JB

NHTSA ID

10096880

Incident

Oct 1, 2004

CONSUMER RECEIVED REIMBURSEMENT FOR THE TIRES HE REPLACED. CONSUMER HAD A PROBLEM KEEPING HIS VEHICLE ON THE ROAD.*AK

NHTSA ID

10094809

Incident

Sep 21, 2004