2002 Ford Expedition Tires & wheels Problems

TL* THE CONTACT OWNS A 2002 FORD EXPEDITION. THE CONTACT WAS DRIVING 5 MPH WHEN HE HEARD A NOISE COMING FROM THE VEHICLE.THE CONTACT DISCOVERED THAT THE SPARE TIRE HAD FALLEN AND PARTIALLY DETACHED FROM THE VEHICLE, HANGING BY A CABLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND THEY STATED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE AND THE CURRENT MILEAGE WAS 75,000.

NHTSA ID

10469993

Incident

Aug 3, 2012

Mileage

75,000 mi

IN MARCH 2008, I PURCHASED 4 ADVANTA SUV TIRES P265/70R17 FOR MY VEHICLE, ABOUT 3 MONTHS LATER ONE TIRE HAD AN AIR BUBBLE ON THE SIDE AND I HAD TO REPLACE IT. I DON'T TRAVEL THAT MUCH JUST TO AND FROM WORK. THIS AUGUST 2009, I LET MY MOM USE MY TRUCK AND THE TWO REAR TIRES WENT, ONE BLEW OUT WHILE THE OTHER REAR ONE BEGAN TO SHRED. ON SATURDAY OCTOBER 10 WHILE TRAVELING ON THE HIGHWAY THE FRONT PASSENGER TIRE BLEW OUT. I NOTICED THERE IS A RECALL FOR P265/70R16 AND I NEED TO KNOW WHO I NEED TO CONTACT REGARDING THE TIRES THAT HAVE. THIS IS A VERY SERIOUS AND DANGEROUS SITUATION, MY FAMILY AND I AM ARE VERY BLESSED THAT WE WERE NOT HURT IN THESES INCIDENTS. *TR

NHTSA ID

10287078

Incident

Oct 10, 2009

Mileage

116,332 mi

ON THREE OCCASIONS BETWEEN MARCH 2006 AND MARCH 2009 FOUR OUT OF FIVE TIRES PURCHASED THROUGH SEARS HAVE SUFFERED TREAD SEPARATION AND THREE CASES LEAD TO COMPLETE FAILURE WHILE DRIVING AT POSTED SPEED LIMITS. TIRE FAILURE LEAD TO TWO NEAR MISS ACCIDENTS. IN THE LAST FAILURE, MARCH 22, 2009 LEAD TO SEVERAL THOUSAND DOLLARS OF PROPERTY DAMAGE. ONE TIRE WAS REPLACED SHORTLY AFTER PURCHASE; ANOTHER TIRE ORDERED BUT WAS NOT STOCKED; CURRENTLY IN POSSESSION OF THE MOST RECENT TIRE FAILURE. THE RECENT TIRE HAS GREATER THAN 60% OF TREAD LIFE REMAINING. TIRE SEPARATED YET INNER TUB STILL INFLATED. *TR

NHTSA ID

10262856

Incident

Mar 22, 2009

Mileage

105,000 mi

TIRE DETREADED ON OUR WAY TO SAN ANTONIO FROM EDINBURG RIPPING OFF THE SIDE FENDER AROUND THE TIRE. THE BOTTOM PART OF THE TRUCK CAVED IN. *TR

NHTSA ID

10223683

Incident

Jun 1, 2007

Mileage

67,000 mi

I NOTICED TODAY THAT THE SIDE WALL TIRES ON MY MICHELIN -CROSS TERRIANIN SUV RADIAL X TIRES APPEAR TO HAVE CROSS CUTS IN THE SIDEWALLS ON 3 OF 4 TIRES (ONE WAS RECENTLY REPLACED). ANOTHER THE RUBBER APPEARS TO BREAKING OFF, LEAVING A WHITE COATING BEHIND THE RUBBER. PLAN TO TAKE TO DEALER WHO SOLD ME THE TIRES, BUT AM DOUBTFUL THE WILL ACT. *TR

NHTSA ID

10197032

Incident

Jul 20, 2007

TRAVELING AT HIGHWAY SPEED MY VEHICLE DEVELOPED A DISTINCT VIBRATION SHORTLY FOLLOWED BY A TREAD SEPARATION. WE REDUCED SPEED AND PULLED INTO A SERVICE STATION WHERE THE SPARE WAS INSTALLED. THE SAME SCENARIO TOOK PLACE APPROXIMATELY ONE WEEK LATER WITH A DIFFERENT TIRE. THE VEHICLE IS A 2002 FORD EXPEDITION, PURCHASED NEW IN OCTOBER 2001, AND CURRENTLY HAVING LESS THAN 30,000 MILES ON IT. TIRES (GENERAL GRABBER AW) ARE ORIGINAL EQUIPMENT AND HAVE BEEN ROUTINELY ROTATED AND INSPECTED BY THE DEALER DURING SCHEDULED MAINTENANCE. AFTER THE FIRST INCIDENT, THE SPARE WAS PUT ON--IT, TOO, IS A GENERAL GRABBER AW, SAME AGE AS THE OTHERS--AND A NEW SPARE WAS PURCHASED. THAT SPARE WAS PUT ON AFTER THE SECOND INCIDENT. I HAVE THE TWO DEFECTIVE TIRES. GENERAL TIRE WAS CONTACTED AND THEY WILL NOT REPLACE THE UNSAFE TIRES. *NM

NHTSA ID

10171839

Incident

Oct 6, 2006

I HAVE A 2002 FORD EXPEDITION SUV WITH TIRE PROBLEMS. I HAD A TIRE TREAD DETACHMENT SEPARATION ON A GENERAL GRABBER AW TIRE P275/60R17 ON 2/17/06. THE SAME TIRES THAT ARE ON MY VEHICLE WERE RECALLED FOR YEAR 2000 AND YEAR 2001 FORD EXPEDITION SUVS IN 2002 (REFERENCE NHTSA CAMPAIGN ID NUMBER 02T012000). I HAVE CALLED THE FORD COMPANY AND THEY HAVE TOLD ME THEY COULD NOT DO ANYTHING ABOUT THIS PROBLEM. ALL THE TIRES SEEM TO HAVE A SLIGHT VIBRATION PROBLEM. IT HAS NOT RIDDEN SMOOTHLY SINCE I BOUGHT THE VEHICLE IN 2002. I HAD FORD CHECK IT IN 2002 AND THEY SAID IT JUST HAD VIBRATION DUE TO IT BEING A SUV. THE TIRE VIBRATION BECAME WORSE JUST BEFORE THE TIRE FAILED AND HAD THE TIRE RUBBER DETACHMENT SEPARATION. I WOULD LIKE TO SEE IF YOU CAN HELP ME TO GET FORD TO REPLACE THESE TIRES AND PAY ME FOR THE TIRE THAT FAILED ALSO. THESE TIRES ARE A SAFETY HAZARD. *JB

NHTSA ID

10150685

Incident

Feb 17, 2006

DT: VEHICLE WA SHYDROPLANING; VERY BADLY AT LOW AND HIGH SPEEDS IN THE RAIN . *AK

NHTSA ID

10124584

Incident

Nov 1, 2004

Mileage

69,000 mi

THERE WAS NO ACCIDENT, BUT SUBSTANTIAL DAMAGE TO MY SUV CAUSED BY THE TIRE TREAD SEPARATION AT 65 MPH. THIS PROBLEM IS SIMILAR TO THE CLASS ACTION LAWSUIT SETTLED LAST YEAR BY FORD REGARDING TIRE TRED SEPARATION ON THEIR SUV LINE. MY EXPEDITION HAD A TRED SEPARATION ON THE LEFT FRONT TIRE AT 65 MPH, WHICH CAUSED DAMAGE TO THE BUMPER, WHEEL WELL, AND RUNNING BOARD. THE TIRE WAS STILL PERFECTLY INFLATED, BUT THE ENTIRE TREAD, WHICH IS STILL HARDLY WORN, COMPLETELY SEPARATED FROM THE TIRE, CAUSING THIS DAMAGE. I TALKED TO FORD CUSTOMER SERVICE, AND THEY SAID IT WAS MY RESPONSIBILITY AS IT IS OUT OF THE 36,000 MILE WARANTY. THEY ARE LUCKY MY SUV DIDN T FLIP OVER AND KILL ME, LIKE MANY BEFORE ME WHO HAD THIS SAME PROBLEM. THESE ARE THE ORIGINAL FACTORY TIRES THAT FORD INSTALLED ON MY NEW EXPEDITION. I FEEL THEY ARE RESPONSIBLE FOR REPLACING THE TIRES AND FIXING THE DAMAGE CAUSED BY THEIR DEFECTIVE PRODUCT. I WOULD LIKE FORD TO REPAIR THE DAMAGE TO MY SUV CAUSED BY THEIR DEFECTIVE TIRE. I WOULD ALSO LIKE FORD TO REPLACE THE REMAINING TIRES SO THAT THIS DOESN'T HAPPEN AGAIN.

NHTSA ID

10118063

Incident

Apr 17, 2005

Mileage

52,000 mi

DURING OUR THANKSGIVING HOLIDAY, I WAS TRAVELING AT HIGHWAY SPEEDS WITH MY FAMILY ON MY WAY FROM PHOENIX, AZ TO LAS CRUCES, NM WHEN THE RIGHT REAR GENERAL GRABBER AW P275/60R17 FACTORY INSTALLED TIRE OF MY 2002 FORD EXPEDITION EXPERIENCED TREAD SEPARATION. THERE WAS NO POLICE REPORT NOR WERE THERE ANY INJURIES. THE TIRE DID NOT DEFLATE, BUT IT DID AN ESTIMATED $2,241.47 IN DAMAGE TO MY EXPEDITION WHEN THE TREAD SEPARATED. PLEASE NOTE THAT THE TIRES WERE INFLATED AS RECOMMENDED AS INDICATED ON THE DOOR STICKER. I CHECK THE AIR IN MY TIRES PRIOR TO EACH TRIP AS THE SAFETY OF MY FAMILY MATTERS MOST. THIS RIGHT REAR TIRE WAS INFLATED TO EXACTLY 33 PSI THE DAY BEFORE THE TRIP. I HAVE SUBMITTED A CLAIM TO CONTINENTAL NORTH AMERICA WHO DENY ANY WORKMANSHIP AND/OR MATERIAL FAULT. THEY ONLY WANT TO OFFER $1,000 IN GOODWILL, WHICH WILL NOT COVER THE DAMAGES CAUSED BY THE TIRE TREAD SEPARATION.*AK

NHTSA ID

10104493

Incident

Nov 24, 2004

Mileage

29,216 mi

WHILE DRIVING THE STEERING WHEEL SHOOK AND A LOUD NOISE WAS HEARD COMING FROM THE FRONT. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND PULLED OVER. THE DRIVER'S SIDE TIRE TREAD SEPARATED FROM WHEEL. THE CONSUMER WAS ABLE TO CHANGE THE TIRE, AND DROVE THE VEHICLE TO THE DEALER FOR INSPECTION. GENERAL, CONTINENTAL, P265/7OR17. *AK TWO DEFECTIVE TIRES WERE FOUND. THE TIRE/TREAD. GM STOPPED MAKING THESE TIRES DUE TO PROBLEMS. ANOTHER TIRE MAY BE SEPERATING. *SC

NHTSA ID

10094330

Incident

Sep 24, 2004

Mileage

28,000 mi

WHILE DRIVING,A LOUD NOISE WAS HEARD COMING FROM THE FRONT. CONSUMER PULLED OVER, AND NOTICED THAT THE RIGHT REAR TIRE TREAD SEPARATED FROM THE WHEEL. CONSUMER CHANGEDE THE TIRE. CONTINENTAL , GENERAL, P265/70R17.*AK

NHTSA ID

10097552

Incident

Oct 22, 2004

THE STEERING WAS ERRATIC. THE VEHICLE WAS TAKEN TO A DEALERSHIP, WHO INDICATED THAT 3 OUT OF THE 4 TIRES WERE DEFECTIVE, AND THE BELTS WERE SEPARATING. ALSO, INDICATED THAT THE TIRES WEREN'T COVERED UNDER ANY KIND OF WARRANTY. THERE WAS TREAD SEPARATION RECALL 02T01200 ON THIS ISSUE BUT THE CONSUMER WASN'T NOTIFIED. *AK *SC

NHTSA ID

10087851

Incident

Jul 16, 2004

Mileage

34,800 mi

WHILE DRIVING 35 MPH THE REAR PASSENGER SIDE TIRE TREAD SEPARATED WITHOUT WARNING. PLEASE PROVIDE ADDITIONAL INFORMATION.

NHTSA ID

10094206

Incident

Sep 23, 2004

Mileage

28,000 mi

WHILE DRIVING 70 MPH THE FRONT DRIVER SIDE TIRE TREAD SEPARATED WITHOUT WARNING. AS A RESULT THE VEHICLES BUMPER WAS DAMAGED. THE CONSUMER STATEED THIS IS THE THIRD OCCURRENCE. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB

NHTSA ID

10092443

Incident

Sep 10, 2004

Mileage

49,000 mi

TREADS SEPARATED FROM THE TIRE, WHILE STILL INFLATED AND CAUSED DAMAGE TO REAR FENDER OF FORD EXPEDITION. PREVIOUSLY REPORTED PROBLEM UNDER CLAIM NUMBER 10024727. CONTACTED CONTINENTAL UNDER THE CLAIM AND WAS TOLD MY TIRES DID NOT FALL WITHIN THE RECALL DOT NUMBERS WHICH CONTRADICTED THE INFORMATION PROVIDED BY YOUR AGENCY. THE TIRE DEALERSHIP ALSO TOLD ME THE OTHER TIRES WERE BAD. TIRES ARE BEING SENT TO CONTINENTAL FOR INVESTIGATION.

NHTSA ID

10086727

Incident

Aug 5, 2004

Mileage

42,000 mi

CONTINENTAL TIRE/ GRABBER AW DOT ADT044T4001. WHILE DRIVING ON I10 WITH MY WIFE AND FOUR SMALL SONS, TREAD PEELED AWAY FROM R/R TIRE AND CAUSED $5,900 IN DAMAGE TO R/R FENDER AREA. *LA

NHTSA ID

10051105

Incident

Nov 9, 2003

Mileage

29,700 mi

WHILE DRIVING AT 35 MPH DRIVER FELT VIBRATION IN THE RIGHT REAR OF THE VEHICLE. RECALL 02T0120000. *AK

NHTSA ID

10044824

MY WIFE HAD A TIRE BLOWOUT ON OUR 2002 FORD EXPEDITION . TIRES MOUNTED ON THE VEHICLE WERE THE GENERAL AW GRABBERS 17INCH. WE WERE INFORMED LAST YEAR A COUPLE OF MONTHS AFTER VEHICLE WAS PURCHASED THAT THESE TIRES HAD BEEN RECALLED. WE CONTACTED DEALERSHIP AND TOOK OUR VECHICLE IN TO ANOTHER LOCAL DEALERSHIP, AND THEY SAID NO THEY HAD NOT BEEN RECALLED EVEN AFTER WE INSISTED THEY AT LEAST LOOK AT THE TIRES. MY WIFE AND INFANT CHILD WERE IN THE VECHICLE WHICH CAUSED EXTENSIVE DAMAGE TO THE CAR BUT THANKFULLY ONLY MINOR BUMPS AND BRUISES TO MY FAMILY. WE ARE IN THE PROCESS OF GETTING LEGAL ADVICE AND HAVE TAKEN NUMEROUS PICTURES OF THE TIRE AND HAD OUR OWN TECH EXAMINE THE TIRE.*AK

NHTSA ID

10030306

Incident

Jul 10, 2003

Mileage

21,000 mi

WHILE DRIVING, THE LEFT FRONT TIRE EXPERIENCED A BLOWOUT AT THE SIDEWALL.GENERAL ,GRABBER AW, P275/60R17, DOT- ADT044T4201, AND 24,016 MILES ON ORIGINAL TIRES. *AK

NHTSA ID

10024727

Mileage

24,016 mi

CONTINENTAL TIRES SENT THE CONSUMER A RECALL/REIBURSEMENT FORM IN REFERENCE TO GRABBER TIRE(S), WHICH WERE BOUGHT BETWEEN AUG 19, 2001-OCT 10,2002/ AW P275/80R17/P275/60R17. THE FRONT SEAT BELT ASSEMBLY WAS BROKEN. SCC

NHTSA ID

10003924

THE VEHICLE EXPERIENCED A FLAT TIRE. *JB PH

NHTSA ID

10003994

FAULTY TIRE COMPLAINT. ALL FOUR TIRES WERE AFFECTED. *JG

NHTSA ID

10003854

WHILE DRIVING, THE RIGHT REAR TIRE HAD SPLIT OPEN IN THE SIDEWALL CAUSING THE TIRE TO FLATTEN. TS SCC

NHTSA ID

10002367

Incident

Jan 5, 2002

Mileage

10,800 mi

TIRES HAVE BEEN SEPERATING FOR SOME TIME NOW. ORIGINAL TIRES HAVE BEEN DISCONTINUED AND ARE ON NATIONWIDE BACKORDER. CONTACTED DEALER REPORTED TO BE ORDERED. HAVE BEEN ON ORDER FOR 3 WEEKS NOW. MY HUSBAND HAS FOUND A DIFFERENT BRAND OF TIRES TO FIT THE VEHICLE BUT THE DEALER AND FORD INSIST ON THE EXACT SAME BRAND AND MAKE OF TIRES. THE BRAND IS NO LONGER AVAILABLE. THE RIDE QUALITY ON THE VEHICLE IS BEYOND HORRIBLE, BUT SO FAR NO ACCIDENT HAS OCCURED. WOULD LIKE TO BE REIMBURSED FOR HAVING TO PURCHASE MY OWN TIRES FOR A VEHICLE WITH A WARRANTY.*AKY

NHTSA ID

763798

Incident

Jul 3, 2002