2003 Ford Taurus

On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.

To date, ODI is aware of 2,401 non-duplicative complaints related to the alleged defect. In addition, ODI is aware of 1,411 subject vehicles with one or more warranty claims related to the alleged defect. In total, ODI is aware of 3,645 unique subject vehicles that have experienced one or more front suspension coil spring fractures. ODI is also aware of four minor crashes related to the alleged defect resulting in one minor injury.With greater than eight years of exposure, a large subject vehicle population and approximately 2,052 reported front tire punctures caused by fractured coil springs (at all speeds), there have been no reported severe crashes, deaths or injuries related to the alleged defect. The real world consequences of these defective coil springs have been a small number of minor control problems that resulted in minor damage; suggesting that the effect of the defect on vehicle control is minor.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency will continue to monitor this issue and will take further action if warranted by the circumstances. See the EA08-018 Engineering Analysis Closing Report for more details.

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.

Vehicle was involved in a collision with major front end damage and no airbags deployed. The brakes have been soft or spongy. I have not seen any leaks for the brake issue. I have bled the brakes several times the master was replaced by the original owner.

NHTSA ID

11647520

Incident

Mar 7, 2025

At times the vehicle accelerates by itself albeit I am not touching the gas pedal. While driving the vehicle at 45 mph, I take my foot off of the accelerator and the vehicle maintains the 45 mph speed or increases speed if I am driving down a hill or any downward gradient regardless of the angle of decent. When I try to stop the vehicle using the foot brake it continues to maintain speed and if I put the shift lever in neutral, while trying to stop, the RPM's increase from approximately 1500 rpm's to 3200 rpm's until the vehicle comes to a complete stop, and then, only after approximately five seconds do the RPM's begin to drop to 1000 rpm's. If I am driving the vehicle with cruise control and cancel the cruise control, the vehicle maintains the cruise control speed indefinitely, literally for miles thereafter. I wanted to give this vehicle to my daughter who has multiple sclerosis but it's too dangerous for her to drive with this acceleration problem. Do you have any recommendations for me???

NHTSA ID

11475206

Incident

Jul 21, 2022

The contact owns a 2003 Ford Taurus. The contact stated that when taking the vehicle out of the park(P) after starting the vehicle, which required the brake pedal to be depressed, the contact could not depress the shifter button out of the park. The contact stated that the shift button would not depress. The contact stated no warning light was illuminated. The contact turned the vehicle off and turned the vehicle back on but had to pump the brake pedal to shift the vehicle out of the park. The contact had not taken the vehicle to a local dealer. The vehicle had not been diagnosed or repaired. The contact researched online and determined that the failure was related to NHTSA Campaign Number: 04V106000 (Exterior Lighting). The manufacturer had been informed of the failure. The failure mileage was approximately 151,000.

NHTSA ID

11462647

Incident

Apr 25, 2022

Mileage

151,000 mi

The contact owns a 2003 Ford Taurus. The contact stated that the brake lights failed to actuate as needed. The contact stated that while driving at an undisclosed speed, the vehicle failed to shift out of park(P) into gear. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed that the brake light switch or wiring needed to be replaced. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 04V106000 (Exterior Lighting). The manufacturer was notified of the failure but no additional assistance was provided. The approximate failure mileage was 74,000.

NHTSA ID

11460786

Incident

Apr 11, 2022

Mileage

74,000 mi

Windshield

NHTSA ID

11459324

Incident

Mar 10, 2022

The contact owns a 2003 Ford Taurus. The contact stated the vehicle failed to release from the park position. The brake warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown. The contact stated the failure was similar to NHTSA Campaign number 04V106000 (Exterior Lighting).

NHTSA ID

11431068

Incident

Jan 1, 2019

TL* THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT STATED THAT WHILE SLOWING DOWN WOULD NOT ACCELERATE WHEN PRESSING THE ACCELERATOR PEDAL AND WHILE SWITCHING GEARS THE VEHICLE WOULD LUNGE FORWARD. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND THE LOCAL DEALER FORSOM LAKE FORD(12755 FOLSOM BLVD, FORSOM LAKE CA.) WAS NOTIFIED OF THE FAILURE BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 175,000.

NHTSA ID

11307742

Incident

Nov 1, 2019

Mileage

175,000 mi

MY INTERIOR LIGHT STAYS ON WHILE I'M DRIVING, AND WILL STAY ON 2-3 HOURS AFTER THE ENGINE HAS STOPPED.

NHTSA ID

11307594

Incident

Jul 27, 2018

Mileage

88,000 mi

This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition

FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPEED CONTROL CABLE IS SUSCEPTIBLE TO DAMAGE AND CAN DISCONNECT DURING HOOD MAINTENANCE AND ALSO INTERFERE WITH FULL THROTTLE RETURN TO IDLE AFTER RELEASING ACCELERATOR PEDAL. MODELS 2000-2003 TAURUS, SABLE. *PE

CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY. *TT

POWER WINDOW CONCERNS - SERVICE TIP. *TT