2025 Kia Seltos

The camber bolts in front struts moved from original location causing uneven tire wear and steering issues. When replacing tires mechanic showed me marks where bolts were originally and where they are now. Mechanic said he has seen multiple of same vehicles with the same issue. Mechanic said most likely poor roads and improperly torque of bolts is causing the issue with this make and model. Caught issue just in time tires were down to threads and wouldn't of lasted much longer. A blowout on a front steer tire would most likely cause an accident or rollover.

NHTSA ID

11752285

Incident

Jul 17, 2026

KiA started a system update while I was driving on a busy road which caused complete loss of engine power and all electrical. This is nuts. What if you’re on the highway driving 70 mph and this happens?

NHTSA ID

11751360

Incident

Jul 19, 2026

While driving at night with the Headlights on Low Beam the light that is projected onto the road is a dull yellowish color, not a bright white color. When the High Beam Lights are turned on there is no difference of the light being projected onto the road. While driving from [XXX] to [XXX] on [XXX] I noticed that I was unable to see or read the Exit Signs for any of the Exit Off Ramps or even the Mileage Signs the show the mileage to the next Towns. When I switched from Low Beam to High Beam it made no difference on Illuminating the Road Signs. When I returned to my home I took the car into the Kia Dealer with the complaint that the Headlights were not working properly. They adjusted the Headlights up higher, so now the Low Beam did Illuminate the Road Signs, but they seemed to High and still had the yellowish color. When the High Beams were turned on it still made no difference in Illuminating the Road. Again I took the car back to the Kia Dealer and they Readjusted the Headlights back to what they said was the Factory Settings. I was then told that if I was not satisfied I could try purchasing some Aftermarket Headlight Bulbs from an Independent Parts Store. This is an Unsafe Condition because I can't see obstructions that may be in the roadway and have enough time to safely maneuver around it. Since this happens at Night the Dealer doesn't have personal to replicate the problem due to the Dealer Service Department is only open during daylight hours. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11744606

Incident

May 21, 2026

The contact owns a 2025 Kia Seltos. The contact stated that while driving in snowy, inclement weather; the entire rear end of the vehicle would become covered in snow. The contact stated snow would become to heavy for the rear windshield wiper which would obstruct his vision while driving in the snow. In addition, the contact stated that the rear tail lights would also become covered in snow which made it difficult for fellow motorist to see his tail lights. The manufacturer was notified of the failure and suggested that the contact purchase an aftermarket spoiler. The contact was also given a case number. The vehicle had yet to be repaired. The failure mileage was approximately 8,000.

NHTSA ID

11740799

Incident

Dec 1, 2025

Mileage

8,000 mi

Instrument cluster does not turn on upon ignition, when in cold weather. this has been a repeating incident, first of which started only 2 months after the purchase. even after 7 separate incidents, and handful dealer visits, car was deemed "okay" because they could not replicate the issue. employees at the dealership have taken pictures and videos but have yet to find a solution to fix this issue, and they further "ask" that if the incident happens again, drive as is so they can see the issue. this is a serious safety issue since nothing is visible including speedometer, rev meter and gas tank indicator, etc. the most recent incident will be dated on the report, but i will attache multiple pictures from different dates as i can recall and recollect.

NHTSA ID

11712544

Incident

Jan 19, 2026

What component or system failed or malfunctioned, and is it available for inspection upon request? The braking system appears to have failed. When I attempted to slow down for a stop sign, the brake pedal went straight to the floor and did not respond as expected. I began pumping the brakes out of panic, but they only engaged at the last moment—approximately one foot or less from the vehicle in front of me. The vehicle is currently totaled, but I believe the braking system could still be inspected upon request, pending insurance and tow yard access. How was your safety or the safety of others put at risk? My safety was significantly at risk. I had no control over stopping the vehicle despite repeated brake attempts. To avoid a direct collision, I was forced to swerve at the last second, hitting the rear edge of the truck ahead and deploying my airbag. Had I not swerved, the impact could have been more severe and potentially endangered the other driver. Has the problem been reproduced or confirmed by a dealer or independent service center? Not yet. My insurance is working to determine whether an inspection is possible due to the extent of the damage. I intend to have the braking system inspected to confirm the failure if it can be safely accessed. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The accident has been reported to my insurance, and they are aware that I believe the brakes failed. I’m waiting to hear whether an inspection by their representatives or a third party will be conducted. To my knowledge, the manufacturer has not inspected the vehicle. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? No brake-related warning lights or messages appeared before or during the failure. However, the forward collision alert did pop up—but it only appeared a couple of seconds before the impact, far too late to help avoid.

NHTSA ID

11673648

Incident

Jul 12, 2025

i get my lane assist and almost wrecked bc it defaulted without warning. when i came up on a car to fast. it didn’t slow down and try to automatically brake.

NHTSA ID

11668451

Incident

May 12, 2025

My Seltos was sitting in my driveway and a crack appeared this morning. It wasn't there two days ago when I last drove it.

NHTSA ID

11649477

Incident

Mar 18, 2025

TECHNICAL SERVICE BULLETIN: INFOTAINMENT SYSTEM SOFTWARE UPDATE USING UPDATE.KIA.COM - This bulletin provides information and service procedures for updating the infotainment systems on applicable Kia vehicles using the Kia Navigation Updater available at update.kia.com. The software update may improve system performance, enhance existing features, and apply the latest operating software for supported vehicles (2021-2026MY All Models).

TECHNICAL SERVICE BULLETIN: SERVICE ACTION: STEERING ANGLE SENSOR CALIBRATION (SA641) - This bulletin provides information regarding the recalibration of the Steering Angle Sensor (SAS) on certain Seltos (SP2 PE) vehicles produced from March 3, 2025, through August 11, 2025. During manufacturing, the SAS in certain vehicles may not have been properly calibrated, resulting in a lower return-to-center feel after completing a turn at low speeds. This does not result in a reduction of steering assist.

PITSTOP: TECHNICAL OPERATIONS: EXTERNAL DAMAGE TO ULTRASONIC SENSOR: This Pitstop provides information related to Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a “Warning Lamp’ to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)

TECHNICAL SERVICE BULLETIN: IBU LOGIC IMPROVEMENT: This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the Integrated Body Control Unit (IBU) software on some 2021-2025MY Seltos (SP2) vehicles produced from November 20, 2019 through January 13. 2025. When the key fob is stored near the vehicle, a signal generated by the IBU for the 'Welcome Function' can cause the key fob battery to become depleted. The ‘Welcome Function' is a convenience feature that activates certain features controlled by the IBU including the puddle lamps (if equipped) when approaching the vehicle with the smart key. By upgrading the IBU software, the ‘Welcome Function' feature prevents the IBU from continuously signaling the key fob after five (5) minutes, improving the key fob battery life.

TECHNICAL SERVICE BULLETIN: IBU LOGIC IMPROVEMENT - This bulletin provides information to upgrade the Integrated Body Control Unit (IBU) software on some 2021-2025MY Seltos (SP2) vehicles produced from November 20, 2019 through January 13. 2025. When the key fob is stored near the vehicle, a signal generated by the IBU for the 'Welcome Function' can cause the key fob battery to become depleted. The ‘Welcome Function' is a convenience feature that activates certain features controlled by the IBU including the puddle lamps (if equipped) when approaching the vehicle with the smart key. By upgrading the IBU software, the ‘Welcome Function' feature prevents the IBU from continuously signaling the key fob after five (5) minutes, improving the key fob battery.

TECHNICAL SERVICE BULLETIN: SERVICE ACTION: OIL CHANGE REMINDER RESETOPERATION LOGIC (SA592) - This bulletin provides information to upgrade the Integrated Control Unit ‘ICU’ software on certain 2024-2025MY Seltos (SP2) vehicles equipped with 1.6L T-GDI GAMMA engines produced from February 14, 2023 through June 29, 2024. The affected vehicles are not equipped with the Oil Change Reminder Reset selection on the Audio Video Navigation ‘AVN’ screen. Some of the affected vehicles may require the ‘AVN’ software to be updated after the ‘ICU’ software upgrade is completed to enable the feature.