2015 Mazda Mazda5

The contact owns a 2015 Mazda Mazda5. The contact stated that while parked with the vehicle occupied, the contact became aware that the rear driver’s and passenger’s side seats were melting. A dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 130,000.

NHTSA ID

11755093

Incident

Feb 15, 2023

Mileage

130,000 mi

The handle on the sliding door and driver's side broke off. We have replaced it twice already and it keeps breaking. This has not happened to me with any of my other cars in the past or present until now. It's unkown to me and it shows the part was not done well. What caught my attention is that I saw another mazda5 minivan without a handle which made me think that this is a problem with this type of car. I'm surprised it doesn't have a recall. Please help us with this. Thank you.

NHTSA ID

11749221

Incident

Dec 2, 2024

Weld failure can cause the board to tip and dump the user on the ground. This is a hazard because this piece of equipment is design for disabled users who can't stand. User found the cracked weld before it broke completely. The board was sagging from horizontal. I notified the manufacturer, then had the part repaired by a local fabricator. I have pictures showing the failure.

NHTSA ID

11528271

Incident

Jun 18, 2023

2015 MADZDA S. CONSUMER WRITES IN REGARDS TO UNINTENDED ACCELERATION. THE CONSUMER STATED WHILE BACKING OUT OF A PARKING SPACE THE VEHICLE SUDDENLY ACCELERATED AND STRUCK ANOTHER VEHICLE.

NHTSA ID

11442831

Incident

Dec 6, 2021

LOSS OF POWER STEERING AT RANDOM TIMES.SRS LIGHT COMES ON AND POWER STEERING LOCKS UP WHILE DRIVING. YOU HAVE TO PULL OVER AND TURN THE CAR OFF AND RESTART IT FOR IT TO WORK AGAIN. IT'S VERY SCARY NOT KNOWING WHEN THIS WILL RANDOMLY HAPPEN AS YOUR DRIVING DOWN THE ROAD. IT COULD CAUSE AN ACCIDENT. I SEE WHERE OLDER MODELS HAVE BEEN RECALLED FOR STEERING BUT NOT NEWER ONES.

NHTSA ID

11352527

Incident

Aug 28, 2020

Mileage

45,000 mi

MY 2015 MAZDA5 WAS INVOLVED IN A SINGLE VEHICLE HIGH SPEED ROLLOVER CRASH WITH 4 KIDS IN IT. THEY WERE ON A DEAD END ROAD THAT RAN PARALLEL TO A DIVIDED HIGHWAY. UPON THE INITIAL IMPACT THE FRONT AIRBAGS DEPLOYED. THE VEHICLE THEN ROLLED SEVERAL TIMES, LANDING DRIVERS SIDE DOWN 150-200 FEET FROM THE INITIAL IMPACT. NEITHER SIDE AIRBAGS DEPLOYED. THE FRONT PASSENGER SEAT WAS VISIBLY TWISTED. ALSO MY SONS SEATBELT CAME UNDONE ON IMPACT, RESULTING IN SEVERAL CRITICAL INJURIES THAT REQUIRED HIM TO BE AIRLIFTED TO A CHILDREN'S TRAUMA CENTER. THE VEHICLE WAS TOTALED. THE WEATHER WAS CLEAR, ROADS DRY AND IT WAS DAYLIGHT, A LITTLE AFTER 5PM.*DT *TR

NHTSA ID

11352072

Incident

Dec 4, 2018

Mileage

115,000 mi

MY VEHICLE WAS RECALL FOR STRUT FAILURE ON THE REAR LIFT GATE. THE RECALL REPAIR WAS COMPLETED MID 2017. RECENTLY THE STRUTS FAILED. THE CARR WAS PARKED IN MY DRIVEWAY WHEN I OPENED THE DOOR AND IT WOULDN'T STAY UP. MAZDA IS UNWILLING TO REPLACE THE DEFECTIVE PARTS (WITHOUT CHARGE) STATING THE PART IS OUT OF WARRANTY. I PURCHASED THIS VEHICLE NEW AND IT CURRENTLY HAS 18,500 MILES IN THE ODOMETER. THIS VEHICLE HAS BEEN GENTLY USED AND THIS PART SHOULD NOT HAVE FAILED SO QUICKLY. IT IS POOR PRACTICE TO REPLACE ONE DEFECTIVE PART WITH ANOTHER DEFECTIVE PART.

NHTSA ID

11191079

Incident

Feb 23, 2019

Mileage

18,500 mi

TL* THE CONTACT OWNS A 2015 MAZDA 5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V393000 (PARKING BRAKE); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. RAMSEY MAZDA OF RAMSEY, NEW JERSEY (436 STATE ROUTE 17) WAS MADE AWARE OF THE RECALL AND STATED THAT THE PARTS WOULD BECOME AVAILABLE IN TWO WEEKS ON MORE THAN ONE OCCASION; HOWEVER, THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11034532

Incident

Aug 23, 2017

This SA supersedes the previously issued SA(s) listed below. The changes are noted in Red. SA-061/25 12/17/25 DESCRIPTION If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...), interview the customer before proceeding with normal MGSS diagnosis by asking if any aftermarket devices have been installed. Aftermarket devices may be the cause of the electrical concern. Below are a few examples of unusual electrical concerns caused by aftermarket devices. Examples: 1. Devices connected to the DLC-2 (battery discharge/DTC stored) 2. Devices plugged into the 12V outlet 3. GPS tracking device (engine no start/battery discharge) 4. Dash cam (DTC stored) 5. Non-certified USB cable (Apple Carplay™/ Android Auto™ will not connect) 6. Over-sized wheels/tires (incorrect GPS location) 7. DTC C0023:14 8. Decorative trim and/or cover on the START/STOP ENGINE button Example 1: Some electrical devices connected to the DLC-2 connector by insurance or mobile phone companies may cause: Battery discharge. The device may disrupt the CAN system battery saver mode. • IDS/MMDS will not communicate with the vehicle due to poor DLC-2 connection. The aftermarket device may cause DLC-2 female terminals to spread open.

This Service Alert supersedes the previously issued SA listed below: The changes are noted in Red. SA-011/24 02/12/24, 06/06/24, 07/29/24 DESCRIPTION Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manual. Services performed outside of Mazda's factory scheduled maintenance are not recommended. These services are unnecessary and create unneeded expenses for your customers. SCHEDULED MAINTENANCE Refer to the applicable Workshop Manual or Owner's Manual for vehicle -specific manufacturer scheduled maintenance. Workshop Manual - Refer to section 00-00 SCHEDULED MAINTENANCE. Owner's Manual - Refer to section 8 Maintenance and Care. b. Note: Please refer to the information below outlining the services not included in Mazda's Factory Scheduled Maintenance: IMPORTANT: Recommending fluid flushes when not necessary can lead to customer confusion and dissatisfaction. Fluid flushing for preventive maintenance purposes is strongly discouraged, unless otherwise specified in a published procedure (Owner’s Manual, Workshop Manual, Technical Service Bulletin, etc.).

If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...), interview the customer before proceeding with normal MGSS diagnosis by asking if any aftermarket devices have been installed. Aftermarket devices may be the cause of the electrical concern. Below are a few examples of unusual electrical concerns caused by aftermarket devices.

A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is caused by condensation, dust, and pollen within the cooling unit. This condition is usually worse during high humidity conditions. “Mazda Air Cooling Coil Coating” is available to encapsulate the mold to reduce odors. If the product is properly applied, it can effectively reduce the musty/mildew odor for up to three years. NOTE: See parts information for Mazda Air Cooling Coil Coating and Kit part numbers.

Some vehicles may experience exterior trim heat damage such (melted, separating, etc.) when parked near a glass building or Low-E windows. This may be caused by the sun's reflection. If a structure's windows create enough of a curve, the concave glass can focus the sun's rays onto a small area and acting like magnifiying glass direct the sunbeams into a hot pinpoint of light. This magnifcation of the sun's rays can cause damage to vehicle trim (see examples). Additional information and exemplar images regarding this phenomenon can be found by performing a google search.

When replacing the SiriusXM satellite radio unit, a call must be made to inform SiriusXM of the existing Radio ID and the new/replacement SAT Radio ID as soon as possible to ensure the customer leaves the dealership with an active SAT radio.