2002 Mercedes-Benz S Class

THE SUBJECT S-CLASS VEHICLES CONTAIN A COMPRESSED AIR SUSPENSION SYSTEM THAT USES AIR STRUTS ON EACH OF THE FOUR WHEELS IN LIEU OF TRADITIONAL SPRINGS AND SHOCK ABSORBERS.THESE AIR STRUTS USE COMPRESSED AIR TO SUPPORT THE WEIGHT OF THE VEHICLE AND CONTROL RIDE HEIGHT.IN THE EVENT OF THE LOSS OF AIR FROM THE SYSTEM, AN ALERT WILL FLASH ON THE INSTRUMENT CLUSTER WARNING THE DRIVER TO EITHER DRIVE CAREFULLY OR TO STOP THE VEHICLE.THE VEHICLE RIDE HEIGHT CAN BE REDUCED BY AS MUCH AS 105 MM BELOW NORMAL RIDE HEIGHT BEFORE THE FULL LOAD OF THE VEHICLE FOR THAT WHEEL COMES TO REST ON A STEEL ROD, WITH A RUBBER STOP ON THE END, LOCATED IN THE SHOCK ABSORBER.THIS REST-STOP CONDITION IS DESIGNED SUCH THAT THERE IS NO IMPACT ON VEHICLE CONTROL.MERCEDES-BENZ (MBUSA) SUPPLIED VIDEO SHOWING A VEHICLE IN THIS CONDITION OPERATING UNDER SEVERAL DIFFERENT SITUATIONS INCLUDING EVASIVE MANEUVERS DEMONSTRATING THE ABILITY OF THE VEHICLE TO BE CONTROLLED EFFECTIVELY WITH A RIDE HEIGHT REDUCED TO THE MINIMUM.ONLY THOSE COMPLAINTS TO ODI AND MBUSA THAT ALLEGED A STEERING INTERFERENCE DURING A REDUCED RIDE HEIGHT CONDITION WERE COUNTED IN THIS RESUME FAILURE REPORT.SOME COMPLAINTS ALLEGED THAT WITH A REDUCED RIDE HEIGHT AND A STOP NOW WARNING MESSAGE THERE WAS A RUBBING NOISE WHEN TURNING, BUT THE ABILITY TO STEER THE VEHICLE WAS NOT COMPROMISED.A SAMPLING OF WARRANTY CLAIMS SUBMITTED BY MBUSA DID NOT REVEAL ANY INDICATING A LOSS OF CONTROL DUE TO AN AIRMATIC SYSTEM FAILURE.THERE WAS ONE CRASH REPORTED BY MBUSA TO ODI BUT THE INFORMATION AVAILABLE INDICATED THAT IT RELATED TO SUSPENSION SYSTEMS AND IT WAS NOT POSSIBLE TO VERIFY THAT THE INCIDENT WAS RELATED TO AN AIRMATIC SYSTEM FAILURE. FURTHER USE OF AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.THIS PRELIMINARY EVALUATION IS CLOSED.

INSTRUMENT CLUSTER FAILURE. ALL LIGHTING FOR INSTRUMENT DARK/UNREADABLE (SPEEDOMETER,TACH,ODOMETER,FUEL,TEMP,TURN SIGNAL ETC). TAKEN TO DEALER AND I PAID FOR REBUILD TO UNIT. IDENTICAL FAILURE OCCURED AGAIN AFTER APPROX 3 MONTHS. *TR

NHTSA ID

10498146

Incident

Aug 1, 2012

Mileage

46,000 mi

THE INSTRUMENT CLUSTER ISSUE I AM EXPERIENCING BEGAN APPROXIMATELY JULY, 2012. INITIALLY, THE DASHBOARD LIGHTS WOULD FLICKER BRIEFLY AND THEN ILLUMINATE AGAIN. SUBSEQUENT TO THE FREQUENT FLICKERING INCIDENTS, THE CLUSTER LIGHTING DIDN'T ILLUMINATE AT ALL, WITH THE EXCEPTION OF THE SMALL DIAGNOSTIC VIEWER. CURRENTLY, ALL LIGHTING, GAUGES, AND ANY DIAGNOSTIC INSTRUMENTS, INCLUDING THE CONTROL BUTTONS LOCATED ON THE STEERING WHEEL DO NOT FUNCTION. IN ADDITION TO THE FOREMENTIONED, THE HEADLIGHTS NOW CONSTANTLY ILLUMINATE AND THE TURN SIGNAL IS COMPLETELY SILENT AND NOT VISIBLE FROM THE INSTRUMENT PANEL. I IMMEDIATELY INQUIRED WITH A CERTIFIED MERCEDES BENZ TECHNICIAN REGARDING THE LIGHTING CLUSTER AND CONTROL ISSUE AND THROUGH THAT INQUIRY WAS MADE AWARE OF THE VEHICLE RECALL RELATED TO THE INSTRUMENT CLUSTER. WITH THAT SAID, I CALLED THE LOCAL MERCEDES BENZ DEALERSHIP SERVICE DEPARTMENT AND PROVIDED THE VIN NUMBER; AND THE SERVICE REPRESENTATIVE REFERRED ME TO MERCEDES BENZ CORPORATE; I PROVIDED THE VIN NUMBER AGAIN, AND WAS THEN TOLD I DIDN'T RESPOND TO THE RECALL NOTIFICATION. THE FACTS ARE CONTRARY TO THAT ASSERTION; BECAUSE IF I HAD RECEIVED THE RECALL NOTIFICATION I WOULD HAVE ACTED UPON THE REQUEST. CURRENTLY THE AUTOMOBILE HAS NO LIGHTS AND CANNOT BE DRIVEN AT NIGHT, NOR AM I AWARE IF THERE IS GASOLINE IN THE AUTOMOBILE. I HAVE CONTACTED MERCEDES BENZ CORPORATION FOR ASSISTANCE, WHO HAVE COMPLETELY EXCUSED THEMSELVES OF THIS VERY SERIOUS PROBLEM. YOUR ASSISTANCE TO THIS VERY IMPORTANT MATTER IS VERY MUCH APPRECIATED. *TR

NHTSA ID

10476954

Incident

Aug 1, 2012

Mileage

130,000 mi

ON STARTING THE VEHICLE, THE INSTRUMENT PANEL WAS BLACK WITHOUT ILLUMINATION OR READING. AS A RESULT, GAUGES TO SPEEDOMETER, ODOMETER, FUEL, WARNINGS TO MALFUNCTIONS, TACHOMETER, OIL PRESSURE, & ENGINE TEMPERATURE ARE NOT PRESENT. *TR

NHTSA ID

10460751

Incident

May 21, 2012

Mileage

103,000 mi

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S-CLASS. THE CONTACT STATED THAT WHILE DRIVING 58 MPH, ALL OF THE INSTRUMENT PANEL LIGHTS AND GAUGES FAILED. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME AND THE DEALER WAS CONTACTED. THE DEALER ADVISED THE CONTACT THAT THERE WAS AN ELECTRONIC MALFUNCTION. THE MANUFACTURER CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 98500.

NHTSA ID

10458150

Incident

May 9, 2012

Mileage

98,500 mi

MY 2002 MERCEDES S430 INSTRUMENT CLUSTER BACK LIGHTING WENT OUT WHILE I WAS DRIVING AND I COULD NOT SEE MY RATE OF SPEED. ALONG WITH NOT SEEING MY RATE OF SPEED MY FUEL AND TEMPERATURE WAS NOT VISABLE. I CALLED MERCEDES DEALER IN VIRGINIA ABOUT THE RECALL THAT CAME OUT IN 2006 AND I WAS TOLD THAT THE RECALL HAD EXPIRED. LOOKING ON THE INTERNET THERE IS A 10 YEAR EXTENSION BUT I WAS TOLD THAT IT WAS FROM THE TIME THE CAR WAS MANUFACTURED. I HAVE NEVER HEARD OF SUCH IN MY LIFE AND I WOULD LIKE TO KNOW THE BOTTOM LINE TRUTH TO THIS SITUATION. *TT

NHTSA ID

10427710

Incident

Sep 26, 2011

Mileage

89,533 mi

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S430. WHILE DRIVING APPROXIMATELY 65 MPH, THE ABC SUSPENSION FAILED AS A RESULT THE VEHICLE AUTOMATICALLY LOWERED IN A DOWNWARD MOTION TOWARDS THE ROAD. THE CONTACT WAS ABLE TO MANEUVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE FUSE LINK, AIRMATIC PUMP RELAY AND AIRMATIC COMPRESSOR WERE REPLACED. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 07V263000 (SUSPENSION). THE VIN WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 71,268.

NHTSA ID

10416475

Incident

Sep 24, 2009

Mileage

71,268 mi

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S55 AMG. THE CONTACT STATED THAT HE WAS UNABLE TO SHIFT THE VEHICLE OUT OF PARK. THE VEHICLE WAS TAKEN TO A LOCAL SHOP WHERE IT WAS DIAGNOSED THAT THE SHIFTER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 118,000.

NHTSA ID

10414720

Incident

Jul 20, 2011

Mileage

118,000 mi

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S55. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH THE ACTIVE BODY CONTROL LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE BEGAN TO DECELERATE. THE SUSPENSION SYSTEM ON THE PASSENGER SIDE OF THE VEHICLE ALSO FAILED, CAUSING THE VEHICLE TO COLLAPSE. AFTER COASTING TO A STOP, THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE SUSPENSION PUMP WAS LEAKING. THE VEHICLE WAS REPAIRED. APPROXIMATELY SIX MONTHS LATER THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 99,000 AND THE CURRENT MILEAGE WAS 101,000.

NHTSA ID

10409218

Incident

Jan 1, 2011

Mileage

99,000 mi

Complaints about poor wiping effect of winshield wiper

MERCEDES: PARKTRONIC INTERMITTENTLY NOT FUNCTIONING. THE FUNCTION WORKS AGAIN AFTER A SHORT TIME OR DISTANCE. WHEN THE FOOT OPERATED PARKING BRAKE IS APPLIED, THE PARKTRONIC SYSTEM IS DEACTIVATED. IF THE FOOT OPERATED PARKING BRAKE IS ON AT THE FIRST NOTCH, THE CONTACT SWITCH MAY REACT WITH A CONSIDERATION DELAY WHEN THE PARKING BRAKE IS RELEASED. NO MODEL YEARS LISTED. *PE

MERCEDES: CORROSION PROTECTION COATINGS FOR BRAKE COMPONENTS AND HARDWARE MAY BE DAMAGED AND OR STRIPPED AWAY IF HIGHLY CONCENTRATED ACID BASED CLEANERS ARE USED. ONCE THE CORROSION PROTECTION IS DAMAGED OR REMOVED THE BRAKE COMPONENTS AND OR HARDWARE CAN BEGIN TO CORRODE. INCLUDE ALL MODELS AND MODEL YEARS. *PE

MERCEDES BENZ: WATER IN TAIL LAMP HOUSING ON EITHER RIGHT SIDE OR LEFT SIDE. *PE

INSTRUMENT CLUSTER SHOWS DASHES INSTEAD OF MAIN ODOMETER READING. *TT

SEAL BETWEEN EXTERIOR REAR VIEW MIRROR HOUSING AND DOOR. *TT