2000 Mercedes-Benz S Class

THE SUBJECT S-CLASS VEHICLES CONTAIN A COMPRESSED AIR SUSPENSION SYSTEM THAT USES AIR STRUTS ON EACH OF THE FOUR WHEELS IN LIEU OF TRADITIONAL SPRINGS AND SHOCK ABSORBERS.THESE AIR STRUTS USE COMPRESSED AIR TO SUPPORT THE WEIGHT OF THE VEHICLE AND CONTROL RIDE HEIGHT.IN THE EVENT OF THE LOSS OF AIR FROM THE SYSTEM, AN ALERT WILL FLASH ON THE INSTRUMENT CLUSTER WARNING THE DRIVER TO EITHER DRIVE CAREFULLY OR TO STOP THE VEHICLE.THE VEHICLE RIDE HEIGHT CAN BE REDUCED BY AS MUCH AS 105 MM BELOW NORMAL RIDE HEIGHT BEFORE THE FULL LOAD OF THE VEHICLE FOR THAT WHEEL COMES TO REST ON A STEEL ROD, WITH A RUBBER STOP ON THE END, LOCATED IN THE SHOCK ABSORBER.THIS REST-STOP CONDITION IS DESIGNED SUCH THAT THERE IS NO IMPACT ON VEHICLE CONTROL.MERCEDES-BENZ (MBUSA) SUPPLIED VIDEO SHOWING A VEHICLE IN THIS CONDITION OPERATING UNDER SEVERAL DIFFERENT SITUATIONS INCLUDING EVASIVE MANEUVERS DEMONSTRATING THE ABILITY OF THE VEHICLE TO BE CONTROLLED EFFECTIVELY WITH A RIDE HEIGHT REDUCED TO THE MINIMUM.ONLY THOSE COMPLAINTS TO ODI AND MBUSA THAT ALLEGED A STEERING INTERFERENCE DURING A REDUCED RIDE HEIGHT CONDITION WERE COUNTED IN THIS RESUME FAILURE REPORT.SOME COMPLAINTS ALLEGED THAT WITH A REDUCED RIDE HEIGHT AND A STOP NOW WARNING MESSAGE THERE WAS A RUBBING NOISE WHEN TURNING, BUT THE ABILITY TO STEER THE VEHICLE WAS NOT COMPROMISED.A SAMPLING OF WARRANTY CLAIMS SUBMITTED BY MBUSA DID NOT REVEAL ANY INDICATING A LOSS OF CONTROL DUE TO AN AIRMATIC SYSTEM FAILURE.THERE WAS ONE CRASH REPORTED BY MBUSA TO ODI BUT THE INFORMATION AVAILABLE INDICATED THAT IT RELATED TO SUSPENSION SYSTEMS AND IT WAS NOT POSSIBLE TO VERIFY THAT THE INCIDENT WAS RELATED TO AN AIRMATIC SYSTEM FAILURE. FURTHER USE OF AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.THIS PRELIMINARY EVALUATION IS CLOSED.

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION BASED ON SEVEN REPORTS INDICATING THAT THE INSTRUMENT CLUSTERS IN MODEL YEAR (MY) 2000-2001 MERCEDES-BENZ S CLASS VEHICLES FAILED IN THAT CONSUMERS WERE UNABLE TO READ ANY OF THE GAUGES WHILE OPERATING THEIR VEHICLES AT ANY SPEED DURING THE DAY OR NIGHT.IN ITS 573 REPORT TO NHTSA DATED FEBRUARY 1, 2006, MERCEDES-BENZ USA, LLC (MERCEDES-BENZ)STATES THAT THERE ARE THREE INSTRUMENT CLUSTER FAILURE MODES THAT WOULD RESULT IN UNDESIRABLE OPERATION.THESE THREE FAILURE MODES ARE SPECIFIC TO CERTAIN DATES OF PRODUCTION (SEE BELOW) FOR THE SUBJECT VEHICLE, AND MERCEDES-BENZ IS RECALLING THOSE VEHICLES WITHIN THOSE DATES.SPECIFIC INFORMATION REGARDING THE FAILURE MODES IS DESCRIBED IN MERCEDES-BENZ'S REPORT (SEE NHTSA RECALL 06V028).THREE OF THE ODI COMPLAINTS SUBMITTED TO MERCEDES-BENZ INVOLVE VEHICLES THAT WERE PRODUCED BEFORE THE DATES OF PRODUCTION OF VEHICLES AFFECTED BY THE THREE FAILURE MODES.BASED ON REVIEW OF THOSE THREE COMPLAINTS, MERCEDES-BENZ WAS UNABLE TO IDENTIFY A RELATION OF THOSE THREE TO THE DEFECTS IDENTIFIED IN THE RECALLED VEHICLES.ALL OF THE MERCEDES-BENZ COMPLAINTS WITH VINS IDENTIFIED WERE WITHIN THE RECALL POPULATION (ONLY 2 VEHICLE VINS WERE NOT AVAILABLE TO POSITIVELY IDENTIFY VEHICLE BUILD DATE).THE RECALL POPULATION WILL INCLUDE 36,911 S CLASS AND CL CLASS MERCEDES-BENZ VEHICLES BUILT IN THE PRODUCTION DATES RANGING FROM JUNE 2000 THROUGH NOVEMBER 2000, JANUARY 2002 THROUGH APRIL 2002, AND MAY 2004 THROUGH SEPTEMBER 2004.THESE DATES OF PRODUCTION COVER VEHICLES FROM THE 2000-2002 MY AND THE 2004-2005 MY.TO CORRECT THE CONDITION, MERCEDES-BENZ WILL REPLACE ALL AFFECTED INSTRUMENT CLUSTERS WITH IMPROVED ONES THAT ARE NOT SUBJECT TO THE FAILURE MODES.MERCEDES-BENZ WILL BEGIN OWNER NOTIFICATION DURING THE 1ST QUARTER OF 2006.

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF ENGINE CRANKSHAFT PULLEY HARMONIC BALANCER FAILURE THAT COULD RESULT IN LOSS OF POWER-STEERING ASSIST.ODI HAS RECEIVED A TOTAL OF 546 NON-DUPLICATIVE REPORTS THAT ALLEGE ENGINE CRANKSHAFT PULLEY HARMONIC BALANCER FAILURE ON ALL MERCEDES-BENZ VEHICLES USING THE SUBJECT COMPONENT.THE SUBJECT COMPONENT FAILURES ARE PROGRESSIVE IN NATURE AND ONLY A SMALL PERCENTAGE OF THE COMPLAINTS AND WARRANT CLAIMS INVOLVED A FAILURE THAT HAD PROGRESSED FAR ENOUGH TO EFFECT POWER STEERING PERFORMANCE (6 OF 55 ODI COMPLAINTS REFERENCE INCREASED STEERING EFFORT).THERE HAVE BEEN NO CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.

TL* THE CONTACT OWNS A 2000 MERCEDES S430. WHILE DRIVING 65 MPH, THE CONTACT STATED THE INSTRUMENT PANEL BECAME INOPERABLE AND SHE WAS UNABLE TO SEE HOW FAST OR SLOW SHE WAS TRAVELING, HOW MUCH FUEL WAS IN THE VEHICLE, OR HOW MUCH OIL WAS IN THE VEHICLE DUE TO INADEQUATE ILLUMINATION. THE DEALER ADVISED THE CONTACT THAT HER VEHICLE WAS NOT INCLUDED IN NHTSA RECALL 06V028000 ( INTERIOR LIGHTING) AND ADVISED HER TO REPLACE THE ENTIRE INSTRUMENT CLUSTER. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS WAITING FOR A RESPONSE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WAS 98,000.

NHTSA ID

10420733

Incident

Aug 11, 2011

Mileage

98,000 mi

MY 2000 MERCEDES S500 CLUSTER ,BACK LIGHTING , SPEEDOMETER FAILED (UNABLE TO SEE INSTRUMENT CLUSTER) ON APRIL ,3 2011 MILEAGE AT TIME OF DEFECT 24,568 I SAW THAT THERE IS A RECALL FOR MY CAR CONCERNING THE PROBLEM. I CONTACTED THE DEALER AND , I WAS INFORM THAT THE EXTENDED WARRANTY EXPIRED (RECALL). SO I CALLED THE MERCEDES1-800-367-6372 NUMBER THEY INFORMED ME THE SAME I WAS COVERED BUT EXPIRED. SO I CALLED NHTSA 1800 NUMBER THEY INFORMED ME THAT I WOULD STILL BE COVERED BECAUSE THE RECALL TOOK PLACE IN 2006 AND IT IS 10 YEARS BEFORE IT EXPIRES SO UNTIL 2016. SO I WILL APPRECIATE SOME HELP CONCERNING MY PROBLEM. V.I,N [XXX] NHTSA CAMPAIGN ID NUMBER 06V028000 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10408760

Incident

Apr 3, 2011

Mileage

24,568 mi

MY 2000 MERCEDES S500 CLUSTER BACK LIGHTING IS GOING IN AND OUT ALSO SPEEDOMETER I SAW THAT THERE IS A RECALL FOR MY CAR CONCERNING THE PROBLEM. I CONTACTED THE DEALER AND WENT IN ON MAY 28 TO SEE THEM PENSKE MERCEDES(626) 859-1200 , I WAS INFORM THAT THE EXTENDED WARRANTY EXPIRED (RECALL). SO I CALLED THE MERCEDES1-800-367-6372 ([XXX], CASE MANAGER) NUMBER THEY INFORMED ME THE SAME I WAS COVERED BUT EXPIRED. SO I CALLED NHTSA 1800 NUMBER THEY INFORMED ME THAT I WOULD STILL BE COVERED BECAUSE THE RECALL TOOK PLACE IN 2006 AND IT IS 10 YEARS BEFORE IT EXPIRES SO UNTIL 2016. SO I WILL APPRECIATE SOME HELP CONCERNING MY PROBLEM. V.I,N [XXX] NHTSA CAMPAIGN ID NUMBER 06V028000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

NHTSA ID

10405368

Incident

May 1, 2011

Mileage

137,437 mi

TL* THE CONTACT OWNS A 2000 MERCEDES BENZ S-500. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHEN THE INSTRUMENT PANEL GAUGES BECAME INOPERABLE. THE MANUFACTURER WAS CONTACTED AND STATED THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 06V028000 (INTERIOR LIGHTING) BUT THE CONTACTS VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

NHTSA ID

10396628

Incident

Apr 15, 2011

Mileage

180,000 mi

TL*THE CONTACT OWNS A 2000 MERCEDES BENZ S-500. THE CONTACT NOTICED THE SUSPENSION HAD DROPPED AND WAS NOT POSITIONED NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS STATED THERE WAS A FRONT SUSPENSION KIT THAT NEEDED TO BE INSTALLED. THE REPAIRS WERE PERFORMED YET THE FAILURE RECURRED WITHIN EIGHTEEN MONTHS. THE DEALER WAS CONTACTED AND ADVISED THAT THE FRONT SUSPENSION WOULD NEED TO BE REPLACED IF THE KIT DID NOT REPAIR THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FRONT SUSPENSION WAS REPLACED. THE MANUFACTURER WAS CONTACTED AND STATED THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 07V263000 ( SUSPENSION) BUT THE CONTACTS VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA ID

10396625

Incident

Nov 1, 2007

Mileage

151,661 mi

THE ACCELERATOR PEDAL ON A 2000 MERCEDES BENZ S500 FAILED AND BECAME STUCK TO THE FLOOR CAUSING THE VEHICLE TO REACH SPEED IN EXCESS OF 100M.P.H. BEFORE THE VEHICLE COULD BE SHUT DOWN BY TURNING OFF THE IGNITION. UPON A MECHANICS INSPECTION, IT WAS FOUND THAT THE MECHANICAL SAFETY DEVICE TO PREVENT THE PEDAL FROM BECOMING STUCK HAD FAILED CAUSING THE PEDAL TO GO TO WIDE OPEN THROTTLE AND BECOME STUCK IN THAT POSITION. *TR

NHTSA ID

10381491

Incident

Feb 8, 2011

Mileage

138,000 mi

THIS COMPLAINT IS RELATED TO CAMPAIGN NO 2006080004, SEPTEMEBER 2006 FOR MERCEDES S500 (MODEL 220), MODEL YEAR 2000. THE INSTRUMENT CLUSTER HAS COMPLETELY FAILED WITH COMPLETE LOSS OF ILLUMINATION, SPEEDOMETER, AND FUEL GAUGE. MY CHASSIS END NUMBER IS A123394 AND THIS DOES NOT FALL WITHIN THE NARROW SERIAL NUMBER RANGE WITHIN THE ORIGINAL RECAL CAMPAIGN. I UNDERSTAND ALL PARTS ARE THE SAME AS THOSE RECALLED AND AND REQUESTING THAT THE SERIAL NUMBER RANGE BE WIDENED. *TR

NHTSA ID

10370851

Incident

Dec 10, 2010

Mileage

33,000 mi

TL*THE CONTACT OWNS A 2000 MERCEDES-BENZ S430. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT HEARD A SCRAPING NOISE AND NOTICED THAT THE VEHICLE WAS LOWER TO THE GROUND THAN USUAL. THE CONTACT PULLED OVER AND HAD THE VEHICLE TOWED TO AN AUTHORIZED DEALER. THE CONTACT WAS INFORMED THAT THE AIRMATIC SUSPENSION SYSTEM HAD ALLOWED THE FRAME TO RUB THE TOP OF THE TIRES. THE VEHICLE WAS REPAIRED. THE FAILURE OCCURRED AGAIN FIVE YEARS LATER. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE IT WAS BEING REPAIRED AGAIN. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000 AND THE CURRENT MILEAGE WAS 130,038. THE VIN WAS UNAVAILABLE.

NHTSA ID

10367763

Incident

Nov 24, 2005

Mileage

90,000 mi

Complaints about poor wiping effect of winshield wiper

MERCEDES: PARKTRONIC INTERMITTENTLY NOT FUNCTIONING. THE FUNCTION WORKS AGAIN AFTER A SHORT TIME OR DISTANCE. WHEN THE FOOT OPERATED PARKING BRAKE IS APPLIED, THE PARKTRONIC SYSTEM IS DEACTIVATED. IF THE FOOT OPERATED PARKING BRAKE IS ON AT THE FIRST NOTCH, THE CONTACT SWITCH MAY REACT WITH A CONSIDERATION DELAY WHEN THE PARKING BRAKE IS RELEASED. NO MODEL YEARS LISTED. *PE

MERCEDES: CORROSION PROTECTION COATINGS FOR BRAKE COMPONENTS AND HARDWARE MAY BE DAMAGED AND OR STRIPPED AWAY IF HIGHLY CONCENTRATED ACID BASED CLEANERS ARE USED. ONCE THE CORROSION PROTECTION IS DAMAGED OR REMOVED THE BRAKE COMPONENTS AND OR HARDWARE CAN BEGIN TO CORRODE. INCLUDE ALL MODELS AND MODEL YEARS. *PE

MERCEDES BENZ: WATER IN TAIL LAMP HOUSING ON EITHER RIGHT SIDE OR LEFT SIDE. *PE

SEAL BETWEEN EXTERIOR REAR VIEW MIRROR HOUSING AND DOOR. *TT

THE CATALYTIC CONVERTER SYSTEM MAY BE SUSCEPTIBLE TO IN-USE DAMAGE TO INTERNAL COMPONENTS UNDER CERTAIN CIRCUMSTANCES DUE TO A PRODUCTION DEFICIENCY DURING THE PERIOD WHEN THE VEHICLE WAS MANUFACTURED, RESULTING IN THE MALFUNCTION INDICATOR LAMP ON THE INSTRUMENT CLUSTER WILL ILLUMINATE, OR A READILY RECOGNIZABLE RATTLING NOISE WILL BE HEARD ORIGINATING FROM EITHER THE ENGINE COMPARTMENT OF FROM UNDER THE CAR. (S430, S500 CL500) *TT