2001 Pontiac Bonneville

BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

MY CAR CAUGHT ON FIRE BACK IN JANUARY 2020 UNDER THE HOOD ON MY WAY TO WORK THE FIRE STARTED BEHIND THE VALE COVER GASKETS AND NOW OIL IS LEAKING ON THE MANIFOLD GASKETS AND GAS IS MIXING WITH THE OIL AND I CAN'T DRIVE MY CAR ANYMORE HELP ME PLEASE.

NHTSA ID

11350207

Incident

Jan 5, 2020

Mileage

191,600 mi

TL* THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE VEHICLE LEAKED OIL OUT OF THE VALVE COVER GASKET AND THE SPARK PLUG WIRE RETAINER CAUSING A MISFIRE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED BUT FAILED TO PROPERLY ACCELERATE WHILE DRIVING. THE CONTACT STATED THAT THERE WERE FUMES INSIDE OF THE VEHICLE WHICH CAUSED EYE IRRITATION. THE CONTACT STATED THAT THE TPMS, CHECK ENGINE, SERVICE ENGINE, SEAT BELT, AND AIR BAGS WARNING LIGHTS WERE ILLUMINATED. ADDITIONALLY, AFTER REFUELING, THE FUEL GAUGE FAILED TO PROVIDE AN ACCURATE FUEL READING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE SPARK PLUG RETAINER AND VALVE COVER GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V238000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 264,000.

NHTSA ID

11343664

Incident

Jan 15, 2020

Mileage

264,000 mi

TL* THE CONTACT OWNED A 2001 PONTIAC BONNEVILLE. WHILE DRIVING OUT OF THE DRIVEWAY, THE ENGINE MADE AN ABNORMAL BANGING SOUND AND THE VEHICLE CAUGHT FIRE. THE ENGINE BLEW UP AND PRODUCED A THICK CLOUD OF SMOKE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOTALED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11190448

Incident

Mar 14, 2019

MY SON WAS IN A CAR ACCIDENT AND HIS AIRBAGS DIDN'T DEPLOY.

NHTSA ID

11175875

Incident

Feb 8, 2019

Mileage

178,000 mi

VALVE COVER GASKETS LEAKING OIL CAN GET ON EXHAUST MANIFOLD CAUSING AN ENGINE FIRE.

NHTSA ID

10940205

Incident

Aug 10, 2015

Mileage

94,000 mi

STEEL BRAKE LINES HAVE CORRODED TO THE POINT OF FAILURE. VEHICLE WILL NOT STOP. BRAKE FLUID LEAKS

NHTSA ID

10924920

Incident

May 1, 2016

Mileage

131,000 mi

TL* THE CONTACT OWNED A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE AND EXPLODED WHEN THE IGNITION KEY WAS INSERTED. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10786335

Incident

Nov 27, 2014

Mileage

100,000 mi

I HAD LEFT MY LIGHTS ON AND BATTERY WENT DEAD. WENT TO JUMP THE VEHICLE AND CHARGE THE BATTERY. CABLES CONNECTED CORRECTLY. WHEN I WENT TO START THE VEHICLE, I HEARD A LOUD EXPLOSION NOISE LIKE A BACK FIRE BUT SAW A FLAME THEN SMOKE OUT OF ENGINE. THE ENGINE HOOD WAS CLOSED SINCE THE BATTERY IS LOCATED UNDER THE BACK SEAT OR THIS COULD HAVE BEEN FATAL OR A SERIOUS INJURY. THE FLAME MUST HAVE BEEN EXTINGUISHED BY THE FLUIDS? WHEN WE OPENED THE HOOD AFTER A SHORT PERIOD, WE FOUND THAT THEIR WAS SOME TYPE OF EXPLOSION IN THE ENGINE. THE VEHICLE WAS STATIONARY AND IN MY DRIVEWAY

NHTSA ID

10779022

Incident

Sep 28, 2015

Mileage

150,000 mi

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.