1995 Pontiac Firebird

MOST OF THE REPORTS REVIEWED IN THIS INVESTIGATION ARE FIRE INCIDENTS IN WHICH FUEL LEAKAGE HAS BEEN ALLEGED AS THE CAUSE OR THE AREA OF ORIGIN IS CONSISTENT WITH THE ALLEGED DEFECT.THERE IS NO EVIDENCE THAT THE SUBJECT CLIP WAS A FACTOR IN ANY OF THESE FIRE INCIDENTS AND NHTSA TESTING INDICATES THATBROKEN OR DISLODGED RETENTION CLIP DOES NOT RESULT IN SIGNIFICANT MOVEMENT OF THE FUEL LINE BUNDLE TOWARD THE LEFT SECONDARY AIR INJECTION CHECK VALVE.FAILURE OF THE CLIP PLACES THE FUEL LINE BUNDLE ASSEMBLY IN THE SAME CONFIGURATION AS THE 1993 MODEL YEAR LTI VEHICLES.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

OWNERS HAVE REPORTED FAILURES OF THE FUEL TUBE RETENTION CLIP THAT ATTACHES TO THE PLASTIC THROTTLE LINKAGE COVER.ACCORDING TO GM, THE SUBJECT RETENTION CLIP (P/N 12048089) WAS IMPLEMENTED IN PRODUCTION ON OCTOBER 12, 1993, TO ADDRESS A CONCERN WITH INCORRECT ASSEMBLY PLANT FUEL LINE ROUTING.MIS-ROUTED FUEL TUBES MAY FAIL FROM CONTACT WITH A HOT AIR CHECK VALVE, CREATING A FIRE HAZARD IN THE ENGINE COMPARTMENT.GM MAINTAINS THAT NO PROBLEMS SHOULD OCCUR IF THE CLIP IS PROPERLY INSTALLED AND ISN'T MISHANDLED DURING SUBSEQUENT SERVICE OPERATIONS.SOME OWNERS HAVE ALLEGED TO ODI THAT THE SUBJECT CLIP BECOMES BRITTLE OVER TIME AND MAY ALSO PULL FREE OF THE THROTTLE LINKAGE COVER ATTACHMENT HOLE.

ON MY WAY HOME FROM WORK ABOUT 1 AM,COMING AROUND SOME CURVES, THAT I HAD COME AROUND A HUNDRED TIMES BEFORE, WENT TO CURVE LEFT AND THE CAR STEERED RIGHT, WENT INTO DITCH, HIT A DRIVEWAY CULVERT AND TORE THE TIRE OFF THE RIM AND DESTROYED THE RIM. DIDNT REALIZE ANYTHING MAJOR WAS WRONG TILL I GOT THE TIRE CHANGED AND WENT TO GO HOME, THE CAR WAS PULLING TO THE RIGHT REALLY HARD, GOT IT UP TO THE SHOP AND THEY SAID THE SUBFRAME WAS BENT IN A FEW PLACES. THEY SAID IR WOULD COST ABOUT $1600.00 TO $2000.00 TO FIX IT, WELL I DON'T HAVE THAT KINDA MONEY TO BE ABLE TO DO THAT. SO NOW ITS BEEN SITTING. NOTHING CAN BE DONE AT THIS TIME TO FIX IT AT THIS TIME..I THINK THERE IS SOMETHING WRONG WITH THE STEERING IN THE CAR. *NM

NHTSA ID

10172836

Incident

Jun 9, 2006

Mileage

147,700 mi

THE LEFT SIDE OF THE T-TOP ON THE CONSUMER 1995 PONTIAC FIREBIRD CAME OFF. *TS THE T-TOP STRUCK ANOTHER VEHICLE THAT WAS DRIVING DOWN THE ROAD CAUSING DAMAGE TO THAT VEHICLE'S WINDSHIELD AND ROOF. UPDATED 07/20/06. *JB

NHTSA ID

10163684

Incident

May 21, 2006

1995 PONTIAC FIREBIRD WIRING HARNESS CAUGHT ON FIRE WHILE DRIVING.*MR THE FIRE CAUSED MINOR DAMAGE TO THE VEHICLE. *NM

NHTSA ID

10117803

Incident

Apr 1, 2005

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH BRAKE LIGHT APPEARING ON THE DASHBOARD, AND PEDAL GOING DOWN TO THE FLOOR. *AK

NHTSA ID

10024836

Incident

Jun 24, 2003

CONSUMER STATES THAT WHEN HIT AT 65MPH IN THE FRONT RIGHT OF THE VEHICLE THE AIR BAG DID NOT DEPLOY CAUSING MINOR INJURIES TO THE CONSUMER. DEALER NOTIFIED. TS

NHTSA ID

8022414

Incident

Oct 17, 2002

THE SAFETY RELATED FAILURE INVOLVES AN ELECTRICAL CONNECTOR AT THE FULE PUMP WHICH IS LOCATED IN THE GAS TANK IMMERSED IN GASOLINE. THE CONNECTER WAS ARCHING, OVERHEATED AND MELTED AND FINALLY LOST CONTINUITY WHICH CAUSED THE FUEL PUMP TO NO LONGER OPERATE. THE SAFETY CONCERN IS THAT THIS CONNECTOR WAS DEFECTIVE AND THROUGH ARCHING AND OVERHEATING COULD HAVE RESULTED IN AN EXPLOSION OF THE GAS TANK. SINCE AN ELECTRICAL CONNECTOR DOES NOT MOVE OR WEAR UNDER USE, I BELIEVE THE CONNECTOR WAS DEFECTIVE AND CAUSED A POTENTIALLY DANGEROUS SITUATION. EVEN THOUGH THE CAR IN QUESTION HAS SIGNIFICANT MILEAGE, I DON'T BELIEVE THIS TYPE OF FAILURE SHOULD HAVE OCCURRED. I BELIEVE THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THIS ABNORMAL FAILURE. I WOULD NOT COMPLAIN IF THE FUEL PUMP SIMPLY STOPEED OPERATING DUE TO USE AND WEAR. IN THIS CASE THE FULE PUMP STILL RUNS, BUT I CHOSE TO REPLACE THE PART DUE TO THE BURNED CONDITION AT THE ELECTRIAL CONNECTION. I BELIEVE ARCHING AND ELECTRICAL CONNECTORS MELTING INSIDE A GAS TANK IS UNSAFE. I HAVE RETAINED THE PARTS FOR INSPECTION. WHEN I TOOK THE PARTS FOR INSEPCTION TO THE SERVICE MANAGER AT THE DEALERSHIP, HE BASICALLY IGNORED MY CONCERN.*AK

NHTSA ID

765485

Incident

Jul 16, 2002

WHILE DRIVING 65 MPH VEHICLE SUDDENLY ACCELERATED ON ITS OWN, BRAKE WAS APPLIED, BUT SPEED INCREASED IN EXCESS OF 100 MPH. VEHICLE STARTED TO SLOW DOWN ON ITS OWN. SAME DAY VEHICLE ACCELERATED ON ITS OWN AGAIN, SPUN OUT, AND HIT A TREE. BRAKE WAS APPLIED BOTH TIMES, CRUISE WAS ON BUT NOT SET. DAMAGE TO VEHICLE UNKNOWN, NO INJURIES.*AK

NHTSA ID

8011297

Incident

Jun 4, 2002

CRACKED HEAD AT 65000 MILES? I HAVE SEEN NOW 20 DIFFENT OWNERS POSTED ON WEB SITES WITH THE SAME PROBLEM AT EVEN LOWER MILES....AND GM DOES NOT RESPOND TO COMPLAINTS. *AK

NHTSA ID

760142

Incident

Mar 25, 2002

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.