2022 Tesla Model Y Owner Complaints

On Aug. 9, 2026, my 2022 Tesla Model Y experienced a sudden low-voltage electrical failure that completely immobilized the vehicle. Earlier that morning, the Tesla app sent a push notification indicating low-voltage battery service was needed. I tapped it, but it provided no actionable warning. I immediately checked Maintenance. At 9:06 AM, the app displayed “0 Recommended” and “No maintenance is recommended for your vehicle at this time.” Less than an hour later, the vehicle completely failed. Nothing functioned. We could not open the doors or trunk, access the vehicle normally, or operate vehicle functions. The vehicle could not be put into a condition for normal towing; it would have had to be dragged/pulled onto the tow truck. Tesla later documented “Electrical system is unable to support all features” and is replacing the 12V battery. This may be relevant to NHTSA PE25010.

NHTSA ID

11755995

Incident

Aug 9, 2026

The rear lift gate will not close. Defective hinges and electrical strut causing miss alignment and inability to close.

NHTSA ID

11755986

Incident

Jun 1, 2026

--torn bushings on both the lateral and compliance links --my understand is that torn bushings, if they completely failed, could cause a wheel to lose its rigid control causing the control arm to shift wildly, causing severe steering wander, loud clunking noises over bumps, unstable braking, and rapid, uneven tire wear. In worst-case scenarios, it can lead to a sudden loss of vehicle control and at worst cause an accident --also, this can also cause alignment issues and excessive tire wear--in my case, the torn bushings caused the front tires to chunk --three dealerships, including Tesla, confirmed the issue, including that it likely impacted the alignment and tires --the earliest symptoms were uneven tire wear: 1) all four tires from my first set were chunking and had to be replaced; 2) the front two exhibited the same chunking and have yet to be replaced

NHTSA ID

11755808

Incident

Apr 21, 2026

Tesla released a new version of FSD: 2026.20.6.11 V14 Lite for my 2022 Model Y Long Range. I installed it overnight and the next morning, several systems become intermittent. The backup camera stopped working immediately, and FSD would drop out, with the message "Take control immediately". I would then lose traffic visualization and other advanced features. Eventually the system would recover and start the cycle all over again. Several times per drive. I took the car to the dealer and they diagnosed it as a failed HW3 computer. The cost to repair it was $2,939 out of pocket since my car was 2 months out of warranty. The car was 100% functional before the V14 Lite update. The dealership denied the problem was related to the update, but the internet now has numerous instances of this problem, and attribute it to the computer running much hotter under this new update, causing components to fail. Our update was installed while the car was in our garage at a temperature in the 70’sF and immediately caused the computer failure before the car even left the garage. I requested and was given the failed computer in case any independent investigation is needed

NHTSA ID

11755642

Incident

Jul 22, 2026

I am reporting a serious safety issue involving severe, difficult-to-detect inner-edge tire wear on my Tesla that resulted in a tire failure on Highway 101. The tire failed while I was driving on the highway, creating a dangerous situation and significant traffic disruption. After the failure, I discovered severe wear concentrated on the INSIDE edge of the tire. The concerning part is that the normally visible tread appeared serviceable. An owner can therefore believe the tire is safe while the difficult-to-see inner portion may be dangerously worn. I am concerned that Tesla’s suspension/alignment geometry, including camber/toe settings, vehicle weight, or related components may contribute to excessive inner-edge tire wear. NHTSA should investigate whether this is occurring on other Tesla vehicles and whether owners are being adequately warned to inspect the entire tire, particularly the hidden inner shoulder. I also experienced a very concerning mileage discrepancy. My vehicle showed approximately 36,000 miles before traveling to Tesla for service. During the trip to the dealership, the mileage associated with my vehicle appeared to increase to approximately 56,000 miles. Tesla subsequently referenced the higher mileage in connection with service/maintenance coverage. I request that NHTSA investigate whether Tesla vehicles have a pattern of excessive hidden inner-tire wear capable of causing sudden tire failures; whether suspension, alignment, camber, toe, vehicle weight, or related components contribute to this condition; whether Tesla has received similar complaints; and whether owners are adequately warned about this difficult-to-see wear. I also request review of the approximately 20,000-mile mileage discrepancy and whether the mileage Tesla relied upon accurately represented my vehicle’s actual accumulated mileage. I have video evidence and can provide photographs, Tesla service records, mileage information, and other documentation.

NHTSA ID

11755625

Incident

Aug 14, 2025

The Autopilot/FSD computer (driver-assistance ECU) on my 2021 Model Y (HW3) began failing intermittently on August 2, 2026, days after installing a software update -FSD v14 "Lite" branch. The component is in the vehicle and available for inspection. While driving at highway speed in high ambient temperatures (112–125°F), the system repeatedly disengaged with "Cruise control unavailable" (alert DI_a175) and "System error — take over immediately" warnings, and later alert APP_w46u on FSD engagement. Failures included: FSD and Autosteer aborting within seconds of engagement or disappearing from the menu entirely; complete loss of driving visualizations (no lane lines or vehicle overlays); rear camera blacking out; loss of speed-limit recognition and automatic turn-signal cancel. Both FSD and Autosteer Beta failed identically, indicating the fault is in the shared Autopilot computer/camera pipeline, not one feature. Because the same camera/compute stack supports automatic emergency braking, forward-collision warning, and blind-spot warning, the status of those safety systems during the failures is UNKNOWN — I had to complete long desert highway stretches fully manually, with repeated unrequested hand-backs of control creating a sudden-takeover risk. The fault is thermal-load related and intermittent: it recurred at high ambient temperatures, sometimes recovered after a rest or power-off reset, but on August 4 one full power-off reset at 88°F ambient failed to restore the system (it later self-recovered), suggesting progressive hardware degradation rather than ambient heat alone. Not yet reproduced by a service center: a Tesla service appointment is scheduled for August 13, 2026, and a service request with fault codes was filed in-app while the faults were active so remote diagnostics could capture them. No inspection yet by the manufacturer, police, or insurance. Public owner reports describe similar Autopilot-computer thermal failures on HW3 vehicle

NHTSA ID

11755613

Incident

Aug 2, 2026

During normal driving on roadway the vehicle pulled to the left and driver was not able to steer right to avoid travelling into oncoming traffic and struck another vehicle from opposing traffic. The vehicle gave no notice prior and was not in automatic mode.

NHTSA ID

11755538

Incident

Feb 15, 2026

While operating my 2022 tesla model y, the vehicle suffered a catastrophic hardware failure of the onboard vehicle control computer. This total computer failure resulted in an immediate, sudden loss of electronic power steering assist while the vehicle was in motion. The steering wheel became incredibly stiff and heavy, creating a severe and hazarders driving situation. the vehicle was towed to a tesla service center, where technicians confirmed the onboard computer hardware requires a complete replacement. A vital computer failing prematurely on a 2022 vehicle presents an extreme safety risk of crash or injury due to sudden loss of vehicle control.

NHTSA ID

11755238

Incident

Jul 24, 2026

The bushings on my vehicles front suspension completely failed at 47k miles and required replacement. The vehicle was under warranty and the manufacturer replaced them free of charge, but I'd heard that this component is being investigated. To be clear, the front lower lateral links and compliance arms all had to be replaced.

NHTSA ID

11754585

Incident

Nov 25, 2025

I took my Vehicle to Tesla service for battery not charging. Service did a vehicle inspection and noted the following Concern: Upon Vehicle inspection, Found front suspension control arms worn and at a charge to me repaired with the below notes.. Repair Notes: Correction Links - Lateral - Lower - Front - Pair (Remove & Replace) - Remove and Replace ALSO repaired Correction Links - Compliance - Lower - Front - Pair (Remove and Replace) - Remove and Replace

NHTSA ID

11754565

Incident

Aug 3, 2026

The car started having a lound clicking sound while making a right turn while I exit from my workplace garage. I started driving home and I was on the freeway and suddenly got an alert from the car saying I need a wheel alignment check. I drove slowly and arrived home. When I was making a turn on my drive way to the garage, I again heard a loud clunk and the car front side appears to be elevated and stopped moving. I went out and saw the left front driver's side looks weired and saw a large bolt on the driveway. I immeditely called my neighboor who is a car repair guy and he found out the suspesion is detached. I have attached the bolt that fell out of the suspension. My neighbor fixed but it was ultimately sent to Tesla for a full repair on March 23rd, 2026.

NHTSA ID

11754253

Incident

Mar 9, 2026

I was driving at approximately 30-35 mph on a 30 mph residential road with my son in the front passenger seat. My vehicle unexpectedly collided with a parked, unoccupied car on the right side of the road, impact occurring between my front passenger side and the rear driver side of the parked vehicle. Following the initial collision, the vehicle continued past a small tree, mounted the sidewalk, and struck a second parked car before I was able to manually bring it to a stop 2–3 houses further down near an intersection. Throughout this sequence—with the vehicle traveling at ~35 mph—neither the Automatic Emergency Braking (AEB) activated nor did any airbags deploy. Fortunately, neither my son nor I sustained catastrophic injuries, though my chest struck the steering wheel during the impact, causing ongoing pain my and mental trauma for my son. I am currently receiving medical advise. Given the speed and sequence of impacts, it is terrifying that the vehicle’s primary safety systems failed to engage before, during, or after the collision. I am seeking a thorough technical investigation into why Automatic Emergency Braking and airbag deployment failed in this scenario with Tesla Model Y

NHTSA ID

11754177

Incident

Jul 17, 2026

The contact owns a 2022 Tesla Model Y. The contact stated that while the vehicle was operating in the self-driving feature, the vehicle bumped into a shopping cart holder while attempting to park into a parking space, prompting the contact to take control of the vehicle. The rear bumper on the driver's side was impacted. No property damage was reported. The vehicle came to a complete stop upon impact. No air bag was deployed. There was no warning light illuminated. A Police report was not filed. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 32,074.

NHTSA ID

11754035

Incident

Jul 30, 2023

Mileage

32,074 mi

FSD failed when on FSD to go to local Walmart, in Walmart parking lot while on FSD, vehicle was parking it self by backing up and it hit shopping cart rack. It failed to see physical shopping cart rack and stop and park. It could have hurt someone if someone was there, software and 3 cameras didn’t avoid the accident.

NHTSA ID

11754034

Incident

Jul 30, 2026

I was backing out of my residential driveway when I suddenly noticed the steering wheel required much greater effort than normal, indicating a loss of power steering. There were no prior warning messages or symptoms before this event. As I began driving, multiple warnings appeared on the display, including “Steering Assist Reduced,” “Stability Control Disabled,” “Traction Control Disabled,” and “Vehicle Hold Unavailable.” The steering immediately became extremely heavy, making the vehicle difficult to maneuver safely. Because the failure occurred without warning, I did not feel it was safe to continue driving except to move the vehicle as necessary. The vehicle was subsequently inspected by a Tesla Service Center, which confirmed that the steering rack and Front Vehicle Controller required replacement. The repair was performed by Tesla after diagnosis. I am submitting this report because a sudden loss of steering assist without any prior warning presents a significant safety risk. Although this occurred while pulling out of my driveway, the same failure could occur while a driver is traveling at higher speeds or in traffic, where maintaining control of the vehicle could be much more difficult.

NHTSA ID

11752664

Incident

Jul 20, 2026

As a 100% T&P Disabled Veteran relying on advanced driver-assistance for mobility, I purchased a 2022 Tesla Model Y Performance with Hardware 3 (HW3), which was actively advertised and sold as possessing all necessary hardware for safe, autonomous operation. In practice, the vehicle suffers from safety-critical driver-assist defects—including unexpected disengagements and erratic system choices—due to fundamental HW3 processing and memory bandwidth limitations. Operating a vehicle marketed as autonomy-ready, but constrained by hardware incapable of handling complex traffic scenarios safely, forces constant manual intervention and creates an unacceptable collision hazard for a disabled driver.

NHTSA ID

11752539

Incident

Apr 23, 2026

**Incident Report — Tesla Model Y Safety System Failure** The subject vehicle, a Tesla Model Y equipped with Full Self-Driving (FSD) technology and advanced safety features, was involved in a collision at an estimated impact speed of 40–45 MPH. The vehicle's onboard recording system captured the incident and clearly documents the impact dynamics, vehicle speed at impact, and the contributing actions of the other party involved. **Incident Details:** - **Impact Location:** Left front side of vehicle - **Impact Speed:** 40–45 MPH - **Damage Assessment:** Vehicle declared total loss by insurance - **Recorded Evidence:** Onboard system footage available **Safety System Failures:** Despite the severity of the impact and speed involved, the following safety systems failed to activate: - Emergency braking system did not engage - Forward Collision Warning Failed - Seatbelt pre-tensioning/locking mechanism did not activate - Airbag deployment systems failed (front, side, curtain, and knee airbags) **Concern:** The vehicle's advanced safety features—which are primary design components marketed for collision mitigation—did not function as designed or expected. Given the impact speed and severity, these safety systems should have either mitigated the collision or deployed to protect occupants. The failure of multiple redundant safety systems raises questions regarding the reliability and function of these critical systems at the time of impact. **Available Evidence:** - Onboard system footage (speed, impact angle, timing) - Insurance total loss assessment - Medical records (if applicable) - Vehicle service history

NHTSA ID

11752329

Incident

Jul 8, 2026

The passenger-side (right) headlight assembly suffered an internal mechanical failure and is stuck aimed too high. It cannot be calibrated or lowered to factory specification. This poses a severe safety risk by blinding oncoming traffic at night. The vehicle was inspected by a manufacturer service center on July 13, 2026. The factory technician confirmed in the official service notes that the right-side headlight is 'internally faulty and will not lower the headlight height to specification,' requiring a full assembly replacement. This is the second time this exact OEM component has failed under normal use; the entire assembly was previously replaced for a failure just over two years prior. No external damage, collision, or impact caused this internal mechanism to fail.

NHTSA ID

11750229

Incident

Jul 13, 2026

The contact owns a 2022 Tesla Model Y. The contact stated that while pulling in and out of a driveway, and while coming to a stop or driving from a stop, the vehicle made an abnormal sound that became louder over time. No warning lights illuminated. The vehicle was taken to the service center, where it was diagnosed and determined that the front driver’s and passenger’s side upper control arms had failed. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.

NHTSA ID

11749945

Incident

May 30, 2026

Mileage

50,000 mi

Tesla Y on the freeway, FSD on(Full Self Driving), driving at 70 mph. I saw the cars ahead are slowing but my car was not slowing, so I braked and held the steering wheel firmly. However, my car still hit the car in front at 36 mph. The airbag deployed and luckily I only sprained my thumb in both hands in holding the steering wheel very hard. If I didn't take over my car would have hit the car in front at 70 mph. I downloaded Tesla "Vehicle Data Report" and it shows that the "FSD was active, Cruise Control State was active, Driver Monitoring Detection was detected and I applied the brake. I used FSD for over 3 years and no problem at all, until the accident. The Tesla Data shows that the FSD malfunctioned that caused the accident but my insurance told me that it was my fault and they increased my insurance for $227 a month.

NHTSA ID

11749824

Incident

Jun 11, 2026

The vehicle pulls or "snaps/clicks" when wheel is moved at all speeds while driving manually. It is more prevalent at higher highway speeds. Tesla stated steering gear mechanism may need replacement and it is considered normal wear and tear. There are no alignment, nor wheel, problems. The steering issue has become a hazard on the highway due to the sudden "jerk" reaction from steering wheel input. I am concerned the steering wheel input may become completely unresponsive in the near future when vehicle is being driven. Steering components should be a safety problem and not a typical "wear and tear" component. Car has never been in an accident or incident.

NHTSA ID

11749156

Incident

Apr 20, 2026

"I have a Tesla Model Y that experienced what looks like a steering malfunction, with documented data and repair records already in hand. "While driving our 2024 Tesla Model Y when the steering wheel suddenly turned itself, hard left, and driver couldn't regain control. The car went up a hillside, between a utility/ electricity pole and an electrical box, coming to a stop just inches from the pole. No injury, but real vehicle damage." "I pulled Tesla's own vehicle data log for that exact moment. It shows the steering angle went from +362° to -358° — basically two full wheel rotations — in about 1.5 seconds, while the torque sensor barely registered any force. Then the wheel stayed pinned at full-left lock for about 8 seconds while the car was actively accelerating in Drive." There was a fault code 14 mention in the data file right before the incident. "Tesla told us their review of the data showed 'no malfunction.' But afterward, Tesla's own repair records show they replaced the steering gear assembly and the drive unit — after we complained the steering felt stiff once we got the car back from the first repair."

NHTSA ID

11748516

Incident

Jun 5, 2026

I had gotten the free trial of FSD (full self driving) from Tesla in 2024. I used it with a friend to take us to the zoo. It drove there perfectly with no issues & even backed itself in the parking spot. When time to leave, my friend suggested using the “summon” mode to have the car come to us- it was in view, maybe 10 or so yards away from the curb where we were. I held down the button to summon, the lights turned on & it began making the noise evs make when reversing to alert others that it was on the move. It started slowly creeping out of the spot, maybe a foot or two when it suddenly turned the wheel all the way to the left and accelerated, crashing into the parked car next to it. We were in a bit of a shock, as it was so slow- but it happened so fast? I didn’t even have time to take my finger off the button that made it move/ stop. It did everything in a split second. I have not used the feature since, and when I brought it up to a Tesla engineer they sort of downplayed it & said it was my fault for not properly supervising the vehicle. However, there was really nothing that could have been done in that situation to prevent that. At no point did my friend or I think the vehicle would randomly accelerate into the car next to it, and I would ask how a human would be able to predict that? The more I see incidents of faulty FSD online, the more I believe this incident should be investigated. Thank you for your time If you reach out regarding this case, I know the date of this incident was April 3, 2024 between window of 4-5pm

NHTSA ID

11748286

Incident

Apr 3, 2024

FSD / vision system , no warnings , the vehicle is turning left and right on a straight road sunny conditions. I have a video that it wouldn’t let me attach to the case. I had Tesla service review this and they told me it’s standard behavior, this never occurred before and is dangerous and unusable. Autopilot has an issue that Tesla themself can’t detect and when I get into an accident it’ll Be too late. I’ve been complaining about this for 3 months and Tesla keeps telling me it’s standard behavior, this never happened before the car used to drive straight, brand new tires front and back , blanket and aligned the car drives straight while not in autopilot, issue is directly related to FSD and Tesla autopilot.

NHTSA ID

11747908

Incident

Jul 1, 2026

On Saturday, [XXX] at around [XXX] going west on [XXX] toward [XXX] stopped at the intersection of [XXX]. While driving my 2022 Tesla Model Y, Performance, I was stopped at a red light. When the light turned green and I began accelerating normally through the intersection, both passenger-side doors unexpectedly unlatched at the same time. The windows on both passenger doors lowered slightly, and the vehicle displayed a warning indicating the doors were open and to drive carefully. This created an immediate safety hazard, as the doors opened while the vehicle was in motion without any intentional action from the occupants(there were 0 occupants there). This is the second time this exact issue has occurred under similar circumstances, with the previous incident also happening as I accelerated from a red light. The vehicle should not allow multiple doors to unlatch while driving. I have reported the issue to Tesla for inspection and request that this incident be documented and investigated as a potential safety defect. I was going less that 10 mph when this occurred. Thankfully, my toddler was not sitting in the back seat and there were no passengers in the car. No injuries. No crash. *Unable to upload any photos/screenshots at the moment, but can email or link a drive when need be. This website doesn't support any uploads at the moment. I'm on a Mac using Google Chrome. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11747051

Incident

Jun 27, 2026