1998 Buick Century

GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.

GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.

BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.

INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.

MY VEHICLE'S WINDOW CONTROLS AND LOCK CONTROLS ARE NO LONGER WORKING, WHEN LOCKING THE DOOR OR THE WINDOW WILL GO DOWN BUT WILL NOT COME UP. THE REST OF THE WINDOWS CONTROL THROUGHOUT THE CAR WILL NOT WORK AS WELL. THE LIGHTING IN THE CAR FLICKERS IF YOU WOULD PUSH THE LOT OR THE WINDOW CONTROL. ANTERIOR LIGHT IS NO LONGER WORKING. NONE OF THIS WORKS EVEN WHEN PARKED OR DRIVING DOWN THE ROAD.

NHTSA ID

11385397

Incident

Dec 28, 2020

Mileage

78,000 mi

TL* THE CONTACT OWNED A 1998 BUICK CENTURY. WHILE THE VEHICLE WAS BEING OPERATED, THE BRAKES AND STEERING COLUMN SEIZED. AS A RESULT, THE VEHICLE WAS INVOLVED IN A FRONT END CRASH. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND DEEMED DESTROYED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED SHORT TERM MEMORY LOSS, A CONCUSSION, AND SEVERAL UNKNOWN INJURIES THAT REQUIRED MEDICAL ATTENTION. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBERS: 09E005000 (STEERING) AND 03V527000 (STEERING); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS NOT PROVIDED.

NHTSA ID

10913581

Incident

Sep 29, 2016

MULTIPLE CRACKING ON SIDEWALLS OF 4 MICHELIN HARMONY TIRES BEING USED 3000 MILES A YEAR. TIRES BOUGHT IN 2007 AND HAVE 99% OF TREAD STILL PRESENT ON TIRE. FEEL MICHELIN USED INSUFFICIENT UV/OZONE INHIBITOR CHEMICALS IN RUBBER COMPOUND MANUFACTURING THESE TIRES. TIRES MAY BE UNSAFE AND NOT DUE TO CAR OWNER'S FAULT. FEEL MICHELIN SHOULD REPLACE THESE AT THEIR EXPENSE, NOT MY MOTHER'S EXPENSE. TIRES SHOULD LAST MUCH LONGER THAN 7-8 YEARS AT 3000 MILES A YEAR WHEN 80,000 IS ADVERTISED FOR THESE TIRES.

NHTSA ID

10788884

Incident

Nov 1, 2015

Mileage

60,000 mi

WAS DRIVEN OFF THE ROAD BY ANOTHER VEHICLE I THEN HIT A POTHOLE AT THE SAME TIME MY PASSENGER DASH AIRBAG DEPLOYED. *TR

NHTSA ID

10649055

Incident

Oct 16, 2014

TL* THE CONTACT OWNS A 1998 BUICK CENTURY. THE CONTACT STATED THAT THERE IS NO ALTERNATIVE WAY TO UNLOCK THE TRUNK. THE CONTACT LOCKED THE KEYS IN THE TRUNK OF THE VEHICLE AND WAS UNABLE TO ACCESS THE TRUNK. THE CONTACT HAD TO GO HOME TO RETRIEVE A SPARE SET OF KEYS TO UNLOCK THE TRUNK. THE CONTACT FELT THIS WAS A SAFETY RISK FOR CHILDREN. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10631591

Incident

Sep 8, 2014

TL * THE CONTACT OWNS A 1998 BUICK CENTURY. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG WAS STARTING TO DETACH FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 144,000 AND THE CURRENT MILEAGE WAS 162,000.

NHTSA ID

10597870

Incident

Jul 25, 2013

Mileage

144,000 mi

I FIRST NOTICED THE ENGINE SHUTTING OFF IN JANUARY OF 2014, ESPECIALLY GOING DOWN A HILL. THE ENGINE SHUTS DOWN AT DIFFERENT SPEEDS AND THE AIR BAG LIGHT STAYS ON. AT FIRST I THOUGHT THAT THERE WAS MOISTURE IN MY GAS TANK, BUT AFTER FILLING UP A COUPLE OF TIMES AND PUTTING IN SOME GAS DRYER, THE PROBLEM CONTINUED. I USUALLY SHIFT TO NEUTRAL AND START THE ENGINE WHILE THE CAR IS STILL MOVING. I TOOK MY REMOTE AND OTHER KEYS OFF THE KEY RING. IT STILL SHUTS OFF THE ENGINE WITH JUST ONE KEY IN THE IGNITION SWITCH, BUT NOT AS MUCH. CAN YOU TELL ME HOW I CAN REMEDY THIS PROBLEM WITH MY 1998 BUICK CENTURY? WILL THIS BE AT MY OWN EXPENSE? *TR

NHTSA ID

10567578

Incident

Jan 6, 2014

Mileage

99,285 mi

NO TOP TETHER ANCHOR AVAILABLE FOR CHILD CAR SEAT. GM REFUSES TO RETROFIT AND SAYS THAT THERE IS NO RETROFIT KIT AVAILABLE, EVEN THOUGH THERE WAS A BULLETIN IN MARCH 2012 THAT SAYS THAT THEY WILL RETROFIT ONE FOR FREE. UNABLE TO SAFETY TRANSPORT MY CHILD. *TR

NHTSA ID

10522064

Incident

Jun 25, 2013

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.