1995 Cadillac Eldorado

ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.

THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.

There is no summary currently available

IF A 1995 CADILLAC INTERIOR IS EXPOSED TO SIGNIFICANT WATER INTRUSION, SUCH AS FROM WATER LEAKS, A WINDOW LEFT OPEN IN THE RAIN, OR DRIVING THROUGH HIGH WATER UP TO THE CARPET LEVEL, THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) SYSTEM SENSING AND DIAGNOSTIC MODULE (SDM) CAN BE DAMAGED.IF THIS OCCURS, BOTH THE DRIVER AND PASSENGER AIR BAGS CAN DEPLOY WHEN THE IGNITION SWITCH IS TURNED ON, EVEN IF THERE HAS BEEN NO FRONTAL IMPACT OR CRASH.AS A RESULT OF THESE DEPLOYMENTS, GM CONDUCTED AN ADVISORY LETTER CAMPAIGN, NUMBER 51-01-08 ENTITLED INADVERTENT DEPLOYMENT OF AIR BAGS WHEN INTERIOR EXPOSED TO WET CONDITIONS, IN FEBRUARY 1996.LETTERS TO OWNERS MAILED PURSUANT TO THIS COMPAIGN WARNED OWNERS TO NOT START THEIR ENGINES IF THE VEHICLE INTERIOR HAD BEEN EXPOSED TO SUBSTANTIAL AMOUNTS OF WATER.ODI HAS RECEIVED A TOTAL 8 REPORTS OF INADVERTENT AIR BAG DEPLOYMENT IN 1995 CADILLAC VEHICLES.

TL* THE CONTACT OWNS A 1995 CADILLAC ELDORADO. THE CONTACT STATED THAT THERE WAS A PIN HOLE LEAK IN THE FUEL LINE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR INSIDE THE VEHICLE WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL RETURN LINE WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE CONTACT CALLED THOMSON-MACCONNELL CADILLAC, INC., (2820 GILBERT AVE, CINCINNATI, OH 45206, (513) 334-4239) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE). THE CONTACT WAS NOTIFIED THAT THE PREVIOUS OWNER HAD THE VEHICLE REPAIRED UNDER THE RECALL. THE CONTACT STATED THAT THE RECALL REPAIR INCLUDED REPLACING THE FUEL RETURN LINE HOWEVER, THE FUEL LINE RETURN WAS NOT REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

NHTSA ID

11375419

Incident

Oct 1, 2020

Mileage

120,000 mi

ON JUNE 24, 2017 WHILE DRIVING THROUGH A RESIDENTIAL AREA HEADING TO THE 7/11 STORE, A HOSE UNDER THE DASH BOARD EXPLODED AND DUMPED ANTI-FREEZE INTO THE VEHICLE ONTO MY RIGHT FOOT CAUSING 2ND DEGREE BURNS TO MY FOOT AND TOES.

NHTSA ID

11002938

Incident

Jun 24, 2017

Mileage

127,030 mi

"TAKATA RECALL CAR STARTED TO ALARM FOR NO REASON WHEN I OPENED THE TRUNK WITH THE KEY WITHOUT UNLOCKING DOORS THEN EVENTUALLY ENGINE WOULD CUT OUT IN THE MIDDLE OF DRIVING OR CAR WOULDN'T START ANYMORE BECAUSE OF THE ANTI THEFT SYSTEM DISABLING THE STARTER. IT'S SAID TO BE A KNOWN ISSUE WITH GM VEHICLES SO I'M CURIOUS WHY THERE IS NO RECALL

NHTSA ID

10864965

Incident

May 9, 2016

TL* THE CONTACT OWNS A 1995 CADILLAC ELDORADO. WHILE PARKED, THE CONTACT NOTICED A STRONG FUEL ODOR COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE PLASTIC FUEL LINES WERE NOT REPLACED WITH THE STAINLESS STEEL FUEL LINES. THE GMC DEALER WAS ALSO CONTACTED AND STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE). THE REMEDY FAILED TO CORRECT THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 140,000.

NHTSA ID

10723971

Incident

Jan 1, 2015

Mileage

140,000 mi

AFTER ROUTINE OIL CHANGE, A RAW GASOLINE SMELL WAS DETECTED, INVESTIGATION WITH IGNITION ON, GASOLINE WAS SPRAYING FROM FUEL LINE. *TR

NHTSA ID

10706480

Incident

Apr 18, 2015

Mileage

144,000 mi

TL* THE CONTACT OWNS A 1995 CADILLAC ELDORADO. THE CONTACT STATED THAT THAT FUEL FUMES EMITTED INTO THE VEHICLE AND THE ENGINE FAILED TO START. THE CONTACT NOTICED THAT THERE WAS A PUDDLE LOCATED UNDER THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS. THE TECHNICIAN DIAGNOSED THAT THERE WAS A FUEL LEAK AND THE RETURN LINE WAS FRACTURED. THE VEHICLE WAS REPAIRED. HOWEVER, THE FUEL ODOR PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.

NHTSA ID

10662858

Incident

Oct 1, 2014

Mileage

175,000 mi

TL*THE CONTACT OWNS 1995 CADILLAC ELDORADO. THE SERVICE AIR BAG LIGHT BEGAN ILLUMINATING INTERMITTENTLY. NHTSA CAMPAIGN ID NUMBER: 98V115000, AIR BAGS IS RELATED TO HIS YEAR, MAKE, AND MODEL; HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT IS CONCERNED ABOUT THE SAFETY RISK SINCE THE AIR BAG COULD FAIL TO DEPLOY DURING A CRASH. THE CURRENT MILEAGE WAS 136,000 AND THE FAILURE MILEAGE WAS 134,000.

NHTSA ID

10285684

Incident

Sep 7, 2009

Mileage

134,000 mi

THIS VEHICLE WAS PURCHASED BY ME ON 2006. WHEN I BROUGHT THE CAR, YOU CAN TELL THERE HAD BEEN A FIRE. WHEN I RECEIVED THE RECALL LAST YEAR, IT APPEARED THAT THE FIRE OCCURRED FROM THE ENGINE FUEL RAIL. I AM UNSURE IF THE PREVIOUS OWNER HAD IT CHECKED OUT. IF BY ANY CHANCE THE ENGINE FUEL RAIL HAS NOT BEEN REPLACED AND THE CAUSE OF THE FIRE WAS IN FACT FROM THE FUEL RAIL, IT IS POSSIBLE TO HAVE ALL OTHER COMPONENTS FIXED THAT WAS AFFECTED BY THE FIRE? *TR

NHTSA ID

10264384

Incident

Feb 21, 2004

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.