2023 Chevrolet Blazer

The contact owns a 2023 Chevrolet Blazer. While the vehicle was at a dealer for routine maintenance, the contact was informed that an unknown fluid was leaking from the radiator. The vehicle was less than one year old, and the radiator was replaced under warranty. Two years and two months later, while at the dealer for a module repair, the contact was informed that a second leak was discovered in the replacement radiator. The contact offered customer assistance toward the cost of a second replacement radiator. Upon investigation, the contact discovered that tabs on the radiator caused the leak. During the second radiator replacement, the contact noted that the tabs were removed, whereas the first two radiators were equipped with tabs. The manufacturer was notified of the failure, and a case was filed. The vehicle was repaired. The failure mileage was approximately 23,000.

NHTSA ID

11771395

Incident

Jun 1, 2024

Mileage

23,000 mi

2023 Chevrolet Blazer 42334 miles 9/18/2026 Component failed: 2023 Blazer RS eBoost system. Integrated electronic brake booster / master cylinder / brake pedal sensor assembly. Component available for inspection. Same left front corner had frozen caliper FRC13443C at 37,940 miles June 2025 to pass inspection, sold as certified at 38,038 miles. Vehicle currently 42,334 miles. Safety risk: Hard brake pedal, loss of brake assist, increased stopping distance. Same condition reported before front collision August 2025. Left front remains hot. Driver scared to drive. NHTSA EA26006 open for eBoost 2023 Blazer describes same failure - spindle fracture, loss of ABS/stability, 21 crashes. Reproduced/confirmed: Yes. Independent shop A+ Automotive RO 82780 Sept 15 2026 confirmed hard pedal remains after full bleed, measured 8mm front/rear. Second shop Sept 17 2026 confirmed system is all-wire eBoost, no vacuums, no vacuum leaks possible. Dealer Sept 16-17 2026 stated "checked vacuum on the brakes no leaks" and "pedal fine braking normal" on eBoost vehicle that has no vacuum. Inspected by others: Manufacturer not yet. Dealer inspection 09/16-17/26 misdiagnosed as vacuum issue. Independent inspections A+ Automotive 09/15 and 09/17/26 confirmed eBoost no vacuums and hard pedal remains. Warning lamps/messages: No warning lamps. No ABS light. Symptom is hard pedal that feels like manual brakes without assist. Also left front heat. First appeared June 2025 as frozen left front caliper, returned as hard pedal after bleed. Dealer claimed normal operation.

NHTSA ID

11765159

Incident

Sep 10, 2025

Multiple warning lights on the vehicle stating the ABS brake system was not functioning, the letters brake showed by the gauges but it was not the parking brake because I put that on to check it and it was a different warning light. The lane assist was not functioning. In January I had the brakes looked at because they are squealing anytime you use them. The brake shop I took it to told me this is a known issue and the brakes are fine and that there was no way to stop the squealing because my brakes still had 80% of their pad. On multiple occasions when I’ve need to brake hard quickly the car had felt like it was shaking and the brakes didn’t feel like they were catching. Vehicle is currently at Vandergriff Chevrolet in Arlington Texas and has been there since August 25th.

NHTSA ID

11760523

Incident

Aug 25, 2026

I am reporting a recurring safety issue with the Forward Collision Alert/Automatic Emergency Braking system on my 2023 Chevrolet Blazer 2LT. The vehicle frequently activates the Forward Collision Alert when there is no vehicle, pedestrian, or other obstruction in front of me. The red collision warning will illuminate and the system will beep even when the roadway is clear. More concerning, on three separate occasions the vehicle has unexpectedly applied the brakes extremely hard while I was driving in traffic despite there being no obstacle or imminent collision. The most recent incident occurred on August 11, 2026. I was making a turn through a busy intersection when the Automatic Emergency Braking system suddenly activated and applied the brakes extremely hard. There was no vehicle, pedestrian, or obstruction in my path that would have required emergency braking. The sudden braking occurred while I was in the intersection and created a serious risk of being struck by surrounding traffic. The braking force was severe enough that my seat belt restrained me very hard and caused an injury to my chest and flew me forward into the steering wheel while also risking the vehicle behind me to almost slam into me. This was not an isolated occurrence. This is the third time the vehicle has unexpectedly applied the brakes hard while I was driving in traffic. In addition to these three braking incidents, I have experienced frequent false Forward Collision Alerts where the red warning and audible alert activate when nothing is in front of the vehicle. I am concerned that the Forward Collision Alert/Automatic Emergency Braking system is malfunctioning and could cause a collision by unexpectedly stopping the vehicle in moving traffic. I am requesting that this recurring safety issue be documented and investigated.

NHTSA ID

11756366

Incident

Aug 11, 2026

The vehicle’s radiator developed a coolant leak that was discovered and confirmed by the dealership during a routine oil change, tire rotation and state inspection. There were no warning lights, warning messages prior to the dealership discovering the leak. The radiator required replacement. The dealership also told me that they had the replacement radiator on hand because this type of radiator failure had been occurring fairly often with this type of vehicle. The radiator failure presented a potential safety concern because a coolant leak can worsen without warning and result in a sudden loss of coolant, engine overheating, or vehicle breakdown while driving. Because there were no warning lamps or other symptoms before the leak was discovered, we may not have had any indication that the cooling system was failing. The problem was confirmed by the dealership during inspection, and the dealership determined that the radiator was leaking and needed to be replaced. The vehicle/component was inspected by the dealership. No manufacturer, police, or insurance inspection has occurred, to my knowledge. There were no warning lamps, messages, overheating, or other noticeable symptoms prior to the dealership finding the leak. The vehicle is only three years old, with 39000 miles on it at the time of the failure. I am reporting this because a radiator failure at such a young vehicle age, particularly one that develops without any warning to the driver, could potentially create a safety hazard if the coolant loss becomes severe while the vehicle is being operated. I’ve seen many complaints in online forums that this is an ongoing issue with these radiators used by Chevy. It seems the replacement radiators are having the same issues. Why can’t something be done? Dealership information: #1 Cochran Chevrolet Cranberry [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11754268

Incident

Jul 11, 2026

Odometer Fraud. The contact purchased a 2023 Chevrolet Blazer. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of the purchase the vehicle mileage was 57,692. It was discovered using the Kelley Blue Book/Experian that in 2022 vehicle was listed for sale with mileage of 57,705, and in 2023 same vehicle was listed with 23 miles.

NHTSA ID

11752425

Incident

Jul 23, 2022

Mileage

57,705 mi

"I am the owner of a 2023 Chevrolet Blazer RS. The digital odometer and speedometer screen intermittently crashes and goes completely black for 15 to 20 seconds while the vehicle is in motion on public roads. This creates an immediate safety hazard as I am left with zero knowledge of my current speed. General Motors has acknowledged this specific software stability bug under Technical Service Bulletin 22-NA-023 but refuses to fix the issue due to the vehicle being 9 days past its 3-year calendar warranty, despite having only 32,400 miles." I contacted your GM agent @ 800-222-1020 and was told its out of warranty sorry, that is horrible service espeacially for a safety issue and a 55,000 vechicle that only has 32,400 miles

NHTSA ID

11750847

Incident

Jul 16, 2026

The contact owns a 2023 Chevrolet Blazer. The contact stated that while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to the dealer on several occasions to be repaired; however, the dealer was unable to duplicate the failure or determine the cause of the failure. The contact stated that the dealer performed a transmission fluid flush; however, the failure persisted. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 25,000.

NHTSA ID

11746026

Incident

Aug 1, 2023

Mileage

25,000 mi

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3

PI created to guide technicians through radio restriction process

This Preliminary information communicates an issue with the SES MIL and DTC P062B and engineering is currently investigating.

This preliminary information is for technicians that may see DTCs that are history and should not perform any part replacements. They should follow the notes mentioned prior to anything being replaced.

This Preliminary information communicates to dealers a procedure to reset the radio.

This PI provides Diagnostics tips on how the LIN bus works and how to diagnosis it.