2025 Chevrolet Blazer

The contact owns a 2025 Chevrolet Blazer. The contact stated that the Forward Collision Avoidance system had erroneously activated on several occasions. While driving very slowly, the braking system suddenly activated while leaving a dealer. Additionally, while driving approximately 30 MPH, the braking system erroneously activated, causing the vehicle to abruptly stop. The automatic braking system was turned off, and the vehicle was later driven to the local dealer. The local dealer was unable to determine the cause of the failure and advised to deactivate the Collision Avoidance System. The contact sustained a neck injury during the failure while seated in the driver’s side rear seat. Medical attention was required. The failure mileage was 7,000.

NHTSA ID

11750366

Incident

Feb 3, 2026

Mileage

7,000 mi

I was going to park in a parking lot, when my car suddenly accelerated rapidly crashing into the building.

NHTSA ID

11742623

Incident

Jun 7, 2026

windshield leaking water inside of drivers compartment, headliner & side pillars (causing stained areas) as well as the top of onstar and electrical buttons on the overhead console . Found wet cup holder. Vehicle does not have a sun roof. GM is aware of this issue from the factory GM plant in Ramos Arizpe, Mexico. This defect is because of lack of not being sealed properly during the assembly process. The windshield has a factory OEM rubber seal attached to a NEW windshield. This rubber seal is NOT a part that can be purchased separately to fix the problem. By replacing the entire windshield with the new factory rubber seal and the channel that the entire windshield fits into is resealed with urethane should fix the issue.. Trying to reuse the current windshield & rubber seal and using sealer to reinstall it stretches out the rubber seal & will still leak. This leak can get into the electrical controls for safety system overhead controls. Extra care must be taken to remove the windshield as to not damage the roof line in anyway. Vehicle is going back into dealership to fix issue again. Vehicle was resealed with existing windshield and showing signs of leaking on L&R pillars.

NHTSA ID

11742550

Incident

Apr 21, 2026

Complete and total failure of the telematics module resulting in loss of self driving, onstar, WiFi, gps, and all connected services. Severe battery drain due to module forcing the vehicle to completely shut down while driving, resulting in loss of power steering and brakes.

NHTSA ID

11740454

Incident

May 27, 2026

Just purchased a used 2025 RS EV on 5/2/2026. When I got home I found out the Google maps and on star app wasn't working. Called on star and they can't connect to the car and that the telematics module is probably bad. Checked my Chevrolet app and it reports that it hasn't connected to the car for over 6 months. Now waiting for replacement part going 3 weeks now. A little pissed off that dealer did find before they sold me the car.

NHTSA ID

11739423

Incident

May 3, 2026

The Telematics Module failed and is on backorder. This is a known issue across the U.S. This makes it so OnStar doesn't work and I am paying for it. Not just that the safety concern of it not working. GPS, Maps, Level 3 Tesla doesn't work. Car is really not usable as we can't charge on a level 3 when going over 100 miles. We have loss access to navigation, Google Built-In services, the myChevrolet apps, and even core safety and convenience features tied to connectivity, including OnStar and Super Cruise.

NHTSA ID

11738977

Incident

May 3, 2026

2025 Chevrolet Blazer EV AWD purchased 5/23/25 (under 3,100 miles) The vehicle's Telematics Control Module (TCM) has failed, disabling the built-in navigation system, OnStar services, remote start, and My Chevrolet app connectivity. The dealership confirmed the TCM needs replacement and the part is on backorder with no ETA. This is a known issue affecting this model. I am reporting this as a safety defect for the following reasons: The 2025 Blazer EV does not support Apple CarPlay or Android Auto. With the built-in navigation disabled, the only way to navigate is by using a phone, which requires visual attention to a separate small screen while driving. Under Pennsylvania's hands-free law (75 Pa.C.S.A. § 3316.1), use of handheld devices while driving is a primary offense, making phone-based navigation both unsafe and legally problematic. On at least one occasion, the navigation system appeared to be functioning normally at the start of a trip but was providing materially inaccurate directions mid-route (e.g., instructing me to turn onto a road I had already been traveling on for miles). A system that displays as operational while delivering incorrect routing data is dangerous because the driver has no way to assess its reliability before departing. GM's EV Concierge characterized the loss of navigation as a non-safety feature issue and suggested using a phone holder. This response is inadequate given the vehicle's lack of CarPlay integration, which makes the built-in navigation the only safe, integrated means of route guidance. This vehicle has also required three prior unrelated warranty repairs in 10 months: a recall for a faulty rear parking brake harness (9/25), a 12V battery failure requiring flatbed towing (11/25), and a faulty tire pressure monitor (12/25). The pattern of recurring failures across unrelated systems at minimal mileage indicates a systemic quality issue with this vehicle.

NHTSA ID

11727054

Incident

Mar 23, 2026

The vehicle accelerated without input and the brakes failed to respond. I am notifying you that this vehicle is a life-threatening safety risk and should not be rented again until a master technician clears the electronic throttle control and breaking system. This condition presents a serious safety risk and could lead to a car crash or injury. Additionally, the vehicles, climate control system behaved erratically, alternating between extremely hot and extremely cold air without adjustment. This may indicate a broader electronic or system malfunction affecting vehicle city.

NHTSA ID

11726743

Incident

Mar 23, 2026

This Preliminary information communicates an issue with the SES MIL and DTC P062B and engineering is currently investigating.

PI to help diagnose A/C concern

This Preliminary information communicates an issue with an OTA pending message still displayed after an OTA event and how to reset/clear the message.

This preliminary information is to inform technicians that GM is placing the B174W Front View Camera Module (ACP2) on part restriction due to elevated replacement rates and ongoing engineering investigation. Technicians must not replace the front camera module unless they have: 1.Completed the diagnostic procedure in this PI, and 2.Contacted TAC and received authorization, including the SI document number and specific step that directs camera replacement.

This preliminary information is to inform technicians and customers that the voice command will be inoperative when trying to open applications. Engineering is investigating and this PI will be converted to a bulletin when a repair is available.

This PI explains that the T18, Battery charger drive power distribution control modules are on parts restriction thru TAC.