1997 Chevrolet Monte Carlo

GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.

GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.

There is no summary currently available

TL* THE CONTACT OWNS A 1997 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING 85 MPH, THE STEERING WHEEL BECAME LOOSE AND CAUSED THE CONTACT TO TEMPORARILY LOSE CONTROL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE LOWER PINION BEARING FOR THE STEERING RACK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 03V527000 (STEERING:RACK AND PINION) HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 220,000.

NHTSA ID

10488701

Incident

Dec 1, 2012

Mileage

220,000 mi

MY 97 MONTE CARLO Z34 STARTED DYING ON ME WHENEVER I CAME TO A COMPLETE STOP AND AFTER I HAD BEEN DRIVING IT FOR A WHILE. AND IT WOULD SHOOT FORWARD AFTER I STARTED IT AGAIN IN NEUTRAL(THE ONLY WAY IT WOULD START). PLACING MYSELF IN THE MIDDLE OF INTERSECTIONS UNWILLINGLY, I WOULD HAVE TO START MY CAR AND MAKE SURE NO CARS WERE COMING ANY WAY OR ELSE I WOULD HAVE CRASHED! NOW MY CAR IS COMPLETELY UNDRIVABLE AND DIES WHENEVER I HIT MY BRAKES, I TOOK THE CAR TO SEVERAL MECHANICS SINCE THIS STARTED AND HAVE HAD THE FOLLOWING CHANGED/REPAIRED: UPPER AND LOWER INTAKE GASKET SET, THROTTLE BODY GASKET, THERMOSTAT, SPARK PLUGS AND WIRES, AIR FILTER, NUMEROUS VACUUM LEAKS, VALVE COVERS. *TR

NHTSA ID

10282225

Incident

Jul 20, 2009

MY 1997 CHEVROLET MONTE CARLO WAS RECENTLY DIAGNOSED WITH AN INTAKE MANIFOLD GASKET THAT NEEDS TO BE REPLACED (DUE TO LEAKING OF ENGINE COOLANT). TWO MECHANICS INFORMED ME THE REPAIR COSTS WOULD BE BETWEEN $800-$1000. AFTER FURTHER RESEARCH, I DISCOVERED SEVERAL GENERAL MOTORS VEHICLES BETWEEN 1996-2002 HAD THIS SAME PROBLEM. THOUGH NO OFFICIAL RECALL WAS DONE, GM DID PUBLISH A TECHNICAL SERVICE BULLETIN REGARDING THIS PROBLEM A FEW YEARS AGO. I KNOW CANADA HAS FILED CLASS ACTION SUITS AGAINST CANADA GM CONCERNING THIS ISSUE. THE CAR ONLY HAS 120K MILES ON IT, AND THE BLUEBOOK STATES THE VALUE TO BE AROUND $2200. DOES THE STATE OF MARYLAND HAVE INFORMATION ON THIS ISSUE REQUIRING GM TO PERFORM THIS WORK UNDER SOME KIND OF WARRANTY? *TR

NHTSA ID

10232010

Incident

May 23, 2008

Mileage

119,000 mi

MY 97 CHEVY MONTE CARLO HAS HAD NO LOWER BRAKE LIGHTS FOR SOME TIME . I HAD MY CAR CHECKED BY AN AUTO ELECTRICIAN AND WAS TOLD THAT THE PROBLEM WAS SO SEVERE AND IT WOULD PROBABLY NEVER FIND THE SOURCE OF THE PROBLEM. I AM VERY CONCERNED WITH THIS ISSUE BEING IT MAY CAUSE SERIOUS INJURY TO MY SELF/FAMILY OR OTHERS. AS I DRIVE ON THE ROAD I NOTICE MANY AUTOS OF THE SAME YEAR AND TYPE HAVE THE SAME PROBLEM SO I KNOW ITS NOT ONLY MY VEHICLE .I THOUGHT IT COULD OF BEEN THE FACTORY INSTALLED SECURITY SYSTEM SO I HAD IT UNINSTALLED TO COME TO THE FACT THAT IT WAS NOT THE SECURITY SYSTEM AFTER ALL. PLEASE HELP WITH THIS ISSUE . THIS IS MY ONLY SOURCE OF TRANSPORTATION AS I AM DISABLED AND CANNOT AFFORD ANOTHER VEHICLE . I HAVE PUT CONSTANT REPAIRS ON THIS CAR , FUEL INJ TANK, ETC. AGAIN PLEASE ADDRESS THIS URGENT ISSUE. *TR

NHTSA ID

10221331

Incident

May 10, 2007

TL*THE CONTACT OWNS A 1997 CHEVROLET MONTE CARLO. WHILE DRIVING 5 MPH, THE ENGINE FELL OUT OF THE VEHICLE. THE MECHANIC STATED THAT THE FAILURE WAS CAUSED BY THE SUB FRAME BOLTS NOT BEING TIGHTENED. THE BOLTS WERE RE-ATTACHED. AS OF AUGUST 14, 2007, NO OTHER FAILURES HAVE OCCURRED. THE CURRENT AND FAILURE MILEAGES WERE 145,000.

NHTSA ID

10199530

Incident

Apr 1, 2007

Mileage

145,000 mi

THIS IS MY SECOND GM VEHICLE WITH THE SAME MALFUNCTION. FIRST, THE WINDSHIELD WIPERS WOULD NOT TURN ON. THEN THE RIGHT BLINKER WOULD NOT WORK (STAYS SOLID, DOESN'T FLASH). THEN THERE WAS A SMALL FIRE ACCOMPANIED BY A LOT OF SMOKE COMING FROM THE STEERING COLUMN. THIS IS A 1997 CHEVY MONTE CARLO. THE OTHER CAR I HAD WITH THE SAME MALFUNCTION WAS A 1995 CHEVY BERETTA. ALL REPAIRS ARE COSTLY. *JB

NHTSA ID

10177137

Incident

Sep 12, 2006

Mileage

120,000 mi

THE TURN SIGNAL SWITCH HAS AN UNNATURAL TENDENCY TO FAIL ON ALL 95-99 MONTE CARLO AND 95- 00 LUMINA'S MADE BY CHEVROLET THIS CAN CAUSE A FAILURE IN THE ELECTRICAL SYSTEM RESULTING IN THE FAILURE OF THE BRAKE LIGHTS. THE TURN SIGNAL SWITCH WILL NEED TO BE REPLACED. THIS HAS RESULTED IN THE PROPER OPERATION OF THE BRAKE LIGHTS. OLD PART NOT AVAILABLE. *NM

NHTSA ID

10168687

Incident

Aug 16, 2006

Mileage

55,000 mi

DECREASE BRAKING ABILITY ON WET PAVEMENT. *JB

NHTSA ID

10152849

Incident

Mar 15, 2006

Mileage

96,450 mi

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.