2015 Chevrolet Silverado 1500 Engine Problems

09/28/2024. Chevrolet 5.3 L V8 Silverado 1/2 ton pickup truck. I was driving on KS. Highway 7, N bound, the engine started shaking, eng light on and the engine quit. I costed to the side of the road. Number 7 cylinder dropped a valve and more damage. Mileage on vehicle 53,198. This truck had top care, as it still has. Cost to me at Hendrick Chevrolet $7,092.89. This has happened to many people with no help from GM. ITS A SHAME. GM KNEW THIS. Date of incident 09.28.2024

NHTSA ID

11748296

Incident

Sep 28, 2024

When on the highway and attempted to accelerate to pass in the passing lane, there was a loud pop, the truck rapid decelerated and my son was forced to drive off the burm to avoid being hit by a semi truck. It’s been determined that it was caused by a lifter failure due to the AFM system

NHTSA ID

11744365

Incident

Jun 12, 2026

My 2015 Chevrolet Silverado 1500 had an oil pump failure at 77,000 miles… Truck may be 11 years old but it only has 77k on it and the oil pump has already failed? Seems crazy to me, especially when I’ve changed the oil religiously every 3,000 miles.

NHTSA ID

11742491

Incident

May 29, 2026

The engine in my 2015 Chevy Siverado 1500 5.3 AFM lost propulsion, began to shudder and stall on the highhway as I was pulling out of my hometown. Speed limit 60 MPH. I returned home and the flashing engine light came on before I could get home. Sputtering I pulled into the drive but was concerned about mine and my passengers safety as I turned around on the highway and headed back home! This is the second time my lifters failed, as diagnosed by the repair shop currently diagnosing the issue.

NHTSA ID

11737672

Incident

Apr 16, 2026

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while driving 40-45 MPH, there was an abnormally loud ticking sound coming from the passenger's side of the engine compartment. There was no warning light illuminated. The vehicle was taken to a local dealer and to another dealer, where it was diagnosed and it was determined that the engine needed to be replaced. The contact was informed that the repair was not covered because the VIN was not under recall. The vehicle was not repaired by the dealers due to the cost. The vehicle was taken to an independent mechanic, where the engine was taken apart, and it was diagnosed that the camshaft was worn, and there were metal shards in the engine oil. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 101,000.

NHTSA ID

11732927

Incident

Mar 29, 2026

Mileage

101,000 mi

Sold vehicle with full knowledge that its was not safe to be driven the dealership/owner didn’t follow state safety regulations I could have been hurts well as innocent people on the roads and highways if the motor would have messed up or something underneath the vehicle would have malfunction and broken

NHTSA ID

11729842

Incident

Jan 1, 2026

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the vehicle started running sluggishly and was jerking abnormally. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 180,000.

NHTSA ID

11728847

Incident

Apr 2, 2026

Mileage

180,000 mi

2015 Chevrolet Silverado complete engine failure. At 143,000 miles the engine failed because of the displacement on demand fuel injection system/lifters. Lifter failed without warning, destroyed the camshaft, cam bearing and crank and crank bearings. Chevrolet/GM were no help at all and took on responsibility for building defective engines they knew would fail after the warranty expired. I ended up spending nearly $17,000 to have a remanufactured engine installed.

NHTSA ID

11716309

Incident

Oct 1, 2025

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the instrument cluster started flickering, and the vehicle stalled. During several failures, the check engine warning light illuminated, and during other failures, there was no warning light illuminated. The contact stated on several occasions that the vehicle restarted independently. The failure was an intermittent failure, but was a recurring failure. The vehicle was not taken to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 120,000.

NHTSA ID

11715346

Incident

Dec 8, 2025

Mileage

120,000 mi

The 6.2L AFM DOD caused the lifter failure in #7 which destroyed my motor causing $10,000 in damages. Junk lifters. Only way to fix is get rid of afm dod.

NHTSA ID

11713952

Incident

May 1, 2025

The contact's father owns a 2015 Chevrolet Silverado 1500. The contact stated that while the owner was driving at an undisclosed speed, the engine made a tapping sound, and the vehicle stalled. The contact was unsure whether a warning light was illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the lifters and the camshaft had failed. The cost of the repair had not yet been determined. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 152,000. The VIN was not available.

NHTSA ID

11706754

Incident

Dec 22, 2025

Mileage

152,000 mi

AFM/DFM on my 2015 Chevrolet Silverado 1500 LT had to lifters collapse without warning and no engine light was hole I had my 7 year old daughter and 10 year old son in the vehicle while I was driving. My kids got scared and I had to react quick and go into a drive way. While I was driving my vehicle gave out without warning and could’ve caused a serious accident to my kids and myself including other vehicles.

NHTSA ID

11703832

Incident

Dec 3, 2025

86K miles smelled gas. Dealer replaced one fuel injector on the 6 cylinder rail. At 108K miles, catastrophic engine failure caused by misfire in the #6 cylinder. No compression or diagnostic testing done at initial fuel injector replacement. It is now my understanding that it is good practice when replacing one fuel injector, all should be replaced. After truck was inoperable at 108K miles, ran a borescope into the 6 cylinder shaft and noticed massive wash and scoring. Goodwill from GM was denied for an engine swap. Subsequent diagnostic testing revealed low pressure in all cylinder heads. I don’t put a lot of miles on this truck per year and suspect the problem compounded over time without notice. There was gas mixture in the oil, however this issue was never brought to my attention during routine maintenance and oil changes. I know there were issues with the 6.2L and didn’t know of parallel or residual issues with the 5.3L. Long story short, I had to go with an engine swap on a truck with relatively low mileage.

NHTSA ID

11698152

Incident

Dec 31, 1969

The 5.3 engine in the 2015 Chevy Silverado had lifter failure. The engine needed to be repaired and taken out of the truck. The engine needed a full repair of the lifters, camshaft, gaskets, etc. Which ended in a costly repair.

NHTSA ID

11696776

Incident

Sep 22, 2025

I have had a problem with the theft deterrent system which, shuts the truck down and issues a message saying "turn the driver side window down and then up". After 5 minutes the truck starts back up by itself? This has occurred sitting in Popeyes drive thru line in August 2024 in Benton Harbor, Mi. This has occurred 3 times in the past week, 09/25/25 driving on Garrett road it shut down during the entry into a "s curve" 09/26/25 driving into my drive way 09/28/25 driving into my drive way Took the truck into Wimberley Chevy dealer and they searched for error codes and checked some of the ground wires not connected properly and found the negative cable on battery was ok. I don't know if any other wire connectors were checked, however I have had this before and the dealer said they would have to keep the truck as it may take quite some time in confirming all connections were good. the service manage of LeValley Cheverolet stated that they would require a $1,000 deposit for them to start looking into the problem and again require another $1,000 deposit to continue and then another etc. I will not drive my truck on any major highway or in any very busy large city for fear of having a return of another shutdown and no place to pull into as I was only coasting when I entered the "S curves" and had space.

NHTSA ID

11694434

Incident

Sep 25, 2025

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the engine started shuddering and the vehicle decelerated unintendedly. Additionally, the check engine and traction control warning lights were illuminated. The vehicle was taken to the local dealer, who diagnosed the vehicle with engine failure. The contact was informed that the engine needed to be replaced. The engine was replaced, but the failure reoccurred. The contact was informed that the engine shudder was due to a faulty fuel management system, which caused the lifters to remain in the open or closed position. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 75,000.

NHTSA ID

11691241

Incident

Aug 3, 2023

Mileage

75,000 mi

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that after arriving to the intended destination, there was an abnormal ticking sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the lifters, resulting in damages to the engine. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); but the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 124,000.

NHTSA ID

11675957

Incident

Jul 24, 2025

Mileage

124,000 mi

2015 5.3 with afm related failure / lifter collapse still within warranty by mileage (5 yrs, 100,000 miles I think), out by years in service, was diagnosed by a GM authorized dealership by a GM Master Certified Technician and under the supervision of service manager. Issue Description On 6/18/2025, the dealership diagnosed a failure in the #7 lifter due to afm / afm related failure / lifter collapse. The vehicle’s engine, diagnosed at approximately 58,000 miles and minimal idle hours. While the GM Master technician is confident that only one side of lifters require immediate replacement, there is a possibility of damage to the camshaft lobe, which cannot be inspected without significant additional labor. There is also a concern about potential metal contamination in the oil, which could further impact the engine’s performance. I also have many documented repair orders indicating my concern with the transmissions performance.

NHTSA ID

11669816

Incident

Jun 18, 2025

Component that failed Lifter failure causing camshaft damage. I was driving my truck at the time the engine failure and loss of propulsion. The problem was later linked to lifter failure. Car started to lose power and surge forward while I was in oncoming traffic. I pulled over and had my truck towed to the Jamestown Chevy Dealership. I have had all of my services done at the certified Chevrolet dealership. Their professional diagnosis was lifter problem with camshaft damage. The vehicle was inspected by mechanics at Sierra Motors in Jamestown Ca. No prior warning to the vehicle failure. Once the truck lost propulsion and was surging the check engine light and road traction light came on.

NHTSA ID

11669346

Incident

Jun 2, 2025

I was driving my truck on a interstate when the torque converter broken and forced me to stop on a "No parking" area, The cars couldn't see me until I got really close to my car and almost caused an accident, the sheriff had to intervene and signal that there was a car stopped on the interstate, it wasn't the first time that it happened, it happened 5 times since I got the truck( I have it for 5 months) I already fixed it and replaced the torque converter but it's not safe to be on the side of the road every month, it need to be fixed because it can cause many accidents

NHTSA ID

11669069

Incident

Feb 20, 2025

My engine shakes when shifting into the V4 from the V6 and my transmission shifts hard as well as a dieseling affect when shifting from 2nd gear to 3rd gear. Rear main seal was replaced 1000 miles ago and now has to be replaced again due to the rapid shaking of the V4 cylinder deactivation(which was a terrible way to make the reliable 4.3 Lt engine unreliable)

NHTSA ID

11660231

Incident

May 11, 2025

Experienced a problem with electrical theft deterrent system and it shut the vehicle off while driving. I tried to start the vehicle and nothing happened except it said theft deterrent system. I took the key out tried starting again and it turned over immediately. The dash said theft deterrent and I clicked dismiss but the dash icon (a car with a lock light) remained on. I then drove 11 miles home. I turned on my directional proceeded to brake upon approaching my driveway. As I attempted to turn the steering wheel the vehicle completely shut off. The info system stating theft deterrent active. I lost power steering and brakes. I needed to press the brakes with great force because the vehicle was headed towards the sidewalk and a road sign. Steering was virtually unresponsive. Vehicle stopped as the tires reached the curb and approximately 1 ft from the sign. Placed vehicle in park and started it back up. Pulled into my driveway and the info system stated I need to roll the drivers window down and the up to deactivate. I have checked all battery connections are intact and tight. The battery, starter and alternator were all checked and fine. I have no idea what caused this dangerous behavior. The incident happened on MA Rt. 126 988 S. Main st Bellingham MA 02019

NHTSA ID

11660051

Incident

May 8, 2025

I bought this truck a little over a year ago. Mileage 89,392. 2 weeks later the truck started to run poorly, shaking badly, misfiring. Took it to the garage. They told me the had to replace coil packs one one side lifters and one push rod. Truck ran good for 1 year. I know this because I had just gotten it inspected. A couple days later the truck started doing the same thing. Now it’s in the garage again. They tell me the camshaft is shot and needs replaced including all the lifters. The truck now has just over 100,000 miles on it. The repair is about $6600.00. GM will allow the garage to do some work under a warranty type citation and GM will pay approximately $535.00. For a total of about $1000.00. Now my concern is this truck could break down on the highway and cause an accident just like a current recall for crankshaft and or connecting rods. If there can be a recall for that there should be a recall on this issue also. The garage has informed me they have done a lot of these repairs. Some even had to come back a second time.

NHTSA ID

11658265

Incident

Mar 18, 2025

The transmission went out with only 140,000 on it. It also has problems with shaking

NHTSA ID

11657983

Incident

Dec 6, 2024

Number 7 cylinder valve failed. “Good Morning Mr. [XXX] . I have some updates on your vehicle. Based on my technicians inspection cylinder 7 is misfiring. He removed valve cover and found a stuck rocker arm caused by collapsed lifter. may need camshaft will know further when engine is tore down.” Then they quoted an outrageous bill. This is an on going issue with General Motors. Why is this not being fixed by the corporation? The truck doesn’t even have 100k miles on it and it’s been kept up routinely. I am the original owner and feel that problem has been going on for over 10 years now. GM should be held accountable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11656137

Incident

Apr 22, 2025