2015 Chevrolet Silverado 1500 Problems

When applying brakes at low speeds the brakes are unresponsive they sound rough and the vehicle does not come to a stop it skids forward, and an electric low whine occurs. This doesn't happen everytime. I took it in for Carvanas 30 day warranty and was told its because I drove it down the mountain grade while applying brakes and they didnt find anything wrong with the brake thus wouldn't be covered. Been seeing this vacuum issue with the brakes on this particular issue and seeing if I can get this resolved.

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the brakes failed to engage while the brake pedal was depressed. The contact placed both feet on the brake pedal for the vehicle to come to a stop. No warning lights were illuminated. A dealer was contacted and made the contact aware of an unknown recall; however, the VIN was not under recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 187,918.

COMPONENT: Electric power steering (EPS) and electrical/power distribution. Available for inspection. FAILURE: My 2015 Chevrolet Silverado 1500 LT (5.3L, 4WD) intermittently loses EPS assist during tight low-speed turns; steering becomes suddenly and severely heavy. On one occasion the engine shut off completely while I was turning - steering went heavy immediately before the stall. The same events bring random Service StabiliTrak warnings, Tow/Haul messages I did not request, and loss of stereo audio and turn-signal chime, sometimes together. Shutting off, opening the driver's door, waiting a minute, then remote starting restores normal operation - modules appear to reset when the truck fully powers down. SAFETY RISK: Loss of steering assist plus complete engine shutdown occurred while turning. Losing both in traffic could readily cause a crash. RECALL: NHTSA 18V-586 (GM 18289, EPS Loss of Steering Assist) was completed on this VIN 2018-10-11. Eight years later the vehicle still loses steering assist, now with engine stall. GM's Part 573 report states the remedy only reduces EPS current draw so voltage stays above the 8.8V cutoff; it appears inadequate here. GM TSB 18-NA-161 describes this same symptom set and attributes it to high-resistance battery cable connections, a poor BCM ground at G218, a shorted B+ cable at the starter solenoid, or a faulty battery - a hardware condition never made subject to recall despite causing engine stall and loss of steering assist. INSPECTION: Hotchkiss Auto could not recreate the failure; the vehicle set numerous codes across multiple modules, making the fault impossible to isolate. Not inspected by manufacturer, police, or insurance. No crash, injury, or fire. PRIOR REPAIR: Two months ago I cleaned and tightened two grounds (front passenger wheel area, under driver's dash). Symptoms stopped two months, then returned. WARNINGS: StabiliTrak and Tow/Haul messages precede and accompany the failures. First appeared June 2025.

Odometer Fraud. The contact purchased a 2015 Chevrolet Silverado 1500. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. The contact stated that the mileage on the title was discovered to be 214,850. At the time of purchase, the mileage was 139,131. The Carfax report mileage was not obtained.

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while the vehicle was parked, the "Service Power Steering Drive" message was displayed and the steering wheel became extremely difficult to maneuver. The contact attempted to drive onto the main street; however, had to drive slowly with the hazard lights activated, before returning to the residence. The contact researched and became aware of an unknown recall; however, the VIN was not under recall. The vehicle was taken to an independent mechanic to be diagnosed and associated the failure with an electric pump. The failure mileage was approximately 106,799.

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the vehicle lost power steering functionality for approximately 1 minute. The failure had occurred while the steering wheel was straight or turning towards the left or the right, and the steering wheel was jerking during the failure. The “Power Steering” message was displayed, and there was an audible chime intermittently. The dealer was contacted, and the issue was discussed. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was 158,000.

I am filing this complaint regarding a serious engine lifter/Active Fuel Management (AFM) failure in my 2015 Chevrolet Silverado 1500. The vehicle experienced a lifter failure that caused significant engine problems and created a potential safety concern while driving back from shopping: loss of power, engine misfire, severe shaking, ticking, check-engine light, stalling, inability to maintain speed, etc. The vehicle had approximately 200k miles at the time of the failure. The vehicle was inspected by a local mechanic, which diagnosed the problem as collapsed/failed lifter. The repair required/will cost approx. 3k or more estimated My concern is that this does not appear to be an isolated failure. Other owners of 2015 Chevrolet Silverado 1500 trucks equipped with GM's Active Fuel Management system have reported lifter failures, including failures resulting in engine damage and sudden loss of engine power or propulsion. A sudden lifter or related engine failure can create a significant safety hazard, particularly when it occurs at highway speeds, while merging into traffic, crossing an intersection, or in another situation where the driver depends upon the engine to maintain acceleration and vehicle speed. I am reporting this in hopes that GM can be held accountable as they knew about these defective lifters but did nothing but hide it.

Lifter for cylinder 7, part of the Active Fuel Management system, failed to open causing the truck to lose full power while I was on the highway without any warning prior to the incident. It could have caused an accident if It had happened during a busier time on the highway as I could not go the "flow of traffic's speed." It has been torn down and looked over to confirm the problem and full extent of the damage, by a dealership, with pictures of proof. This has left me without my vehicle for months due to needing a full brand new motor.

I am filing this complaint regarding a serious engine lifter/Active Fuel Management (AFM) failure in my 2015 Chevrolet Silverado 1500. The vehicle experienced a lifter failure that caused significant engine problems and created a potential safety concern while driving back from shopping: loss of power, engine misfire, severe shaking, ticking, check-engine light, stalling, inability to maintain speed, etc. The vehicle had approximately 200k miles at the time of the failure. The vehicle was inspected by a local mechanic, which diagnosed the problem as collapsed/failed lifter. The repair required/will cost approx. 3k or more estimated My concern is that this does not appear to be an isolated failure. Other owners of 2015 Chevrolet Silverado 1500 trucks equipped with GM's Active Fuel Management system have reported lifter failures, including failures resulting in engine damage and sudden loss of engine power or propulsion. A sudden lifter or related engine failure can create a significant safety hazard, particularly when it occurs at highway speeds, while merging into traffic, crossing an intersection, or in another situation where the driver depends upon the engine to maintain acceleration and vehicle speed. I am reporting this in hopes that GM can be held accountable as they knew about these defective lifters but did nothing but hide it.

January of last year, I was driving, coming off the highway, my engine came on and the system send to shutdown immediatly. I was close enough to my machanic, upon inspection, the AFM System failed at only 76,622 miles. This is part of the building issues with this value lifter problem I wanted to document it with the NHTSA as you are actively opening case for this ongoing issue with GM. i am hoping that a class action law suit will hopfully gain traction. this was a know issue, i was outside of standard warrenty, I was forced to replace the engine out of my own pocket to avoid having a truck worth almost nothing. I will bring this up with GM corporate also, reciept uploaded. Millions of 2014-present trucks and SUVs, while federal investigations specifically target nearly 878,000 to 1 million newer vehicles (2019–2026). GM should be helad accountable

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while driving approximately 40-50 MPH, the driver's side curtain and front air bags, and the passenger's side curtain air bag deployed without impact. The contact stated that the front driver's side seat belt automatically retracted during the failure, but both the front driver's side and passenger's side seat belts had failed to retract manually after the failure. The contact was able to pull over to the side of the road. The air bag warning light illuminated after the failure. The contact sustained a burn on the back of the upper arm and a cut on the front of the forearm. The contact did not receive medical assistance. The contact was able to continue driving. The dealer and the manufacturer were not contacted. The vehicle was not yet diagnosed or repaired. The failure mileage was approximately 272,200.

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while her son was driving approximately 50 MPH, the front driver's side air bag and front passenger side air bag unexpectedly deployed without an impact to the vehicle. No warning light was illuminated. There were no injuries sustained. There were no passengers seated inside the vehicle. The contact's son drove the vehicle back to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

The paint on this vehicle is horrible. Now I am upside down in the vehicle and unable to get anything close to what is owed. No one affiliated with GM/Chevy will take any responsibility

Paint failure

I purchased a Brand new Chevrolet Silverado 1500 LT Z71 in2015. While still paying on this vehicle I had an issue with the engine bogging down and it would almost die. It would jerk and shake terribly to the point it just shut down. I took to Royal Chevrolet and they found that it had a broken Valve spring on Cyl 7. This went on and on they had this vehicle for a total of almost 7 months before they put 1 last engine in it. The 1st thing I did was drove down From Michigan to North Carolina to visit my daughter. Plenty of Mountains and a lot of driving as I drove 14 hours straight by myself. The engine that they had just put in started Chugging and choking and it stalled on the highway going through the mountains and I was hit in the rear end and the other driver never stopped. I managed to get it running again. Prior to leaving for North Carolina I ordered what they call a tuner where I could deactivate the AFM system and stay in 8 Cyl mode at all times. I had it sent to her house. I installed the program. Keeping in mind #1 I was rear ended. And every single time there was an issue it was Cyl#7 on all the previous engines. I talked to the Lead man at Royal chevrolet about all the issues and he said they know all about it and its a joke. They tried it on Cadillacs back in 1975 and recalled every one of them and turned it off. On my way back home not 1 single issue in fact and I sill have it displayed on my dashboard I actually got 26.2 Miles per gallon in V-8 mode in the mountains. I have driven to NC every year since before I even owned that truck and have never seen milage before or since. The AFM system is nothing but a ploy to get people to buy junk. Could someone been killed? Most certainly. I told the manager 1 more engine and I have a Friend cut stickers of lemons out and put at the main 4 corners in our town. I still have that truck and currently have 128,000 miles on it and I had to pay $600.00 to fix it myself. And GM thinks its a joke. I called GM

As I was driving, the brakes got all Smashy the pedal locked and the brakes started grinding. I couldn’t stop the truck anymore. I couldn’t do absolutely anything I had to stop and hit a divider from a parking structure to be able to stop my truck. My truck is a 2015 Chevy Silverado, I do maintenance all the time I almost took out four cars and injured. These people along with myself. This is uncalled for something is wrong with my brakes. I took a video right after and you see on the video how the brake is just stuck it won’t even go in or anything you hear , a marshmallow sound you feel the grinding it’s horrible .

Rear windshield was recalled and replaced in 2020, was driving and heard a pop and driver side rear windshield had shattered again, Chevys fix for rear windshield was just to put a new one in and not fix the actual issue, have a 6 month old baby and thank goodness she was not back there at the time.

Trucks driver side rear window which is a three-piece window with a sliding window in the middle has shattered apparently due to a defect or fault in the rear window fogger. I had my son in the back at one point and put the defogger on, and it started smoking and nearly caught on fire. No warning on either incidences and they did not occur at one time but about two days apart.

The engine in my 2015 Chevy Siverado 1500 5.3 AFM lost propulsion, began to shudder and stall on the highhway as I was pulling out of my hometown. Speed limit 60 MPH. I returned home and the flashing engine light came on before I could get home. Sputtering I pulled into the drive but was concerned about mine and my passengers safety as I turned around on the highway and headed back home! This is the second time my lifters failed, as diagnosed by the repair shop currently diagnosing the issue.

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the engine started shuddering and the vehicle decelerated unintendedly. Additionally, the check engine and traction control warning lights were illuminated. The vehicle was taken to the local dealer, who diagnosed the vehicle with engine failure. The contact was informed that the engine needed to be replaced. The engine was replaced, but the failure reoccurred. The contact was informed that the engine shudder was due to a faulty fuel management system, which caused the lifters to remain in the open or closed position. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 75,000.

I bought the truck around [XXX] from Barkau CDJR, Freeport IL. Two hours away from the dealer the truck went completely dead in traffic. A message appeared on the info screen that said roll down the drivers window and back up to reset the system when the truck finally restarted. Got home with it and called the dealer and let the know. In the next few weeks it happened a couple of more times. It was taken to Tapper Chevrolet in Paw Paw, MI to be serviced. The tech thought it was a problem in the fuse Block and replaced that, after that on the week end the truck was returned the problem happened 3 times. Took it back to Tapper's and they checked it again, had it for 4 days and could not replicate the problem. Kept having issues and took it to 1st Choice Automotive LLC in Dowagiac, MI, he went through the wiring and cleaned some grounds and it seemed to work for a while. Now it is doing the same thing again. It just shuts down randomly for no reason. You lose steering, brakes, you have no control when it happens and no warning when it is going to happen. Have searched You Tube and have seen many other complaints of the same problem with no solution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2015 Chevy Silverado 1500 LT/LTZ Double Cab 5.3 liter v8. Electrical short to power in underhood fuse block part number 84303175. Passenger side brake/tail light stay on constantly even when vehicle is shut off and key is out of ignition. Driver side brake/tail light works fine, customer had to disconnect harness to prevent battery from going dead. Hare Chevrolet Dealership, Noblesville Indiana, found short to power in under hood fuse block. Invoice: 340227 Part: 84303175 Customer pay 674.17 replacement of under hood fuse block. * MAJOR SAFETY CONCERN *

Sold vehicle with full knowledge that its was not safe to be driven the dealership/owner didn’t follow state safety regulations I could have been hurts well as innocent people on the roads and highways if the motor would have messed up or something underneath the vehicle would have malfunction and broken

I bought this vehicle last November from Shea. When we bought the truck we noticed the check engine light, but was told that we would have to bring it back in for inspection. The last vehicle we bought from Shea it had a 30 day return and it would fix any problems. Not so with this time. So, we purchased a Platinum warranty which was a little above $2K and we believed would cover these issues. That was not the case. We had a friend of ours who is a GM Mechanic look it over and told us that it needed a high pressure fuel pump. So when I brought the vehicle in on January 22nd I told the service person at the desk that we had a platinum warranty and told him that I had a GM technician tell me that it needed a high pressure fuel pump. After sitting for six hours he comes out and tells me that I needed a high pressure fuel pump and tells me it will cost me $1400.00+ to have it fixed and it would not be covered by my warranty. And then tells me that the work they did today would cost me $150.00. I told him when I came in what the problem was. I understand that they need to do their own diagnostics, but why didn't they tell me that the part would not be covered by the platinum warranty. We paid $23K for the truck, plus an additional $2k+ for the warranty and now an additional $1,400.00-$1,500.00 for the fuel pump. So, yes we are not happy and will give a second thought to ever using Shea again. I understand that this memo will not change things, but I want you to understand that prior to today's fiasco I have told friends that I would recommend Shea when looking for a vehicle. Now I would not recommend Shea to any of our friends. Sorely disappointed! To go along with the previous text, when I purchased the 2015 Z71 Silverado the key FOB fell apart so I purchased two (2) new ones at a cost of $225 each so that I could start my vehicle on cold winter days. So far, that was a waste of money a money also because the check engine light and the high pressure fuel pump

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while his son was stopped at a gas station, while buckling the seat belt, the floor anchor pretensioner cable snapped off. The contact stated that there was no warning light illuminated. A Chevrolet dealer was contacted and stated that the VIN was previously under recall, and the vehicle was repaired in Maryland in 2016 under NHTSA Campaign Number: 16V209000 (Seat Belts). The vehicle was recently repaired at Lancaster Chevrolet in Lancaster, SC (1616 Charlotte Hwy, Lancaster, SC 29720), and the contact stated that the vehicle would be covered under warranty if the mileage was under 184,700 miles. The contact paid out of pocket to have the cable replaced. The cause of the failure was not diagnosed. The manufacturer was not notified of the failure. The approximate failure mileage was 200,000.

I am having difficulty getting the driver side seat belt buckle to latch.

2015 SILVERADO clear coat peeling off wheels and not holding air I,m [XXX] if I need this truck in an emergency i,m stranded. Have contacted the dealer and gm both with no success the wheels were $2900. and they wanted me to pay $2300. for a truck that has 50,000 miles on it. it is clearly a safety issue driving down the road when they will not hold air. I filed a complaint in oct 2021 and oct 2024 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mi camión está marcando un problema de servicio del sistema de freno de remolque y amanece con la batería baja y cuando voy conduciendo la mayoría de tiempo se pone muy duro el pedal del freno y hace un ruido muy raro cuando freno y también cuando acelero truena cómo si trajera un Fierro suelto en el motor

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that the door locks were independently locking and unlocking, and the hazard lights were flashing intermittently. The contact stated that the interior lights and the headlights were activated without the contact using the key fob or manually turning the lights on. The contact stated that the 12-Volt battery and alternator were replaced, but the vehicle still experienced electrical failures. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the door lock actuator and the wiring harness needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The manufacturer was not informed of the failure. The failure mileage was approximately 129,000.

My driver’s seat started moving slightly then by the end of the day it was rocking back and forth at least 2 inches. The dealer said it’s not under warranty and it would be $1,200 to repair it. I had it welded but the weld didn’t hold. I am afraid this is a big safety hazard and should be covered especially since the truck is only 5 years old. I only weigh 200 lbs and I am the only one who’s ever driven the truck. There is no reason the seat should be broken. Consumer stated vehicle not included in the recall.

The contact owns a 2015 Chevrolet Silverado 1500 equipped with Tread Wright Tires, Tire Line: Mud Lord, Tire Size: 295/65/R20, DOT Number: 1422. The contact stated while driving approximately 65 MPH, the contact heard an abnormal flapping sound coming from the rear of the vehicle while the vehicle started shaking and vibrating. The contact stopped and inspected the vehicle and discovered that a baseball-sized bubble had developed on the tread of the rear passenger’s side tire. The cause of the failure was not yet determined. The manufacturer and dealer were notified of the failure, but no assistance was offered. The failure mileage was 2,000.

TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 1500 EQUIPPED WITH GOODYEAR WRANGLER TIRES, SIZE: C265/65R18, AND DOT: 4AXPJH1R1215. WHILE DRIVING VARIOUS SPEEDS, THE STEERING FAILED AND THE CONTACT HEARD A LOUD, ABNORMAL NOISE UNDER THE HOOD. THE FAILURE OCCURRED INTERMITTENTLY. THE CONTACT HAD THE BATTERY REPLACED TWICE. THE CONTACT STATED THAT THE BATTERY NEEDED TO BE REPLACED AGAIN. IN ADDITION, ALL FOUR TIRES CONTAINED BUBBLES. THE TIRES AND BATTERY HAD NOT BEEN REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. PRESTON HOOD CHEVROLET (212 HOLLYWOOD BLVD NW, FORT WALTON BEACH, FL 32548, (850) 610-7278) DIAGNOSED AND REPAIRED THE VEHICLE. THE REPAIRS WERE UNKNOWN. THE VEHICLE FAILURE MILEAGE WAS 46,000 THE TIRE FAILURE MILEAGE WAS UNKNOWN.

See attached document for complaint.

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated while driving approximately 70 MPH, there was a loud clunking sound underneath the vehicle. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 21V504000 (Air Bags) however, the part to do the recall repair was unavailable. The contact mentioned that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was notified of the failure. The approximate failure mileage was 125,000. VIN tool confirms parts are not available.

A/C UNIT DOES NOT WORK. RECHARGE THE SYSTEM AND IT LEAKS OUT. GM/CHEVROLET KNOWS OF THE ISSUE AND HAS RECALLED OTHER MODELS USING THE SAME EQUIPMENT. NOT ON THE CHEVROLET SILVERADO MODELS. NO MENTION OF LEAKS OR ISSUES BY THE DEALERSHIP DURING REGULAR MAINTENANCE. ON JUNE 20TH 2020 I PAID TO HAVE THE SYSTEM RECHARGED, DIDNT BLOW REALLY COLD BUT GRADUALLY IT GOT WARMER, NOW IT BLOWS HOT AIR. LAST FALL OCT 2019 IT WAS NOT BLOWING COLD AIR, IN FEBRUARY 15 2920 WHILE DRIVING THE AIR SEEMED TO GET WARMER, COULD NOT KEEP THE CAB COOL. AFTER REVIEWING RECALL INFORMATION AND OTHER REVIEWS OF ISSUES I SEE THAT THE $1,100 OR MORE FOR REPLACEMENT OF CERTAIN EQUIPMENT, PLUS THE LONG DELAY BECAUSE GM/CHEVROLET HAS A SHORTAGE OF THE SPECIFIC PARTS (BACK ORDERED). I THINK THIS SHOULD BE A RECALL TO FORCE GM/ CHEVROLET TO FIX THIS ISSUE THEY HAVE KNOWN ABOUT SINCE BEFORE MY TRUCK WAS EVEN BUILT.

TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS, THE AIR CONDITIONER BEGAN BLOWING OUT HOT AIR. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (MASTER BUICK GMC, 3710 WASHINGTON ROAD, AUGUSTA, GA 30907, (706)-760-2303) WHERE IT WAS DIAGNOSED THAT THE AIR CONDITIONER CONDENSER FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS 60,000.