2018 Dodge Challenger

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Driving along and all of a sudden the shifter lights started flashing, wipers turned on, steering became difficult, and finally the transmission locked up. Stalled in the middle of the hiway turn lane and because the transmission was locked up it couldn't even be pushed out of the way. Traffic was backed up and people trying to get around because I was blocking a major hiway intersection. The dodge dealership has had the car 3 times and finally diagnosed it as the rack and pinion plug.

NHTSA ID

11743056

Incident

May 15, 2026

The contact owns a 2018 Dodge Challenger. The contact stated that the rims on the wheels of the vehicle were poorly designed and there were several cracks on the rims. The vehicle was taken to an independent mechanic who discovered cracks on the inside edges of the rims. The contact stated that the cracks were formed while driving over bumps and uneven road pavements. The dealer was notified of the failure, and the contact was notified that there were no recalls related to the VIN. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 75,000.

NHTSA ID

11729418

Incident

Feb 1, 2024

Mileage

75,000 mi

I purchased the vehicle which had minor passenger door damage under $500. There were false reports on Copart and Autobidmaster about the vehicle. They lied and said the vehicle was 91.2 percent damaged. The businesses are false. They admitted insanity as their fraudulent motivation. The title should be clean title and the door has been completely repaired. The title to the vehicle should be in my name. Car is ready to be registered. The reports from State Farm Insurance, Copart and Autobidmaster were what they said were false attempts to keep me from registering my vehicle I purchased. This has been ongoing since February 2025 and they are the guilty party.

NHTSA ID

11711734

Incident

Feb 15, 2025

The contact owns a 2018 Dodge Challenger. The contact stated that while driving at various speeds, the left turn signal light failed to function as intended. The turn signal light on the instrument panel was flashing erratically. The message "Left Turn Signal Out" was displayed. The vehicle was not diagnosed or repaired. The contact stated that on a separate occasion, while driving at various speeds, the passenger’s side window failed to function as intended. The window was rolling up and down slowly. Eventually, the window became inoperable. The vehicle was taken to the local dealer, where it was diagnosed, and determined that the window motor had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the failure persisted. The contact took the vehicle back to the dealer, where it was diagnosed, and the contact was informed that a wire was damaged, which caused an electrical system failure. The contact was informed that the electrical assembly needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ID

11686582

Incident

Sep 11, 2023

I got the car on 4/13/2025 from a Toyota dealership with about 31000 miles they told me the car fax showed the car had 2 owners a regular customer and another dealership, they also told me they change the battery but they failed to disclosed that they took the car to a body shop to fix a dent and to be repainted, by mistake they offered me the Toyota warranty 5 years or 60000 miles , on 8/10/25 while driving the car it caught on fire luckily nobody got injured , after putting the fire off the fire department told us the cause of it was an engine malfunction only after 4 months and with about 39000 miles ,from the pictures we suspect the fire started by the fuse box and now I'm looking for answers and who's responsible, the dealership, the previous owner or the manufacturer, the car got totaled.

NHTSA ID

11681493

Incident

Aug 10, 2025

My trouble is with my 2018 Dodge Challenger. The UConnect system is delaminating and the entire system is malfunctioning. I have taken the vehicle to my local Dodge dealer and showed them the issue, and they agree there is an issue. The safety issue is that the screen display system goes into what is called "ghost touching" where random buttons on the display are acting as if someone is pushing them but no one is touching anything. While backing up, the screen goes haywire, when trying to control anything electronic, the system goes haywire. Safety issue of distraction trying to find certain when in "ghost mode" The vehicle has been inspected by my local Dodge dealer, and agree there is an issue, but refuse to fix it without me paying $1,500. No prior issues electrically prior to the delamination issue. The first time is saw an issue was june 0f 2024.

NHTSA ID

11669404

Incident

Jun 12, 2024

No power then open the trunk and the power comes back on!! Dash lights blink out and radio then window goes up and down! Will leave u stranded

NHTSA ID

11661550

Incident

May 16, 2025

I have had an issue like the 30 other complaints on here with my window going up and down and faulty switch!!! Went to dodge and the lady stated no open recalls on the vehicle so I was probably looking at $2500 to fix . How is dodge not being held accountable for this and being liable to create a recall!!! I’m driving and the window started opening and shutting in the middle of a hurricane and I almost crashed, hit a divider & swirled ! Had to pull over and wait 1 hour for it to stop!!! PLEASE HELP before someone seriously is injured by this window faulty switch mechanism distracting apparently since 2011

NHTSA ID

11610678

Incident

Jul 1, 2024

Backup Camera Poor Image Quality Inspection

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH)

Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders: Warranty, Mopar, Customer pay and Service contract. Order"68" part number for New unsold units only

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE