2017 Dodge Challenger

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

The 8.4 Uconnect radio controls many aspects of the vehicle including hands free communications. When a communication device is paired to the system, at a random time, the device becomes unpaired and hands free communication becomes unusable. Additionally, at a random time, when the steering wheel communication button is pressed, the voice prompt announces "SIRI not connected". At that point, hands-free communication is not possible. It should be noted that SIRI is an Apple device feature. I have never used nor connected an Apple device to the system. The radio was dealership replaced in 2021 under partial goodwill coverage and partial cost to me. During my last dealership visit, I noted the issues and asked the service department to check the system software for updates. They verified that the software was already up to date. Additionally which is a minor safety issue, when communication device pairings are lost, other system settings are lost including all of the radio presets. At that point, communication pairings and system settings must be re-done. These issues are noted on several Dodge Challenger, Dodge Charger, Dodge Ram and Jeep forums. To view the forum posts regarding these issues, Google search using the term "8.4 unconnect problems". Many functions of this vehicle are controlled through the radio head. Random failures of the head including vehicle hands-free communication operation are critical to highway safety.

NHTSA ID

11689737

Incident

Sep 22, 2025

Dear [NHTSA / Indiana Attorney General], I am filing a complaint regarding a serious safety issue with my vehicle, a 2017 Dodge Challenger, purchased on [XXX] from Wetzel Chrysler Dodge Jeep Ram, Richmond, Indiana). Six months after purchase, the steering column failed, leaving the vehicle unsafe to drive. The dealership confirmed the repair cost at $4,500 but refused assistance, and Stellantis has also declined support despite the fact that this is a critical safety component necessary to control the vehicle. This defect poses a significant risk of sudden steering loss while driving, endangering both myself and others on the road. I respectfully request that your office review this matter for potential manufacturer accountability, safety recall investigation, or consumer protection enforcement. Thank you for your attention to this urgent safety concern. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11684151

Incident

Jul 30, 2025

My Service airbag system light keeps coming on and I have done everything to fix it but the light still comes on.

NHTSA ID

11677638

Incident

Jul 28, 2025

2017 Dodge Challenger 392. my radiator fan motor seized, causing the fan blades to explode sending plastic pieces into the radiator and other fuel lines. The fuel lines were my biggest concern because of fire. however, it did not. Next the repairs at a certified Dodge dealership cost me over $5,500. in damages to repair. This is a very known issue with Dodge SRT models. Furthermore, not even a month later the other fan seized and exploded apart, once again causing complete failure of my 1 month old radiator, causing another $5,000 in damages to repair. THIS is a very well known issue on forums across the USA. Thank you

NHTSA ID

11676473

Incident

Jun 12, 2025

8.4" touchscreen delaminating, causing ghost touches, which is changing my steering , timing, wipers, headlights, and suspension. The radio is going through stations, inputs, i can not use my android auto or use gps, all of my settings. It is very much a safety concern!

NHTSA ID

11674937

Incident

Mar 2, 2024

The front suspension has a problem and the engine oil cooler has a leak

NHTSA ID

11657907

Incident

Apr 30, 2025

Airbags did not deploying after passenger side impact

NHTSA ID

11639206

Incident

Dec 18, 2024

I took my car to the mechanic because the car was leaking radiator fluid. In testing the car he found that the head gasket had blown. He confirmed this with a hydrocarbon test. The car has 72,000 miles on it. I am the original owner. After saving the money to get the head gasket done. I was driving the car around when it began to to run poorly. At idle it was running very badly. I took it back to the mechanic to see what this issue was. After doing some testing they started to take the camshaft out of the car. It came out in 2 pieces. My car has the 3.6 in it. There is a class action lawsuit for this issue but because whatever part was linked to the lawsuit was not installed in my car I am not entitled to the fix. There are many more people with the same issue with the 3.6 liter Pentastar motor that I have had to go through after doing a bunch of research. This car is my dream car. I have taken excellent care of her. She has gotten oil changes religiously. I am at a complete loss as to how a camshaft can break. I have attached pictures of the camshaft and at the break you can see where there are defects in the metal causing it to break in two.

NHTSA ID

11623878

Incident

Oct 21, 2024

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH)

Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders: Warranty, Mopar, Customer pay and Service contract. Order"68" part number for New unsold units only

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.