2006 Hyundai Azera

In a letter dated August 9, 2013, Hyundai-Kia America Technical Center, Inc. (Hyundai) notified NHTSA that Hyundaiis conducting a safety recall (13V-354) involving approximately 239,000 vehicles involving model year (MY) 2006 through 2010 Hyundai Sonata vehicles (approximately 215,000)produced beginning on March 1, 2005 through January 21, 2010 and model year (MY) 2006 through 2011 Hyundai Azera vehicles (approximately 24,000) produced beginning on September 27, 2005 through November 22, 2010 that are registered in and operated or originally sold in the following 20 salt belt states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Hyundai will also inform dealers to inspect/repair vehicles that were previously registered in salt belt states but are currently registered elsewhere. Hyundai is conducting the recall to remedy a defect involving internal corrosion of the rear sub frame that may lead to separation of the rear upper/lower control arm(s) at their respective mounting points and/or separation of the axle from the transaxle where they meet.This could result in a loss of vehicle control and/or vehicle disablement which may increase the risk of a vehicle crash.In response to NHTSA?s Information Request (IR) letter, Hyundai stated the Azera vehicles utilizes the identical cross member and upper/lower rear control arm components as the subject (Sonata) vehicles.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Hyundai, ODI identified 19 non-duplicative reports alleging excessive corrosion of the rear sub frame. All of the complaint vehicles were either originally sold or registered at the time of the incident in one of the salt belt states.Of these 19 reports, 9 alleged either a suspension component separation or a fracture of the vehicle's rear cross member assembly.Similarly, ODI identified 8 warranty claims of rear sub frame replacement in data submitted by Hyundai due to excessive corrosion, all of which involved vehicles originally sold or operated in a salt belt state. Based on Hyundai's decision to conduct a safety recall, (13V-354) this investigation is closed.The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10535115, 10534110, 10525976, 10524726, 10521520, 10508368, 10505463, 10490073, 10486752, 10486435, 1048354, 10473922, and 10437887.

When driving, if you encounter even a small bump in the road, the car jumps as if it were a train jumping the tracks and getting back on track. If it's raining, it feels as though the vehicle is sliding across the road. (Finally, realizing that I WAS sliding across the road).

NHTSA ID

11625930

Incident

Nov 7, 2024

The contact owns a 2006 Hyundai Azera. The contact stated while driving at an undisclosed speed, the rear driver's side wheel unexpectedly collapsed. The vehicle was towed to an independent mechanic, who diagnosed that the sub frame had severe corrosion, causing the rear control arm to detach. The contact was informed that the sub frame needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 13V354000 (Suspension); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 193,430.

NHTSA ID

11604243

Incident

Jul 22, 2024

Mileage

193,430 mi

The air bag light came on for the front passenger seat. I took it to Grayson Hyundai & they tried to get part #88840-3L500-J9 which is the latch right front buckle assembly. I was told there was no part available because my car is a 2006 & manufactures are only required to carry parts for 10 years. I was also told if the air bags worried me to trade cars. I would think the seat belt buckle for a safety feature like the air bag would have to always be available. I have owned this car since 2006, it only has 26,600 miles on it. It has always been garage kept & literally looks like a new one EXCEPT I have NO air bags. Also, today I was told part #88840-3L500-J9 is on a National Parts List, whatever that means. Surely this has happened to someone else. I just decided to report it.

NHTSA ID

11549423

Incident

Oct 11, 2023

The vehicle has a random, chronic no start issue. Everything appears to be working normally, and you will turn the key with no crank. All the dashboard lights work, everything is as normal except it wont turn over. The dealer will not help. They refuse to even attempt replacing parts with my approval, just to try to rule things out. Due to my own investigation into the problem, we have successfully replaced the transmission inhibitor switch twice with good results. That switch will not allow the engine to crank if the car thinks the transmission is not in park. The first time the repair worked for 1 year, and the second time 6-8 months. I'm having the problem again, not sure where to turn for help. Dealer is useless, local shops have no better ideas than I do.

NHTSA ID

11532397

Incident

Jun 1, 2019

The contact owns a 2006 Hyundai Azera. The contact stated while driving at an undisclosed speed, the anti-lock braking system malfunctioned then failed to respond. The ABS warning light was illuminated. Additionally, the contact stated that the check engine warning light illuminated, and the vehicle stalled and failed to restart. The insurance company was notified of the failure and the vehicle was towed to the residence. Additionally, the contact stated that multiple relays were installed in the vehicle and previously failed while driving. The vehicle was taken to an undisclosed dealer where it was diagnosed that the ABS relay switch box was faulty and the vehicle was repaired under NHTSA Campaign Number: 18V026000 (Service Brakes, Hydraulic) however, the failure recurred. The undisclosed dealer was notified of the failure and the contact was advised to bring the vehicle to the dealer to be diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 150,000.

NHTSA ID

11528998

Incident

Jun 2, 2023

Mileage

150,000 mi

The contact owns a 2006 Hyundai Azera. The contact stated that the air bag warning light had illuminated and remained illuminated on the instrument panel for a year. The vehicle was taken to the dealer and diagnosed but no cause for the failure was found. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 307,000. The contact stated the vehicle was taken to the dealer but informed there was nothing wrong with the vehicle. Also, the contact received a recall for the airbag but no longer has the recall notice.

NHTSA ID

11527367

Incident

Jun 16, 2022

Mileage

307,000 mi

The contact owns a 2006 Hyundai Azera. The contact stated that on numerous occasions, the air bag warning light illuminated. The vehicle was taken to the dealer several times. The contact was then referred by the dealer to a different dealer where it was diagnosed and produced code: B1489 and B1495. The contact then stated that the pod reset was performed, and the ECU was not responding however, the contact stated that she was not informed of which part needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 10V007000 (Air Bags, Seat Belts). The manufacturer was not notified of the failure. The failure mileage was approximately 83,000.

NHTSA ID

11503466

Incident

May 23, 2022

Mileage

83,000 mi

The contact owns a 2006 Hyundai Azera. The contact stated while driving approximately 70 MPH, the vehicle rode over a slight bump in the roadway and the rear-end of the vehicle started swaying to the left and the right. The contact pulled over and stopped the vehicle to check for a flat tire and observed that the tires were inflated. The contact stated that the failure was intermittent but occurred at various speeds while driving over a slight bump in the road. The contact stated no warning light was illuminated. The vehicle was not taken to a local dealer or independent mechanic to be diagnosed or repaired. The contact looked under the vehicle and saw that the rear driver’s side upper control arm and the rear mount had detached from the frame. The vehicle was not diagnosed or repaired. The contact researched online and determined that the failure was related to NHTSA Campaign Number: 13V354000 (Suspension). The manufacturer had been informed of the failure. The failure mileage was approximately 215,000.

NHTSA ID

11499427

Incident

Dec 26, 2022

Mileage

215,000 mi

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.