2007 Hyundai Azera

In a letter dated August 9, 2013, Hyundai-Kia America Technical Center, Inc. (Hyundai) notified NHTSA that Hyundaiis conducting a safety recall (13V-354) involving approximately 239,000 vehicles involving model year (MY) 2006 through 2010 Hyundai Sonata vehicles (approximately 215,000)produced beginning on March 1, 2005 through January 21, 2010 and model year (MY) 2006 through 2011 Hyundai Azera vehicles (approximately 24,000) produced beginning on September 27, 2005 through November 22, 2010 that are registered in and operated or originally sold in the following 20 salt belt states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Hyundai will also inform dealers to inspect/repair vehicles that were previously registered in salt belt states but are currently registered elsewhere. Hyundai is conducting the recall to remedy a defect involving internal corrosion of the rear sub frame that may lead to separation of the rear upper/lower control arm(s) at their respective mounting points and/or separation of the axle from the transaxle where they meet.This could result in a loss of vehicle control and/or vehicle disablement which may increase the risk of a vehicle crash.In response to NHTSA?s Information Request (IR) letter, Hyundai stated the Azera vehicles utilizes the identical cross member and upper/lower rear control arm components as the subject (Sonata) vehicles.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Hyundai, ODI identified 19 non-duplicative reports alleging excessive corrosion of the rear sub frame. All of the complaint vehicles were either originally sold or registered at the time of the incident in one of the salt belt states.Of these 19 reports, 9 alleged either a suspension component separation or a fracture of the vehicle's rear cross member assembly.Similarly, ODI identified 8 warranty claims of rear sub frame replacement in data submitted by Hyundai due to excessive corrosion, all of which involved vehicles originally sold or operated in a salt belt state. Based on Hyundai's decision to conduct a safety recall, (13V-354) this investigation is closed.The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10535115, 10534110, 10525976, 10524726, 10521520, 10508368, 10505463, 10490073, 10486752, 10486435, 1048354, 10473922, and 10437887.

BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. THE AGENCY OPENED ITS INVESTIGATION BASED ON FIVE COMPLAINTS OF STOP LAMP FAILURE ACROSS SEVERAL 2007 HYUNDAI MODELS. THE AGENCY ALSO RECEIVED EARLY WARNING (EWR) REPORTS ON THIS ISSUE.MOST OF THOSE FAILURES WERE TRACED TO THE IMPROPER OPERATION OF THE STOP LAMP SWITCH THAT CONTROLS STOP LAMP ILLUMINATION.A MALFUNCTIONING STOP LAMP SWITCH CAN CAUSE THE VEHICLE'S BRAKE LIGHTS NOT TO LIGHT DURING BRAKING, OR ALTERNATIVELY, IT CAN CAUSE THE BRAKE LIGHTS TO STAY LIT EVEN WHEN A DRIVER TAKES THE FOOT OFF THE BRAKE PEDAL. FAILURE OF THE STOP LAMPS TO ILLUMINATE PROPERLY CREATES THE HAZARD OF REAR END COLLISIONS WHEN DRIVERS FOLLOWING THE SUBJECT VEHICLE DO NOT RECOGNIZE THAT THE VEHICLE IS SLOWING OR STOPPING. HYUNDAI REPORTED ONE CRASH INCIDENT (A FRONTAL IMPACT), WITHOUT INJURY, THAT WAS ALLEGED TO HAVE BEEN CAUSED BY THIS DEFECT.THE AGENCY REVIEWED THE INCIDENT AND CANNOT CONCLUDE THAT IT IS RELATED TO THIS DEFECT. THERE ARE OTHER POTENTIAL PROBLEMS RELATED TO FAILURE OF THE STOP LAMP SWITCH: FAILURE OF THE CRUISE CONTROL TO DISENGAGE, INTERFERENCE WITH PROPER FUNCTIONING OF ANTILOCK BRAKES AND ELECTRONIC STABILITY CONTROL, AND INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF PARK POSITION.BASED ON THE ABOVE SAFETY RECALL, THIS INVESTIGATION IS CLOSED.

The contact owns a 2007 Hyundai Azera. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. There ws no warning light illuminated. The contact stated that the steering wheel intermittently felt very loose, with a loud clunking noise, and unexpectedly jerked. The vehicle was taken to an independent mechanic but was not diagnosed or repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 140,000. The VIN was not available.

NHTSA ID

11709133

Incident

Jan 6, 2026

Mileage

140,000 mi

abs module failed affecting braking and electricals'. battery was drained. car was unsafe to drive

NHTSA ID

11579754

Incident

Feb 14, 2024

TL* THE CONTACT'S WIFE OWNS A 2007 HYUNDAI AZERA. THE CONTACT STATED THAT HE EXPERIENCED INTERMITTENT SOFTNESS WHILE DEPRESSING THE BRAKE PEDAL. THE ABS WARNING LIGHT WAS ILLUMINATED. UPON INVESTIGATION, THE CONTACT LINKED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 18V026000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE VIN WAS NOT INCLUDED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.

NHTSA ID

11413393

Incident

Mar 1, 2018

Mileage

200,000 mi

THE CARS LEAKING OIL INTO THE ALTERNATOR.THE OWNER BEFORE ME SAID THEY FIXED THE GASKET AND REPLACED THE ALTERNATOR TWICE.I BOUGHT IT 12/01/20 AND HAVENT DRIVEN IT DUE TO ITS COST TO FIX THE LEAK AND REPLACE THE ALTERNATOR. IF HE GAVE UP ON HIGHWAY GUARANTEE OF AN ACCIDENT. BACK DRIVER SIDE DOOR HANDLE FELL OFF. PASSENGER SIDE FRONT SEAT WON'T WORK

NHTSA ID

11388154

Incident

Dec 1, 2020

CHECK ENGINE LIGHT CAME ON ALONG WITH ESC OFF LIGHT SHOWING UP ON DASHBOARD. AT TIMES WHEN STARTING VEHICLE UP IN MORNING VEHICLE WOULD NOT ACCELERATE, I'VE PRESSED THE GAS PEDAL TO THE FLOOR AND NO ACCELERATION. SUNROOF WINDOW, BACK DRIVER WINDOW AND HEATED FRONT SEATS HAVE STOPPED WORKING AND MY AIRBAG LIGHTS STAY ON ?

NHTSA ID

11376156

Incident

Nov 18, 2020

Mileage

164,000 mi

I HAD THE RECALL 172 PERFORMED AT THE HYUNDAI DEALERSHIP ON 07/03/2020, AND 2 WEEKS LATER MY ABS MODULE FAILED ANYWAY DUE TO BRAKE FLUID LEAK INSIDE THE ABS MODULE AND HAD TO BE REPLACED. I CONTACTED HYUNDAI FOR REIMBURSEMENT AND WAS DENIED. OUT OF POCKET $500. WAS ALSO TOLD REPAIR WOULD BE $4000, BUT WAS THEN CHANGED TO $300.

NHTSA ID

11364295

Incident

Jul 25, 2020

Mileage

140,000 mi

TL* THE CONTACT OWNS A 2007 HYUNDAI AZERA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO TWO SEPARATE INDEPENDENT MECHANICS WHO INFORMED HIM THAT THE REAR SUSPENSION WAS COMPLETELY CORRODED. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 13V354000 (SUSPENSION) WHICH HE LINKED TO THE FAILURE. THE CONTACT CALLED THE MANUFACTURER WHO REFERRED HIM TO A HYUNDAI DEALER TO HAVE THE VEHICLE INSPECTED. THE CONTACT TOOK THE VEHICLE TO LYNNES NISSAN CITY (318 BLOOMFIELD AVE, BLOOMFIELD, NJ 07003) WHERE HE WAS INFORMED THAT THE RECALL REPAIR WAS PERFORMED BACK IN 2013. THE CONTACT WAS INFORMED THAT HE WOULD HAVE TO PAY A DIAGNOSTIC FEE TO HAVE THE VEHICLE INSPECTED. AFTER DISCOVERING THAT THE RECALL HAD ALREADY BEEN PERFORMED ON THE VEHICLE PRIOR TO HIM OWNING IT, THE CONTACT STATED THAT THE RECALL REMEDY WAS INEFFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 87,000.

NHTSA ID

11359779

Incident

Aug 1, 2020

Mileage

87,000 mi

TL* THE CONTACT OWNS A 2007 HYUNDAI AZERA. THE CONTACT STATED THAT WHILE DRIVING 15-20 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD CAUSING THE BRAKING DISTANCE TO BE EXTENDED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THE ABS MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED. THE VEHICLE THEN WAS TAKEN TO NOLLER HYUNDAI (2920 S. KANSAS AVENUE, TOPEKA, KS 66611) WHERE IT WAS DIAGNOSED FOR THE 2ND TIME AND DETERMINED THAT THE ABS MODULE FAILED AND NEEDED TO BE REPLACED. THE REPAIR WAS STILL PENDING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 18V026000 (SERVICE BRAKES, HYDRAULIC) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.

NHTSA ID

11353023

Incident

May 6, 2020

Mileage

140,000 mi

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.